Engine
3.8L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 116 of 147 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 37 of 147 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Engine & cooling
59 complaint records16 fire reports
"EXCESSIVE LOSS OF ENGINE COOLANT WHILE DRIVING. DEALER WAS NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Electrical system
30 complaint records6 fire reports
"VEHICLE FAILED TO START. UPON OPENING HOOD CONSUMER NOTICED THAT THE BATTERY TERMINAL POST CAME OFF, AND ACID WAS LEAKING OUT.*AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Power train
19 complaint records
"WHILE DRIVING VEHICLE CAME TO AN ABRUPT STOP. THE TRANS AXLE LOCKED UP. VEHICLE HAS BEEN AT THE DEALERSHIP FOR 5 WEEKS. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA02030 opened Oct 2002 | closed Mar 2004 | Fuel System, Gasoline | ENGINE COMPARTMENT FIRES - led to recall 04V090000 EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS... |
| PE02050 opened Jun 2002 | closed Oct 2002 | Engine And Engine Cooling | ENGINE COMPARTMENT FIRES |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 96V196000 | Seats | THE SEAT COVER TRIM MATERIAL DOES NOT MEET THE FLAMMABILITY REQUIREMENTS OF FMVSS NO. 302, "FLAMMABILITY OF INTERIOR MATERIALS." | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 1996162 1996-10-08 | Other | 4 | THESE VEHICLES DO NOT COMPLY WITH C.M.V.S.S. 302 - FLAMMABILITY. VEHICLES WERE MANUFACTURED WITH A SEAT COVER TRIM MATERIAL THAT DOES NOT MEET FLAMMABILITY REQUIREMENTS. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIP4723F Jan 2022 | Fuel System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIP4723D Jan 2020 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| 19NA273 Dec 2019 | Electrical System | This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock. | |
| PIC4696E Nov 2019 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| 17NA073 Sep 2019 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIC4696D Sep 2019 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| 17NA073 Feb 2019 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. | |
| PIC4696C May 2018 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. | |
| PIP4723C Sep 2017 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| 17-NA-073 Mar 2017 | Equipment | This warranty administration bulletin provides policy information with the field action courtesy transportation policy. | |
| PIP4723B Feb 2017 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| 16NA260 Aug 2016 | Equipment | THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBRATION CONCERNS. | |
| PIC4696B Dec 2015 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| PIC4696A Oct 2015 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| Recalls Jun 2014 | Equipment | Vehicle Recalls | |
| 05-06-04-035D May 2014 | Fuel System | This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle. | |
| PI1217 Apr 2014 | Power Train | This preliminary bulletin provides a way to aid the technician in diagnosing transmission fluid leaking from the trans breather vent. | |
| 130089009 Sep 2013 | Engine And Engine Cooling | Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules | |
| 010601007 Sep 2007 | Engine And Engine Cooling | ENGINE COOLANT CONSUMPTION OR COOLANT LEAK (INSPECT FOR MATERIAL DEGRADATION/REPLACE INTAKE MANIFOLDS) *TT UPDATED 11/02/07 *NJ | |
| 050604058 Sep 2005 | Vehicle Speed Control | INTERMITTENT CHUGGLE OR FISHBITE ON LIGHT ACCELERATION OR A HIGHWAY SPEEDS WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT | |
| 010730032B Nov 2004 | Power Train | SOME OWNERS MAY COMMENT ON A TRANSMISSION OIL LEAK. *TT UPDATED *EH | |
| 010844005A Oct 2004 | Equipment | INFORMATION ON ERROR CODES ON RADIO DISPLAY THEIR CAUSE AND CORRECTIVE ACTION. *EH | |
| 040601017 Jun 2004 | Engine And Engine Cooling | NEW UPPER INTAKE MANIFOLD AND GASKET KITS. *TT | |
| 040601021 Jun 2004 | Engine And Engine Cooling | NEW REAR MAIN SEAL AND SPECIAL TOOL FOR INSTALLATION. *TT | |
| 000730002B Jul 2002 | Power Train | CONCERNS WITH SLIPS, HARSH UPSHIFT OR GARAGE SHIFTS, LAUNCH SHUDDERS, FLARES, ERRATIC SHIFTS AND INTERMITTENT CONCERNS, DIAGNOSTIC TROUBLE CODE P1811 OR P0748 SET. *TT | |
| 020730014A Jul 2002 | Unknown Or Other | INFORMATION ON SERVICING 4T65-E TRANSAXLE SPACER PLATE AND GASKETS FOR VARIOUS MODELS FROM 1997 THROUGH 2002. *TT | |
| 010601008A May 2002 | Engine And Engine Cooling | SOME OWNERS MAY COMMENT ON A REPEAT ENGINE OIL PAN LEAK. *TT | |
| 020730014 Apr 2002 | Unknown Or Other | INFORMATION ON SERVICING 4T65E TRANSAXLE SPACER PLATE AND GASKETS. *TT | |
| 010601007A Jul 2001 | Engine And Engine Cooling | EXPERIENCING EXCESSIVE ENGINE COOLANT CONSUMPTION, OR AN ENGINE COOLANT LEAK NEAR OR UNDER THE THROTTLE BODY AREA OF THE UPPER INTAKE MANIFOLD. *TT | |
| 990730030A Apr 2001 | Power Train | OWNERS OF SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60, 4T60-E OR 4T65-E TRANSAXLES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN STANDING IN PARK ON A HILL OR SLOPE WITH THE ENGINE RUNNING AND THE PARKING BRAKE NOT APPLIED. *TT | |
| 010601008 Feb 2001 | Engine And Engine Cooling | SOME OWNERS MAY COMMENT ON A REPEAT ENGINE OIL PAN LEAK. *TT | |
| 990730030 Dec 1999 | Power Train | SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60 OR 4T60-E TRANSXALES MAY COMMENT ON A GRINDING AND / OR GROWLING NOISE THAT IS NOTICEABLE WHEN IN PARK ON INCLINE. *TT | |
| 832006 Dec 1998 | Structure | SOME CUSTOMERS MAY COMMENT THAT THERE IS CORROSION ( RUST ) APPEARING ON THE LEFT AND /OR RIGHT ROCKER PANEL(S). *YC | |
| 877175 Nov 1998 | Power Train | SOME COMMENTS ON VEHICLE SURGE. *YC | |
| 98833005 Oct 1998 | Suspension | SOME CUSTOMERS MAY COMMENT THAT THE VEHICLE | |
| 98831519 Oct 1998 | Structure | REAR COMPARTMENT LID DIFFICULT TO CLOSE. *YC | |
| 831704 Oct 1998 | Structure | CONCERNS OF DOOR HANDLES ON WHITE PAINTED VEHICLES TRUNING YELLOW. *YC | |
| 9874T60E04 Oct 1998 | Engine And Engine Cooling | SOME VEHICLES MAY EXPERIENCE VEHICLE SURGING AT 72 TO 89 KM/H ( 45 TO 55 MPH ). *YC | |
| 98848301 Jun 1998 | Unknown Or Other | COMMENT THAT THE VEHICLE'S COMPASS DISPLAY IS TOO DIM, HAS AN UNEVEN DISPLAY OR NO DISPLAY. *YC | |
| 98777155A Apr 1998 | Power Train | EXPERIENCING A TRANSAXLE GEAR WHINE NOISE ON COAST DOWN OR LIGHT ACCELERATION BETWEEN 20 AND 40 MPH. *YC | |
| 738325 Dec 1997 | Fuel System | CUSTOMERS MAY COMPLAIN THAT THE FUEL GAUGE REMAINS ON "FULL" TOO LONG. *TT | |
| 971101739015 Nov 1997 | Unknown Or Other | COMMENTS ON INSUFFICIENT RANGE OF THE KEYLESS ENTRY SYSTEM. *YC | |
| 971101631041 Nov 1997 | Structure | COMMENTS ON INOPERATIVE POWER DOOR LOCKS (FRONT AND/OR REAR DOORS). | |
| 971101731615 Nov 1997 | Seat Belts | CONDITION WITH OUTER REAR SEAT BELTS ARE DIFFICULT TO FASTEN. *YC | |
| 9709016116A Sep 1997 | Engine And Engine Cooling | COMMENTS OF AN ENGINE OIL LEAK THAT APPEARS TO ORIGINATE TOWARD THE DRIVER'S SIDE OF THE VEHICLE; REAR OF ENGINE. *YC | |
| 9709017160A Sep 1997 | Power Train | VEHICLES EQUIPPED WITH HARSH GARAGE SHIFT REVERSE TO DRIVE. *YC | |
| 970801777155 Aug 1997 | Power Train | EXPERIENCING A TRANSAXLE GEAR WHINE NOISE ON COAST DOWN OR LIGHT ACCELERATION. *YC | |
| 97080177715F Aug 1997 | Power Train | EXPERIENCE A TRANSAXLE GEAR WHINE NOISE ON COAST DOWN OR LIGHT ACCELERATION. *YC | |
| 731608 Jun 1997 | Visibility | EXCESSIVE VIBRATION OF ELECTROCHROMIC INSIDE REARVIEW MIRROR. *TW | |
| 776110 Jun 1997 | Engine And Engine Cooling | ENGINE OIL LEVEL INDICATES OVER FULL (REPLACE OIL LEVEL INDICATOR TUBE ASSEMBLY). *TW | |
| 970501735019 May 1997 | Service Brakes | WHEN BRAKES ARE DEPRESSED FORCE OR ENGINE LOAD MAY AFFECT AND CAUSE VARIOUS NOISES. *YC | |
| 970501777160 May 1997 | Power Train | EXPERIENCING HARSH ENGAGEMENT FROM REVERSE TO DRIVE. *YC | |
| 9774T65E02 Apr 1997 | Power Train | HARSH GARAGE SHIFT, REVERSE TO DRIVE, HYDRA-MATIC 4T65-E TRANSAXLE. *TW | |
| 549001A Mar 1997 | Equipment | CLN INDICATOR APPEARS ON RADIO DISPLAY AND DOES NOT TURN OFF (RESET CLN INDICATOR WITH THE EJECT BUTTON ON TAPE). *TW | |
| 731207 Mar 1997 | Equipment | INTERMITTENT A/C SYSTEM THUMP NOISE ON INITIAL START UP FROM FRONT PASSENGER SIDE FLOOR PANEL (REPLACE ACCUMULATOR). *TW | |
| 677164 Feb 1997 | Power Train | INTERMITTENT NEUTRAL OR LOSS OF DRIVE AT HIGHWAY SPEEDS OR FROM FOURTH GEAR (REPLACE CONTROL VALVE BODY ASSEMBLY). *TW | |
| 577106A Feb 1997 | Power Train | COLD START RATTLE NOISE (DIAGNOSIS/SERVICE PROCEDURE). *TW | |
| 638315 Jan 1997 | Electrical System | CHECK GAGES LAMP ILLUMINATES WITH GAGE READING 1/4 TANK OF FUEL LEFT (REPLACE IPC CLUSTER). *TW | |
| 631218 Jan 1997 | Equipment | A/C SYSTEM FLUTTER AND/OR MOAN NOISE WITH HVAC IN A/C MODES. *TW | |
| 108150A Dec 1996 | Power Train | SOME VEHICLES MAY DISPLAY A CONDITION AT 70 MPH WHERE THE SPEEDOMETER READS ABOUT 4 MPH FASTER OR SLOWER THAN HUD. *TW |
Showing 60 of 61 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Pontiac Bonneville →