Engine
3.8L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 74 of 92 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Lighting
28 complaint records
"AN ELECTRICALSHORT IN THE HEADLIGHT SWITCH, CAUSED WIRES IN THE DASH AREA TO BURN AND LIGHT TO GO OUT WHILE DRIVING. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse lighting parts in the directory →
Engine & cooling
21 complaint records1 fire report
"HEAD GASKETS LEAKAGE WATER INTO CYLINDER, CAUSING PROBLEMS TO ENGINE PROFORMANCE-STALLING, DECREASED EXCELERATION, ETC. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Brakes
12 complaint records
"THE CAR ABS. THE SYSTEM FAILED TO STOP THE CAR AND WENT THROUGH AN INTERSECTION AND ALMOST HIT ANOTHER CAR. PLEASE DESCRIBE. TT..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA99005 opened Jan 1999 | closed Dec 1999 | Exterior Lighting | HEADLIGHT SWITCH - led to recall 99V275000 SUBJECT VEHICLES HAVE A HEADLIGHT SWITCH WITH AN INTERNAL, BIMETAL CIRCUIT BREAKER THAT CAN OPEN DUE TO OVERHEATING DURING HEADLING OPERATION. |
| RQ97011 opened Sep 1997 | closed Nov 1998 | Fuel System, Gasoline | FUEL LINE JUMPER - led to recall 97V159000 TO DETERMINE THE SCOPE OF THE ALLEGED FUEL LINE FAILURES OUTSIDE OF THE RECALL GEOGRAPHIC REGION AND IF THE RECALL SHOULD BE EXPANDED NATIONALLY |
| EA95030 opened Oct 1995 | closed Sep 1997 | Vehicle Speed Control | REAR FUEL LINE INTERFERENCE - led to recall 97V159000 THE REAR FUEL TUBE BUNDLE MAY ABRADE AND FAIL IN THE VICINITY OF THE FUEL TANK. |
| PE93075 opened Aug 1993 | closed Dec 1993 | Vehicle Speed Control | THRTTL VLV LINKAGE BUSHING There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 99V275000 | Exterior Lighting | VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING. | Normally free |
| 97V159000 | Fuel System, Gasoline | VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN,... | Normally free |
| 96V071000 | Electrical System | THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1999193 1999-10-29 | Electrical | 4,154 | On certain vehicles, the high electrical current flowing through the headlamp switch during simultaneous operation of the headlamps and fog lamps may cause the switches internal bimetal circuit breaker to open due to overheating. |
| 1997193 1997-11-10 | Fuel System | 9,271 | MOVEMENT OF FUEL LINES, RESULTING FROM NORMAL VEHICLE BODY VIBRATIONS. CAUSES THE NYLON FUEL LINES TO WEAR BY RUBBING AGAINST THE METAL FLOOR PAN. |
| 1995212 1995-11-29 | Electrical | 834,368 | A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 03148 Jul 2003 | Power Train | NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| 02208 Oct 2002 | Equipment | CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| 02176 Sep 2002 | Exterior Lighting | LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| 0214 Jan 2002 | Engine And Engine Cooling | SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| 01181 Sep 2001 | Power Train | BRAKE SHIFT INTERLOCK.*JB |
Show 41 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 01156 Aug 2001 | Visibility | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| 01157 Aug 2001 | Unknown Or Other | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| 002310 Nov 2000 | Power Train | SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT | |
| 00213 Oct 2000 | Equipment | SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB | |
| 0015 Jan 2000 | Power Train | INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS | |
| 99222 Oct 1999 | Electrical System | SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT | |
| 99196 Sep 1999 | Equipment | INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT | |
| 99152 Jul 1999 | Power Train | INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT | |
| 99139 Jun 1999 | Exterior Lighting | CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT | |
| 99129 Jun 1999 | Equipment | EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT | |
| 99816 May 1999 | Engine And Engine Cooling | FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT | |
| 5244 Dec 1998 | Exterior Lighting | SOME VEHICLES MAY REQUIRE HEADLAMP SWITCH (11654) REPLACEMENT DURING A NORMAL SERVICE VISIT. ENGINEERING IS INVESTIGATING. *TT | |
| 12199 Dec 1998 | Exterior Lighting | SOME VEHICLES MAY REQUIRE HEADLAMP SWITCH (11654) REPLACEMENT DURING A NORMAL SERVICE VISIT. *TT | |
| 982310 Nov 1998 | Engine And Engine Cooling | MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK | |
| 9852 Apr 1998 | Tires | INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC | |
| 9874 Apr 1998 | Engine And Engine Cooling | A NEW SILICONE GASKET AND SEALANT. *YC | |
| 9864 Mar 1998 | Engine And Engine Cooling | INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT | |
| 985A13 Mar 1998 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC | |
| 9848 Mar 1998 | Equipment | ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC | |
| 97111097234 Nov 1997 | Electrical System | VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC | |
| 9768 Mar 1997 | Unknown Or Other | FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD | |
| 97610 Mar 1997 | Engine And Engine Cooling | BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD | |
| 97511 Mar 1997 | Power Train | FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD | |
| 962612 Dec 1996 | Power Train | TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW | |
| 96246 Nov 1996 | Electrical System | WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW | |
| 96249 Nov 1996 | Power Train | TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW | |
| BC0678961025 Oct 1996 | Power Train | INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT | |
| 96221 Oct 1996 | Visibility | WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW | |
| 96225 Oct 1996 | Fuel System | MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW | |
| 96226 Oct 1996 | Equipment | AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW | |
| 95212 Oct 1995 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. | |
| 95153 Jul 1995 | Engine And Engine Cooling | TEMPERATURE GAUGE - FLUCTUATING AND /OR INACCURATE HIGH READINGS. *SD | |
| BC2850950401 Apr 1995 | Power Train | TORQUE CONVERTER CLUTCH SHUDDER/VIBRATION. *TW | |
| 9582 Apr 1995 | Visibility | A REVISED SERVICE WINDSHIELD WIPER MOTOR IS NOW AVAILABLE. *TW | |
| BC8899950401 Apr 1995 | Service Brakes | UNKNOWN | |
| 9562 Mar 1995 | Service Brakes | ROUGHNESS CONCERN DURING BRAKE APPLICATION. *TW | |
| 9568 Mar 1995 | Engine And Engine Cooling | REVISED OIL PAN GASKET. *TW | |
| 95310 Feb 1995 | Engine And Engine Cooling | NEW TORQUE-TO-YIELD CYLINDER HEAD BOLT KIT. *TW | |
| 9546 Feb 1995 | Visibility | REVISED WIPER MOTOR. *TW | |
| 94263 Dec 1994 | Electrical System | SOME VEHICLES MAY EXHIBIT A NO-CRANK CONDITION DUE TO CORROSION AT THE STARTER SOLENOID CONNECTOR. *TW | |
| 94224 Oct 1994 | Fuel System | MOANING OR HOOTING NOISE COMING FROM THE ENGINE COMPARTMENT MAY BE COMING FROM THE IDLE AIR BYPASS VALVE. *TW |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Do a full walk-around with every light on.Condensation inside a lens, a dim side, or a flickering tail light match this vehicle's lighting cluster.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Mercury Cougar →