Engine
2.3L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 80 of 110 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Engine & cooling
34 complaint records2 fire reports1 crash report
"DROVE VEHICLE APPROXIMATELY 30 MPH, THEN PARKED IN A PARKING GARAGE. CAME BACK, AND VEHICLE WAS ENGULFED IN FLAMES. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Electrical system
27 complaint records4 fire reports
"ELECTRICAL PROBLEM CAUSED FAILURE OF WIRING HARNESS/SPARK MODULE/MAIN COMPUTER/GROUND WIRES, RESULTING IN VEHICLE STALLING. *AW..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Brakes
22 complaint records1 crash report
"AFTER PUTTING THE VEHICLE INTO DRIVE, THE VEHICLE ACCELERATED AND WOULD NOT STOP WHEN APPLYING THE BRAKES, CAUSING AN ACCIDENT. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA96024 opened Sep 1996 | closed Apr 1997 | Engine And Engine Cooling | ENGINE COOLING FAN FIRES - led to recall 97V019000 There is no summary currently available |
| PE96033 opened May 1996 | closed Sep 1996 | Engine And Engine Cooling | ENGINE COOLING FAN FIRES - led to recall 97V019000 IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT... |
| PE96005 opened Jan 1996 | closed May 1996 | Service Brakes, Hydraulic | REAR BRK ADJUSTER FAILURE 1984 - 1991 FORD TEMPO/MERCURY TOPAZ |
| DP96002 opened Jan 1996 | closed Jan 1996 | Service Brakes, Hydraulic | REAR BRAKE SYSTEM FAILURE There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 96V071000 | Electrical System | THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1995212 1995-11-29 | Electrical | 834,368 | A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. |
| 1995197 1995-11-02 | Engine | 243,095 | EXTENDED HIGHWAY OPERATION DURING VERY LOW AMBIENT TEMPERATURES (-20 DEGREES CENTIGRADE OR BELOW) MAY RESULT IN ICE FORMING IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. |
| 1992077 1992-06-30 | Lights And Instruments | 464,543 | NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. |
| 1992011 1992-02-05 | Emissions | 107,040 | NOTE: TEMPO/TOPAZ WITH 2.3 LITRE ENGINE AND AEROSTAR WITH 3.0 LITRE ENGINE. THESE VEHICLES SO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 01156 Aug 2001 | Visibility | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| 01157 Aug 2001 | Unknown Or Other | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| 0015 Jan 2000 | Power Train | INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS | |
| 99222 Oct 1999 | Electrical System | SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT | |
| 99196 Sep 1999 | Equipment | INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
Show 34 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 99152 Jul 1999 | Power Train | INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT | |
| 99129 Jun 1999 | Fuel System | INFORMATION ON "WHINING" / "BUZZING" NOISE COMING THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER CAUSED BY THE FUEL PUMP. *TT | |
| 99816 May 1999 | Engine And Engine Cooling | FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT | |
| 98246 Dec 1998 | Electrical System | FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC | |
| 9888 Apr 1998 | Power Train | INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC | |
| 9852 Apr 1998 | Tires | INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC | |
| 9873 Apr 1998 | Equipment | EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT | |
| 9874 Apr 1998 | Engine And Engine Cooling | A NEW SILICONE GASKET AND SEALANT. *YC | |
| 9864 Mar 1998 | Engine And Engine Cooling | INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT | |
| 985A13 Mar 1998 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC | |
| 985A12 Mar 1998 | Equipment | RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT | |
| 9848 Mar 1998 | Equipment | ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC | |
| 9832 Feb 1998 | Structure | FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC | |
| 9815 Jan 1998 | Unknown Or Other | ISSUES CONCERNING THE MALFUNCTION OF THE INDICATOR LAMP. | |
| 97111097234 Nov 1997 | Electrical System | VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC | |
| 9768 Mar 1997 | Unknown Or Other | FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD | |
| 97610 Mar 1997 | Engine And Engine Cooling | BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD | |
| 97511 Mar 1997 | Power Train | FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD | |
| BC3143970220 Feb 1997 | Engine And Engine Cooling | REAR ENGINE MOUNT CONCERNS. *TW | |
| 962612 Dec 1996 | Power Train | TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW | |
| 96246 Nov 1996 | Electrical System | WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW | |
| 96249 Nov 1996 | Power Train | TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW | |
| 96221 Oct 1996 | Visibility | WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW | |
| ONP95B77 Dec 1995 | Engine And Engine Cooling | CERTAIN 1989 MODEL TEMPO & TOPAZ CARS EQUIPPED W/ 2.3L HSC ENGINES BUILT FROM 5/31/89 AT KANSAS CITY & 6/22/89 AT OAKVILLE THROUGH THE END OF THE 1989 MODEL YEAR AND ALL 1990 THROUGH 1994 TEMPO & TOPAZ CARS EQUIPPED WITH 2.3L HSC ENGINES THAT ARE CURRENTLY REGISTERED IN THE... | |
| 95212 Oct 1995 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. | |
| 95153 Jul 1995 | Engine And Engine Cooling | TEMPERATURE GAUGE - FLUCTUATING AND /OR INACCURATE HIGH READINGS. *SD | |
| BC2471950503 May 1995 | Visibility | BLOWER MOTOR CHIRP OR SQUEAK FROM BLOWER MOTOR AT LOW SPEEDS. *TW | |
| 9582 Apr 1995 | Visibility | A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW | |
| 9562 Mar 1995 | Service Brakes | ROUGHNESS CONCERN DURING BRAKE APPLICATION. *TW | |
| 9546 Feb 1995 | Visibility | REVISED WIPER MOTOR. *TW | |
| 9515 Jan 1995 | Power Train | DELAYED AND/OR INTERMITTENT NO UPSHIFT OF 1-2 GEAR. *TW | |
| BC0391941201 Dec 1994 | Vehicle Speed Control | THE TV PLUNGER VALVE POSITION MAY BE INCORRECT CAUSING VEHICLES TO HAVE AN INTERMITTENT NO 1-2 UPSHIFT PROBLEM OR COLD/HARD ACCELERATOR PEDAL EFFORT. *TW | |
| BC8774941201 Dec 1994 | Power Train | NEW REVISED CLUTCH SEALS TO CORRECT A NO REVERSE IN EXTREME COLD WEATHER CONDITIONS. *TW | |
| 94248 Nov 1994 | Power Train | VEHICLES MAY EXHIBIT THE LACK OF REVERSE IN EXTREME COLD CONDITIONS. *TW |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford Tempo →