Engine
5.7L 8-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 201 of 246 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Seats
78 complaint records2 fire reports
"CONSUMER STATED THAT HE WAS REAR ENDED WHILE HE STOPPED ON THE TRAFFIC LIGHT AND THE DRIVERS SEAT MOUNTINGS FAILED. *YD..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse seats parts in the directory →
Brakes
55 complaint records8 crash reports
"WHEN BRAKES ARE APPLIED THE PEDAL GOES TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE. THE DEALER HAS NOT BEEN NOTIFIED. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Electrical system
37 complaint records3 fire reports
"BATTERY LEAKED, CAUSING ACID TO DESTROY PAN AND BOLT THAT HOLDS BATTERY IN PLACE AND DESTROY WIRING AND FINISH BELOW BATTERY . *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA02006 opened May 2002 | closed Jul 2003 | Visibility | WINDSHIELD WIPER FAILURE - led to recall 03V210000 AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L... |
| EA01019 opened Dec 2001 | closed Sep 2002 | Seats | FRONT SEAT RECLINER BOLT There is no summary currently available |
| PE01023 opened Jul 2001 | closed Dec 2001 | Seat Belts | SEAT BELT ANCHORAGE SEPARATION ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER... |
| EA00024 opened Sep 2000 | closed Dec 2001 | Exterior Lighting | HEADLIGHT |
| EA00013 opened May 2000 | closed Jun 2002 | Electrical System | BATTERY LEAKS ACID There is no summary currently available |
Show 3 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE00017 opened Apr 2000 | closed Sep 2000 | Exterior Lighting | HEADLIGHT BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING... |
| PE99073 opened Dec 1999 | closed May 2000 | Electrical System | BATTERY LEAKS ACID ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT... |
| RQ99015 opened Jul 1999 | closed Dec 2001 | Seats | FRONT SEAT RECLINER BOLT FAILURE - led to recall 99V130000 |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 03V159000 | Visibility | ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. | Normally free |
| 98V150001 | Visibility | VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY. | Normally free |
| 96V057000 | Vehicle Speed Control | THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. | Normally free |
| 95V139000 | Power Train | THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE. | Normally free |
| 95V140000 | Air Bags | THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION." | Normally free |
| 95V081000 | Seat Belts | VEHICLES FAIL TO CONFORM TO FMVSS NO. 210, "SEAT BELT ANCHORAGES." THE CENTER REAR SEAT LAP BELT WAS IMPROPERLY ROUTED. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2003064 2003-03-17 | Other | 323,584 | Certain vehicles (not involved in recall 98-150), may experience a windshield wiper failure due to cracked solder joints on the controller circuit board. |
| 2000080 2000-03-21 | Accessories | 200,580 | On certain vehicles operated in areas of high salt use, the spare tire hoist cable may corrode and eventually break. This would allow the spare tire to fall off the vehicle possibly resulting in a road hazard for other vehicles. |
| 1997049 1997-03-11 | Seats And Restraints | 58,031 | Certain vehicles exhibit a condition in which a pinch bolt exists in the recliner mechanism that could trap and pinch a person's hand or finger(s) when the easy entry feature is activated. |
| 1995073 1995-04-21 | Seats And Restraints | 376 | THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 210 - SEAT BELT ASSEMBLY ANCHORAGES. THE REAR SEAT CENTRE LAP BELT MAY HAVE BEEN ROUTED OVER THE SEAT FRAME RATHER THAN UP THROUGH THE HOLE IN THE LOWER CUSHION. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 17-NA-073 Feb 2023 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. | |
| PIP4723F Jan 2022 | Fuel System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIP4723D Jan 2020 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| 19NA273 Dec 2019 | Electrical System | This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock. | |
| PIC4696E Nov 2019 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. |
Show 26 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 17NA073 Sep 2019 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. | |
| PIC4696D Sep 2019 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| 17NA073 Feb 2019 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. | |
| PIC4696C May 2018 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. | |
| PIP4723C Sep 2017 | Equipment | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| 17-NA-073 Mar 2017 | Equipment | This warranty administration bulletin provides policy information with the field action courtesy transportation policy. | |
| PIP4723B Feb 2017 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIC4696B Dec 2015 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| PIC4696A Oct 2015 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| 130089009 Sep 2013 | Engine And Engine Cooling | Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules | |
| 020525006 Jan 2006 | Service Brakes | ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS. *TT | |
| 3005 Jan 2004 | Equipment | 93-00 FULL SIZE UTILITIES (GMT 400 OLD STYLE ONLY) AC BLOWS WARM AND THE HIGH SIDE PRESSURE IS TOO HIGH. *MJ | |
| 01349A Nov 2003 | Fuel System | 6.5L L49 L56 L57 L65 DIESEL ENGINE REQUIRING FUEL INJECTION PUMP REPLACEMENT. MODELS P32/P42 1994-1999 INCLUDED. *TT | |
| 02054 Feb 2003 | Visibility | WINDSHIELD WIPER FAILURE DUE TO CRACKED BOULDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THIS SPECIAL POLICY COVERS THE CONDITION FOR A PERIOD OF SEVEN YEARS OR 70,000 MILES, WHICHEVER OCCURS FIRST FROM THE DATE THE VEHICLE WAS ORIGINALLY PLACED IN SERVICE REGARDLESS OF OWNERSHIP... | |
| 020525006A Dec 2002 | Service Brakes | ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS ON VARIOUS MODELS INCLUDING THE 1995 AND 1996 ENVOY. *TT | |
| 990730016A Oct 2002 | Power Train | DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT | |
| 98043 Sep 1998 | Visibility | PRODUCT RECALL CAMPAIGN INVOLVING WINDSHIELD WIPER MOTOR REPLACEMENT. *TT | |
| 577126B Apr 1997 | Power Train | TRANSMISSION FLUID LEAK FROM PUMP BODY (REPLACE BUSHING). *TW | |
| 667202A Feb 1997 | Power Train | MANUAL TRANSMISSION RATTLE NOISE AT IDLE (INSTALL CONVENTIONAL FLYWHEEL). *TW | |
| 568204 Aug 1995 | Visibility | WINDSHIELD WIPER BLADE CHATTER(REPLACE WIPER ARM AND BLADE). *SD | |
| 576513 Aug 1995 | Engine And Engine Cooling | ROUGH RUNNING OR STALLING IMMEDIATELY AFTER START (INSTALL PROM) *SD | |
| MSG95C45 Aug 1995 | Engine And Engine Cooling | PRODUCT SAFETY CAMPAIGN 95-C-45 SIR LABEL NON COMPLIANCE 1995 SUBURBAN AND TAHOE 2 DOOR L56/L65 DIESEL JANESVILLE PLANT. *SD | |
| CAMP95C32A Aug 1995 | Power Train | NO DRIVE/REVERSE OR NOISE WHILE DRIVING. *SD | |
| MSG95C24/C32 Aug 1995 | Unknown Or Other | THE SUBJECT CAMPAIGNS ARE BOTH BEING REVISED TO INCREASE THE TIME ALLOWANCE FOR FOR THE G-VAN MODELS TO 2.4 HOURS. *SD | |
| CAMP95C32 Jun 1995 | Power Train | NO DRIVE/REVERSE OR NOISE WHIEL DRIVING. *SD | |
| 576404 Jun 1995 | Electrical System | CLICK-NO-CRANK CONDITION (INSTALL NEW STARTER MOTOR).*SD |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Run every power seat adjustment and check the seat frame.Motors that stall and seats that rock on their tracks are this vehicle's seat complaints.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Run the VIN against open recalls before you negotiate.This vehicle has 6 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Chevrolet Tahoe →