Engine
4.9L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 545 of 676 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 131 of 676 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Brakes
179 complaint records3 fire reports10 crash reports
"THE FRONT DISC BRAKES PULL TO THE RIGHT WHEN APPLIED CAUSING SLIGHT LOSS OF CONTROL OF THE VEHICLE. PLEASE DESCRIBE. TT..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Fuel system
120 complaint records2 fire reports1 crash report
"THERE IS A STRONG SMELL OF FUEL COMING FROM THE VEHICLE . ALSO, VEHICLE IS LEAKING FUEL. PLEASE PROVIDE MORE INFORMATION. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Air bags
101 complaint records50 crash reports
"WHILE IN VEHICLE NOTICED AIR BAG INDICATOR ON AT ALL TIME. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse air bags parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA05005 opened Mar 2005 | closed Aug 2006 | Vehicle Speed Control | ENGINE COMPARTMENT FIRES - led to recall 08V025000 EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A... |
| RQ98006 opened Mar 1998 | closed Aug 2000 | Air Bags | INADVERTENT AIR BAG DEPLOYMENT - led to recall 93V155000 There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 05V388000 | Vehicle Speed Control | ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN. | Normally free |
| 96V064000 | Seats | THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. | Normally free |
| 94V169001 | Parking Brake | THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET. | Normally free |
| 94V018000 | Structure | THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE. | Normally free |
| 93V184000 | Air Bags | THESE VEHICLES WERE BUILT WITH NONFUNCTIONAL AIR BAG DIAGNOSTIC MODULES INTENDED FOR CERTAIN VEHICLES OVER 8,500 BLS. GVWR. | Normally free |
| 93V155000 | Air Bags | THE DESIGN OF THE AIR BAG DIAGNOSTIC MONITOR CAUSES THE DRIVER'S SIDE AIR BAG TO DEPLOY WHEN THE PASSENGER DOOR IS SLAMMED WHILE THE IGNITION KEY IS TURNED TO THE START POSITION. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2005028 2005-02-14 | Electrical | 304,417 | On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 03148 Jul 2003 | Power Train | NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| 02176 Sep 2002 | Exterior Lighting | LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| 01194 Oct 2001 | Electrical System | THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT | |
| 01181 Sep 2001 | Power Train | BRAKE SHIFT INTERLOCK.*JB | |
| 01156 Aug 2001 | Visibility | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 01157 Aug 2001 | Unknown Or Other | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| 00239 Nov 2000 | Electrical System | A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT | |
| 002310 Nov 2000 | Power Train | SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT | |
| 98167 Apr 2000 | Power Train | TRANSMISSION-E40D-NO 2-3 UPSHIFT. SOME VEHICLES MAY EXHIBIT A NO 2-3 UPSHIFT CONDITION. *AK | |
| 98168 Apr 2000 | Power Train | TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD | |
| 0038 Feb 2000 | Power Train | VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS | |
| 0011 Jan 2000 | Parking Brake | VEHICLES MAY EXPERIENCE PARKING BRAKE PEDAL WHICH GOES TO THE FLOOR WITH MINIMAL EFFORT- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/94. | |
| 0012 Jan 2000 | Parking Brake | INFORMATION REGARDING PARKING BRAKE CONTROL ASSEMBLY CONCERNS- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS | |
| 0013 Jan 2000 | Parking Brake | PROCEDURE FOR SERVICING PARKING BRAKE- SERVICE TIP- BRONCO AND F-SERIES BUILT THROUGH 4/22/1994 AND EXPLORER/RANGER BUILT THROUGH 5/13/1994. *MJS | |
| 0015 Jan 2000 | Power Train | INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS | |
| 99222 Oct 1999 | Electrical System | SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT | |
| 99194 Sep 1999 | Service Brakes | INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT | |
| 99196 Sep 1999 | Equipment | INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT | |
| 99139 Jun 1999 | Exterior Lighting | CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT | |
| 99129 Jun 1999 | Equipment | EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT | |
| 12905 Jun 1999 | Power Train | SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT | |
| 9996 May 1999 | Power Train | EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT | |
| 99816 May 1999 | Engine And Engine Cooling | FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT | |
| 99-8-15 May 1999 | Structure | SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT | |
| 98246 Dec 1998 | Electrical System | FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC | |
| 982010 Oct 1998 | Engine And Engine Cooling | EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC | |
| 9888 Apr 1998 | Power Train | INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC | |
| 9852 Apr 1998 | Tires | INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC | |
| 9864 Mar 1998 | Engine And Engine Cooling | INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT | |
| 985A5 Mar 1998 | Service Brakes | HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC | |
| 985A11 Mar 1998 | Service Brakes | SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC | |
| 985A13 Mar 1998 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC | |
| 985A37 Mar 1998 | Service Brakes | THE PARKING BRAKE PEDAL MAY GO TO THE FOOR WITH LITTLE OR NO EFFORT DURING APPLICATION. *YC | |
| 985A39 Mar 1998 | Service Brakes | A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN RESOLVING BRAKE PULL OR DRIFT CONCERNS. *AK | |
| 985A40 Mar 1998 | Service Brakes | A SHUDDER / VIBRATION AND / OR SQUEALING HEARD WHILE BRAKING - REVISED FRONT BRAKE LINING. *TT | |
| 985A12 Mar 1998 | Equipment | RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT | |
| 985A41 Mar 1998 | Service Brakes | SUBJECT REGARDING ON-VEHICLE CALIPER-MOUNT LATHE MACHINING SETUP PROCEDURES. *TT | |
| 985A46 Mar 1998 | Suspension | SOME VEHICLES MAY EXHIBIT A DRIFT OR PULL TO THE LEFT WHILE BRAKING. *TT | |
| 9845 Mar 1998 | Service Brakes | AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC | |
| 98419 Mar 1998 | Unknown Or Other | SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC | |
| 983074 Feb 1998 | Power Train | CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT | |
| 9814 Jan 1998 | Service Brakes | SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT | |
| 98122 Jan 1998 | Visibility | PERFORMANCE ENHANCEMENT FOR DEFROSTER. *TT | |
| 98123 Jan 1998 | Power Train | SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT | |
| 97050110621 May 1997 | Child Seat | PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW | |
| BC2301970501 May 1997 | Power Train | NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW | |
| 9778 Mar 1997 | Exterior Lighting | HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD | |
| 9768 Mar 1997 | Unknown Or Other | FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD | |
| 97511 Mar 1997 | Power Train | FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD | |
| 9747 Feb 1997 | Structure | FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD | |
| 9748 Feb 1997 | Engine And Engine Cooling | ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE. *JD | |
| BC3287970206 Feb 1997 | Power Train | THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW | |
| 97310 Feb 1997 | Suspension | NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD | |
| BC0326972301 Jan 1997 | Air Bags | AIR BAG LAMP FLASH-OUT CODE 33 ON VEHICLES EQUIPED WITH A PASSENGER SIDE AIR BAG. *JD | |
| 962612 Dec 1996 | Power Train | TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW | |
| 962511 Dec 1996 | Electrical System | POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW | |
| BC0326961129 Nov 1996 | Air Bags | WHEN DIAGNOSING AN AIR BAG LAMP FLASH-OUT CODE 33 (PASSENGER SIDE AIR BAG HIGH RESISTANCE OR OPEN) ON A 1994-1996 F150 OR BRONCO THAT IS NOT EQUIPPED WITH A PASSENGER SIDE AIR BAG, CHECK FOR PROPER GROUND FROM PIN 7, CIRCUIT 629, AT THE AIR BAG DIAGNOSTIC MONITOR CONNECTOR C218,... | |
| 96246 Nov 1996 | Electrical System | WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW | |
| 96249 Nov 1996 | Power Train | TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW | |
| 962415 Nov 1996 | Power Train | VIBRATION - DRIVELINE VIBRATION AND/OR DRIVELINE NOISE - REGULAR CAB 4X4 VEHICLES EQUIPPED WITH 7.5L ENGINE AND MANUAL TRANSMISSION. *TW |
Showing 60 of 91 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Watch the airbag warning light through a full key cycle.It should light on start and go out within seconds. A light that stays on, or never lights at all, means the system needs attention. Run the VIN for inflator recalls specifically.
- Run the VIN against open recalls before you negotiate.This vehicle has 6 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford F-150 →