Engine
4.9L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 365 of 470 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 48 of 470 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Fuel system
258 complaint records5 fire reports
"RECALL WORK PERFORMED FOR THE DUAL TANK FUEL DELIVERY MODULE PRESSURE REGULATOR, HOWEVER FAILED RESULTING IN GAS LEAKAGE...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Electrical system
58 complaint records30 fire reports2 crash reports
"I DID NOT KNOW THIS WAS A PROBLEM WITH THOUSANDS OF FORDS UNTIL THE NEWS REPORTS. THIS HAS ALWAYS BEEN A SAFETY ISSUE FOR US...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Engine & cooling
39 complaint records6 fire reports
"OIL PAN IS RUSTING, AND THERE IS OIL LEAKING FROM VEHICLE. CONTACTED DEALER, AND DEALER IS NOT WILLING TO DO ANYTHING.*AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA99032 opened Nov 1999 | closed Dec 2001 | Vehicle Speed Control | DUAL FUEL TANK CROSSFLOW/LEAKAGE - led to recall 01I008000 ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A... |
| RQ98008 opened May 1998 | closed Nov 1999 | Fuel System, Gasoline | FORD F-SERIES DUAL FUEL TANK LEAKAGE - led to recall 93V125000 THESE VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO A MALFUNCTIONING FUEL PUMP.FROM THE INFORMATION GATHERED TO DATE, IT APPEARS THAT THERE CAN BE MULTIPLE CAUSES AND/OR A COMBINATION OF CAUSES FOR FUEL CROSS FLOW AND THAT THE RECALL... |
| EA93022 opened Jul 1993 | closed Aug 1994 | Engine And Engine Cooling | IDLE AIR SPD CTRL VLV MALF There is no summary currently available |
| EA93020 opened Jul 1993 | closed Sep 1994 | Service Brakes, Hydraulic | PARKING BRAKE FAILURE - led to recall 94V169002 There is no summary currently available |
| PE93015 opened Mar 1993 | closed Jul 1993 | Service Brakes, Hydraulic | PARKING BRAKE FAILURE There is no summary currently available |
Show 3 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE93010 opened Mar 1993 | closed Jul 1993 | Engine And Engine Cooling | IDLE AIR SPD CTRL VLV MALF There is no summary currently available |
| EA93001 opened Jan 1993 | closed Aug 1993 | Vehicle Speed Control | FUEL EXPULSION - led to recall 93V125000 There is no summary currently available |
| PE92077 opened Sep 1992 | closed Jan 1993 | Vehicle Speed Control | FUEL EXPULSION There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 94V169001 | Parking Brake | THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET. | Normally free |
| 93V125000 | Fuel System, Gasoline | A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. | Normally free |
| 92V006000 | Structure | WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1992119 1992-09-29 | Other | 5,261 | IN VEHICLES EQUIPPED WITH 7.3 LITRE DIESEL ENGINES, THE SOUND INSULATOR ON THE OUTSIDE OF THE DASH PANEL MAY CONTACT THE EXHAUST MANIFOLD RESULTING IN THERMAL DEGRADATION OF THE INSULATOR AND POSSIBLE IGNITION OF THE INSULATOR RESULTING IN... |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 03148 Jul 2003 | Power Train | NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| 01156 Aug 2001 | Visibility | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| 01157 Aug 2001 | Unknown Or Other | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| 002310 Nov 2000 | Power Train | SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT | |
| 98167 Apr 2000 | Power Train | TRANSMISSION-E40D-NO 2-3 UPSHIFT. SOME VEHICLES MAY EXHIBIT A NO 2-3 UPSHIFT CONDITION. *AK |
Show 53 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 98168 Apr 2000 | Power Train | TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD | |
| 0038 Feb 2000 | Power Train | VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS | |
| 0011 Jan 2000 | Parking Brake | VEHICLES MAY EXPERIENCE PARKING BRAKE PEDAL WHICH GOES TO THE FLOOR WITH MINIMAL EFFORT- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/94. | |
| 0012 Jan 2000 | Parking Brake | INFORMATION REGARDING PARKING BRAKE CONTROL ASSEMBLY CONCERNS- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS | |
| 0013 Jan 2000 | Parking Brake | PROCEDURE FOR SERVICING PARKING BRAKE- SERVICE TIP- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS | |
| 0015 Jan 2000 | Power Train | INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS | |
| 99222 Oct 1999 | Electrical System | SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT | |
| 99196 Sep 1999 | Equipment | INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT | |
| 99129 Jun 1999 | Equipment | EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT | |
| 12905 Jun 1999 | Power Train | SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT | |
| 99816 May 1999 | Engine And Engine Cooling | FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT | |
| 98246 Dec 1998 | Electrical System | FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC | |
| 9888 Apr 1998 | Power Train | INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC | |
| 9852 Apr 1998 | Tires | INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC | |
| 9864 Mar 1998 | Engine And Engine Cooling | INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT | |
| 985A13 Mar 1998 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC | |
| 985A37 Mar 1998 | Service Brakes | THE PARKING BRAKE PEDAL MAY GO TO THE FOOR WITH LITTLE OR NO EFFORT DURING APPLICATION. *YC | |
| 985A12 Mar 1998 | Equipment | RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT | |
| 985A46 Mar 1998 | Suspension | SOME VEHICLES MAY EXHIBIT A DRIFT OR PULL TO THE LEFT WHILE BRAKING. *TT | |
| 9848 Mar 1998 | Equipment | ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC | |
| 98419 Mar 1998 | Unknown Or Other | SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC | |
| 983074 Feb 1998 | Power Train | CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT | |
| 98122 Jan 1998 | Visibility | PERFORMANCE ENHANCEMENT FOR DEFROSTER. *TT | |
| 98123 Jan 1998 | Power Train | SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT | |
| 9778 Mar 1997 | Exterior Lighting | HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD | |
| 9768 Mar 1997 | Unknown Or Other | FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD | |
| 97511 Mar 1997 | Power Train | FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD | |
| 9747 Feb 1997 | Structure | FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD | |
| 9748 Feb 1997 | Engine And Engine Cooling | ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE. *JD | |
| BC3287970206 Feb 1997 | Power Train | THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW | |
| 97310 Feb 1997 | Suspension | NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD | |
| 962612 Dec 1996 | Power Train | TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW | |
| 96246 Nov 1996 | Electrical System | WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW | |
| 96249 Nov 1996 | Power Train | TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW | |
| BC0678961025 Oct 1996 | Power Train | INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT | |
| 96221 Oct 1996 | Visibility | WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW | |
| 96728 Mar 1996 | Power Train | SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE. *TT | |
| BC0131960102 Dec 1995 | Power Train | 4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES. | |
| 95212 Oct 1995 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. | |
| 951713 Aug 1995 | Electrical System | GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95. *SD | |
| BC4321950705 Jul 1995 | Power Train | VEHICLES EXPERIENCING OCCASIONAL HARSH REVERSE ENGAGEMENT CONCERNS. *TW | |
| 951515 Jul 1995 | Steering | STEERING GEAR-REPLACEMENT OF BENDIX, STEERING GEAR WITH NEW ROSS STEEERING GEAR. *SD | |
| 951112 Jun 1995 | Power Train | REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW | |
| 951113 Jun 1995 | Power Train | DELAYED FORWARD ENGAGEMENT AND/OR HEAT STAINED FORWARD CLUTCH PLATES AFTER INSTALLING CENTER SUPPORT SERVICE. *TW | |
| 9597 May 1995 | Suspension | UNKNOWN | |
| 95912 May 1995 | Electrical System | UNKNOWN | |
| 951015 May 1995 | Engine And Engine Cooling | HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER. *TW | |
| 9585 Apr 1995 | Seats | A RATTLE FROM THE SPLIT SEAT BENCH MAY BE DUE TO A LOOSE OR MISSING SEAT BUSHING. *TW | |
| 9588 Apr 1995 | Engine And Engine Cooling | KNOCKING NOISE ON INITIAL START-UP. *TW | |
| BC4178950401 Apr 1995 | Engine And Engine Cooling | UNKNOWN | |
| 95521 Mar 1995 | Electrical System | UNDER HOOD WIRE HARNESS MAY BECOME CHAFED. *TW | |
| 9568 Mar 1995 | Engine And Engine Cooling | REVISED OIL PAN GASKET. *TW | |
| 95619 Mar 1995 | Power Train | NEW DESIGN TRANSMISSION RANGE SENSOR. *TW |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford F-150 →