Engine
4.3L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 166 of 233 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Brakes
151 complaint records2 fire reports28 crash reports
"WHEN APPLYING THE ABS BRAKES AT SPEED OF10- 25 MPH DURING WET CONDITIONS THE VEHICLE'S RIGHT FRONT BRAKES LOCKED UP. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Fuel system
22 complaint records3 fire reports
"APPARENTLY SAND WAS TRAPPED AROUND THE AREA OF THE TANK SHIELD FROM DRIVING ON OFF ROAD CONDITION, REUSULTING IN RUSTING OUT THE TANK...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Engine & cooling
19 complaint records2 fire reports
"CONSUMER SON WAS DRIVING TRUCK CAUGHT ON FIRE TRUCK WAS TOTALED . TT IT WAS BELIEVED THAT THE EXHAUST SYSTEM STARTED THE FIRE. *YH..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA99018 opened Jun 1999 | closed Oct 2000 | Equipment | SPARE TIRE SEPARATION FROM VEHICLE |
| PE99004 opened Jan 1999 | closed Jun 1999 | Equipment | SEPARATION OF SPARE TIRE FROM VEHICLE ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION |
| EA94038 opened Oct 1994 | closed Feb 2000 | Service Brakes, Hydraulic | ABS BRAKING SYSTEM - led to recall 99V193000 THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006. |
| EA94029 opened Jul 1994 | closed Jul 1996 | Engine And Engine Cooling | ENGINE COMPARTMENT FIRES AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES. |
| PE94046 opened Jun 1994 | closed Oct 1994 | Service Brakes, Hydraulic | ABS BRAKING SYSTEM FAILS There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 99V193000 | Service Brakes, Hydraulic | VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. | Normally free |
| 96V195000 | Steering | THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE... | Normally free |
| 93V105000 | Seat Belts | THE OUTBOARD REAR SAFETY BELT ASSEMBLY WILL NOT RELEASE THE WEBBING FROM THE RETRACTED POSITION. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS 209, "SEAT BELT ASSEMBLIES." | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1999135 1999-07-26 | Brakes | 72,445 | Certain four wheel drive vehicles may experience increased stopping distances during ABS stops while in the two-wheel drive mode. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 020730024A Aug 2005 | Power Train | DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT | |
| 990730016A Oct 2002 | Power Train | DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT | |
| GM161514 Apr 1995 | Latches/Locks/Linkages | END GATE LATCH RATTLE (INSTALL REVISED STRIKER). *TW | |
| GM561204 Apr 1995 | Structure | WATER LEAK AT THE A/C RECIRCULATION DOOR (INSTALL NEW HOOD HINGE SEAL). *TW | |
| 376105 Feb 1995 | Engine And Engine Cooling | COLD ENGINE KNOCK. *TW |
Show 5 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 476149 Dec 1994 | Unknown Or Other | OIL PRESSURE GAUGE READING CONCERNS. *TW | |
| 94269 Dec 1994 | Power Train | LETTER ANNOUNCING THE RE-ISSUE OF PRODUCT CAMPAIGN 93-C-52. *TW | |
| 01423 Dec 1994 | Power Train | 95-C-52 CAMPAIGN BULLETIN. *TW | |
| 461602A Sep 1994 | Seats | REAR SEAT RATTLES/LOOSENESS (INSTALL REAR SEAT LATCH). *TW | |
| 9310A343 Feb 1993 | Visibility | FRONT DOOR SIDE GLASS BINDING/TRACK DISENGAGEMENT. *TW |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Chevrolet S10 →