Engine
3.9L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 97 of 116 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Electrical system
24 complaint records5 fire reports2 crash reports
"VEHICLE EXPERIENCED FAILURE OF THE RECALL COMPONENT (00V-135) IGNITION SWITCH PRIOR TO RECALL NOTIFICATION, CONSUMER REQUESTING REIMBURSEMENT. *MJS..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Suspension
19 complaint records
"WHEN DRIVING 30 MPH OR MORE FRONT END VIBRATED. VEHICLE WAS TAKEN TO TA REPAIR SHOP ON TWO OCCASIONS, BUT PROBLEM RECURRED. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse suspension parts in the directory →
Steering
18 complaint records1 fire report3 crash reports
"WHEN TURNING STEERING WHEEL THERE IS A POPPING SOUND. *AK THE PROBLEM SEEMS TO OCCUR AT A POINT WHERE STEERING SHAFT COMES THROUGH FIRE WALL. *YH..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse steering parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP03006 opened Sep 2003 | closed Apr 2004 | Seats | SEAT BACK FAILURE ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS... |
| DP03002 opened May 2003 | closed Jul 2003 | Steering | STEERING COLUMN SEPARATION MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED... |
| EA98010 opened May 1998 | closed Dec 1999 | Exterior Lighting | HEADLIGHT CIRCUIT - led to recall 99V024000 THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES... |
| PE96022 opened Mar 1996 | closed Jul 1996 | Steering | ALLEGED FAILURE OF STEERING PITMAN SHAFT STEERING BOX OUTPUT (PITMAN) SHAFT BREAKAGE RESULTING IN LOSS OF CONTROL. |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2001052 2001-03-08 | Engine | 18,025 | On certain diesel pickup trucks, the throttle cable can unravel (fray) or break, which could result in loss of throttle control and loss of power. |
| 2001055 2001-03-08 | Structure | 73,167 | On certain pickup trucks located in Ontario, Quebec and the Maritime provinces, corrosion of the hood secondary latch return spring may cause the hood secondary latch to become inoperative, possibly allowing the hood to open unexpectedly... |
| 2000144 2000-06-30 | Electrical | 54,601 | Certain pickup trucks were built with an ignition switch and wiring that may overheat under certain operating conditions. |
| 1999158 1999-08-27 | Suspension | 8,630 | On certain pickup trucks equipped with a diesel or V-10 engine, the front suspension spring/shock towers may crack and eventually separate from the vehicle frame. |
| 1999132 1999-06-28 | Structure | 687 | On certain 4 x 4 pickups equipped with an 8.0 litre V10 engine, Under certain heavy duty applications, such as driving up a steep grade in four wheel drive with a full load, the local exhaust temperature proximate to the hydraulic clutch... |
Show 15 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1999027 1999-02-23 | Electrical | 6,176 | On certain Ram 3500 vehicles, the headlamp switches used in this truck series operate under a high current load which results in switch internal temperatures above the 100 degree centigrade limit for the internal lubing grease. |
| 1998123 1998-06-17 | Emissions | 46,147 | Certain vehicles may not comply with CMVSS 1105 - evaporative emissions. The evaporative canister may allow migration of its contents (charcoal) through the purge system and into the engine. |
| 1997206 1997-11-20 | Fuel System | 34,694 | On certain vehicles, the fuel tank mounted rollover valve may allow liquid fuel to leak onto the ground under certain conditions. In the presence of an ignition source, a fire could occur. |
| 1997178 1997-10-16 | Emissions | 4 | Certain vehicles do not comply with CMVSS 1103 - exhaust emissions. The elbow containing the crankcase ventilation orifice was installed on the wrong valve cover resulting in improper metering of crankcase gases being returned to the... |
| 1997096 1997-05-07 | Powertrain | 50,846 | On certain vehicles, the transmission fluid temperature could exceed the melting point of the connector which retains the fluid line to the transmission. |
| 1996187 1996-11-20 | Steering | 36,575 | On certain vehicles, the plastic pins and metal clip that retain the steering column lower shaft could break, causing the lower shaft to separate from the upper shaft. |
| 1995108 1995-06-19 | Steering | 25,215 | On certain vehicles, the operator's key ring keys may bind on the steering wheel back cover while turning and hamper steering wheel return. This could adversely affect steering control and result in a possible crash. |
| 1995063 1995-04-07 | Structure | 15,564 | On certain vehicles, the secondary hood latch rod may bind on the guide bracket and prevent secondary latch engagement. If this condition occurs simultaneously with a not engaged primary latch, the hood may not be properly restrained. |
| 1995009 1995-01-31 | Seats And Restraints | 15,666 | Certain vehicles do not comply with CMVSS 208 - Seatbelt installations. Under severe collision conditions, the passenger side seat belt may may release as the result of shattering and displacement of the latch plate cinch bar. |
| 1994156 1994-10-26 | Suspension | 295 | On certain Ram 3500 vehicles, the front suspension track bar bracket attachment may have inadequate fatigue strength which may result in long range durability failure if the truck is operated at or near its maximum gross vehicle weight. |
| 1994133 1994-08-24 | Steering | 25,212 | On certain vehicles, the extra keys operator's key ring may become temporarily lodged in the airbag screw access holes on the steering wheel back cover, hampering steering wheel return. |
| 1994119 1994-07-26 | Fuel System | 145 | THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 301 - FUEL SYSTEM INTEGRITY. A ROUTINE REAR IMPACT COMPLIANCE TEST RESULTED IN FUEL LEAKAGE DURING ROLLOVER STAGE IN EXCESS OF THAT ALLOWED BY THE STANDARD. |
| 1994104 1994-06-03 | Suspension | 44 | On certain vehicles, the front suspension track bar may have inadequate fatigue strength and may eventually fail. This could result in front axle vibration and the potential for directional control difficulty. |
| 1994009 1994-01-17 | Seats And Restraints | 2,881 | THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 207 - ANCHORAGE OF SEATS. SEAT BACK LATCH LEVER COULD BIND DUE TO DISTORTION OF THE RIVET FOR THE LATCH LEVER PIVOT. CORRECTION: SEAT BACK LATCH ASSEMBLY WILL BE REPLACED WITH A REVISED ASSEMBLY. |
| 1993149 1993-11-05 | Suspension | 959 | ON RAM 4X4 VEHICLES, THE FRONT SUSPENSION TRACK BAR ATTACHMENT TO THE AXLE MAY BECOME LOOSE. LOSS OF THE ATTACHMENT MAY RESULT IN FRONT AXLE VIBRATION WITH THE POSSIBILITY OF REDUCED STEERING CONTROL. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| R2118796A Feb 2016 | Engine And Engine Cooling | Valve Body. These may cause over drive cycling. | |
| 9002849 Sep 2014 | Structure | Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. | |
| 9002688 Feb 2013 | Equipment | 68069384A$, R8069384A$, 68086182A$, R8027067A$, RL002012A$ - Gasket, Cylinder Head Cover Before replacing injectors for Diagnostic Trouble Codes P0201, P0202, P0203, P0204, P0205, and/or P0206, please make sure that the wiring loom and/or connector in the valve cover gasket is... |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Find the roughest road nearby.Clunks over bumps, a droning hum that changes when the car leans, or a corner that sits low are this vehicle's suspension complaints. Wheel bearings and control arm bushings lead the parts list.
- Drive one straight highway stretch and one slow parking lot.Wander or a shimmy over bumps at speed, and heavy or dropped assist at low speed, are the two faces of this vehicle's steering cluster. A clunk on turn-in points at the linkage.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Dodge Ram 1500 →