Engine
4.0L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 1,050 of 1,348 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 296 of 1,348 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Tires
397 complaint records2 fire reports46 crash reports
"DEFECTIVE TIRE STILL UNDER MANUFACTURERS WARRANTY BLEWOUT AND CAUSED DAMAGES. *AK( DOT NUMBER: TIRE SIZE: 235-75-15 )..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse tires parts in the directory →
Glass & wipers
225 complaint records1 fire report2 crash reports
"WINDSHIELD WIPERS KEEP GETTING WORSE. THEY ACTIVATE ON THEIR OWN EVERY 2 TO 30 SEC. DEALER CANNOT FIX THE PROBLEM. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse glass & wipers parts in the directory →
Speed control
153 complaint records11 fire reports14 crash reports
"GEM MODULE (VEHICLE GETS LOCKED INTO 4 WHEEL DRIVE OR WILL NOT EXIT 4 WHEEL DRIVE NHTSA CAMPAIGN ID NUMBER: 99V06200. *JB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse speed control parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP05005 opened Sep 2005 | closed Jan 2006 | Engine And Engine Cooling | SPARK PLUG EJECTION FROM CYLINDER HEAD ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE... |
| PE03020 opened May 2003 | closed Sep 2003 | Seats | FRONT SEAT BACK RECLINER ATTACHMENT - led to recall 03V281000 BY LETTER DATED AUGUST 4, 2003, FORD NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. |
| EA01008 opened Feb 2001 | closed Apr 2002 | Seat Belts | SEAT BELT WEBBING ODI OPENED PE00-044INVESTIGATION ON NOVEMBER 3, 2000, BASED ON A REPORT REGARDING THE DEATH OF THE OCCUPANT OF THE RIGHT FRONT SEAT IN A 2000 MODEL YEAR FORD EXPLORER XLS INVOLVED IN A ROLL-OVER CRASH.IT IS ALLEGED THAT THE WEBBING OF THE BUCKLE PORTION OF... |
| SQ99026 opened Nov 1999 | closed May 2000 | Air Bags | AIRBAG SYSTEM'S LIGHT DYSFUNCTIONAL There is no summary currently available |
| PE99049 opened Jul 1999 | closed Apr 2000 | Visibility | WINDSHIELD WIPER MALFUNCTION - led to recall 00V072000 There is no summary currently available |
Show 1 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| SQ99017 opened Jun 1999 | closed Feb 2000 | Power Train | VEHICLE HESITATION/STALLING There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 09V399000 | Vehicle Speed Control | FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY... | Normally free |
| 07V336000 | Vehicle Speed Control | ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. | Normally free |
| 03V281000 | Seats | ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. | Normally free |
| 03V280000 | Vehicle Speed Control | ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS... | Normally free |
| 00V395000 | Power Train | VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. | Normally free |
| 00V072000 | Electrical System | VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. | Normally free |
| 99V164000 | Latches/Locks/Linkages | VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SECONDARY HOOD LATCH MAY CORRODE AT THE LATCH PIVOT AND STICK IN THE OPEN POSITION. | Normally free |
| 99V123000 | Service Brakes, Hydraulic | VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT FRONT BRAKE LINE TO THE HYDRAULIC CONTROL UNIT (HCU) CONNECTION COULD SEPARATE CAUSING THE LINE TO LEAK WHEN THE BRAKE PEDAL IS APPLIED. | Normally free |
Show 1 more recall campaigns
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 99V062001 | Vehicle Speed Control | VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR... | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2019420 2019-08-21 | Other | 5,327 | Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. |
| 2009292 2009-10-14 | Other | 492,877 | On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. |
| 2007258 2007-08-07 | Electrical | 165,447 | On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The failure mode appears to be different than that of Recall 2005028 (05S28). |
| 2006079 2006-04-18 | Seats And Restraints | 366 | On certain Explorer, Explorer Sport and Explorer Sport Trac vehicles, the upper bolt on the driver's high back seat that attaches the seat recliner mechanism to the seat back frame could fracture. |
| 2003189 2003-08-11 | Other | 28,596 | On certain Explorer, Explorer Sport and Explorer Sport Tract vehicles, the speed control cable strand cover could impact the conduit end fitting during speed control engagement. |
Show 6 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2003190 2003-08-11 | Seats And Restraints | 56,363 | On certain Explorer, Explorer Sport and Explorer Sport Trac vehicles, the upper bolt on the driver's high back seat that attaches the seat recliner mechanism to the seat back frame could fracture. |
| 2001003 2001-01-12 | Powertrain | 5,281 | On certain vehicles, the Powertrain Control Module may allow the vehicle to exceed the design intent top speed. At these extreme speeds. the vehicle may be capable of exceeding the speed rating of the tires. |
| 2000078 2000-03-21 | Electrical | 18,576 | On certain vehicles, the generic electronic module (GEM) may experience a condition referred to as "lock-up" in which the GEM controlled functions (front windshield wipers, interior lights, 4X4 system etc.) could not be turned ON or, in... |
| 1999133 1999-06-30 | Structure | 40,771 | On certain vehicles, the secondary hood latch may corrode at the latch pivot and stick in the open position. If this occurs and the primary hood latch is either not engaged or is released, a hood fly-up may occur. |
| 1999102 1999-05-26 | Brakes | 1,057 | On certain vehicles, the right front brake line attachment to the ABS hydraulic control unit (HCU) may separate from the HCU. This may be due to an incorrect seat angle on the flare nut that is part of the brake line assembly. |
| 1999061 1999-04-15 | Engine | 35,668 | On certain vehicles, the speed control cable may interfere with the speed control servo pulley and not allow the throttle to return to idle when disengaging the speed control. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| CSP-08B01 May 2008 | Engine And Engine Cooling | FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. *PE | |
| 030508 Apr 2005 | Power Train | FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT | |
| 0471 Dec 2004 | Electrical System | WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT | |
| 04189 Dec 2004 | Visibility | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| 042107 Dec 2004 | Power Train | GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 042419 Dec 2004 | Suspension | REVISED PROCEDURE FOR ADJUSTING ALIGNMENT ON ALL SUSPENSIONS - NEW RIGHT HAND UPPER CONTROL ARM DESIGN FOR TORSION BAR FRONT SUSPENSIONS. *TT | |
| 020801 Aug 2004 | Engine And Engine Cooling | RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA 2000-3000 RPM - 4.0L SOHC ENGINE. *TT | |
| 041514 Aug 2004 | Visibility | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| 031501 Jul 2004 | Visibility | INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| 02138 Nov 2003 | Power Train | LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT | |
| 03199 Sep 2003 | Engine And Engine Cooling | RATTLE/BUZZ SOUND FROM UNDER THE VEHICLE ON 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT | |
| 03181 Sep 2003 | Electrical System | REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| 03148 Jul 2003 | Power Train | NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| 16935 Jul 2003 | Power Train | AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT | |
| 0398 May 2003 | Fuel System | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| 16735 Apr 2003 | Suspension | VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT | |
| 0358 Mar 2003 | Power Train | FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB | |
| 03261 Jan 2003 | Power Train | NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| 02221 Nov 2002 | Engine And Engine Cooling | ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| 870197 Oct 2002 | Engine And Engine Cooling | INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT | |
| 02171 Sep 2002 | Structure | PAINT-PREMATURE CLEARCOAT CRACKING-SERVICE TIPS. *MJ | |
| 02176 Sep 2002 | Exterior Lighting | LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| 16114 Aug 2002 | Air Bags | SOME VEHICLES MAY EXHIBIT REPEAT SERVICE FOR AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1994 (DRIVER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) AND / OR B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH). *TT | |
| 16040 Jul 2002 | Steering | EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT | |
| 15887 May 2002 | Power Train | SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT | |
| 15910 May 2002 | Service Brakes | CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT | |
| 0281 Apr 2002 | Engine And Engine Cooling | SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT | |
| 0282 Apr 2002 | Power Train | SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT | |
| 0285 Apr 2002 | Equipment | ON SOME VEHICLES, THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) BLOWS COLD AIR FROM THE FLOOR DUCTS ON VEHICLES PRODUCED BEFORE 9/30/2000 ONLY. *TT | |
| 0276 Apr 2002 | Engine And Engine Cooling | INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT | |
| 0242 Mar 2002 | Power Train | CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT | |
| 0245 Mar 2002 | Electrical System | INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| 15692 Mar 2002 | Suspension | SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT | |
| 0232 Feb 2002 | Unknown Or Other | SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT | |
| 0214 Jan 2002 | Engine And Engine Cooling | SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| 15532 Jan 2002 | Fuel System | INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT | |
| 15040 Jan 2002 | Engine And Engine Cooling | SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT | |
| 15563 Jan 2002 | Unknown Or Other | INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH | |
| 15567 Jan 2002 | Engine And Engine Cooling | SOME VEHICLES BUILT BEFORE APRIL 23, 2001 MAY EXHIBIT A HARD START/LONG CRANK AFTER SITTING FOR AN HOUR OR MORE. *TT | |
| 01246 Dec 2001 | Engine And Engine Cooling | ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| 15470 Dec 2001 | Engine And Engine Cooling | CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT | |
| 15496 Dec 2001 | Engine And Engine Cooling | SOME VEHICLES BUILT BEFORE APRIL 23, 2001 MAY EXHIBIT A HARD START/LONG CRANK AFTER SITTING FOR AN HOUR OR MORE DUE TO FUEL SYSTEM CONTAMINATION. *TT | |
| 15406 Nov 2001 | Visibility | CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS. *TT | |
| 15422 Nov 2001 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK CONDITION AFTER SITTING FOR AN HOUR OR MORE. *TT | |
| 012113 Oct 2001 | Electrical System | SOME IGNITION SWITCH LOCK CYLINDER ASSEMBLIES MAY EXHIBIT ROUGNESS AND / OR EXCESS EFFORT IN TURNING, KEY DOES NOT FULLY RETURN FROM START, A MALFUNCTION INDICATOR LAMP MAY ILLUMINATE WITH P0500, P1502 AND U1039 STORED IN POWERTRIAN CONTROL MODULE (PCM). *TT | |
| 01205 Oct 2001 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT | |
| 01197 Oct 2001 | Engine And Engine Cooling | SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT | |
| 01B77 Oct 2001 | Tires | OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT | |
| 01181 Sep 2001 | Power Train | BRAKE SHIFT INTERLOCK.*JB | |
| 15217 Sep 2001 | Unknown Or Other | INFORMATION ON SERVICE PARTS FOR HARD START CONDITION. *TT | |
| 15226 Sep 2001 | Engine And Engine Cooling | SOME VEHICLES EQUIPPED WITH A 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE THAT MAY BE PERCEIVED BY THE CUSTOMER A S ADIESEL TYPE NOISE AND IS KNOWN AS MARBLE NOISE. *TT | |
| 15249 Sep 2001 | Service Brakes | CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT | |
| 01156 Aug 2001 | Visibility | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| 01157 Aug 2001 | Unknown Or Other | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| 15119 Aug 2001 | Exterior Lighting | INFORMATION REGARDING MULTIFUNCTION SWITCH PART NUMBER CLARIFICATION. *SLC | |
| 15168 Aug 2001 | Service Brakes | SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH | |
| 15138 Aug 2001 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT A HESITATION ON ACCELERATION DURING ENGINE WARM-UP. *SLC | |
| 15155 Aug 2001 | Visibility | ON SOME VEHICLES THE REAR WIPER ARM FAILS TO CLEAN BACK GLASS. *ET | |
| 01137 Jul 2001 | Power Train | SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT. *TT | |
| 15040 Jul 2001 | Engine And Engine Cooling | SOME EXPLORER / SPORT / SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE CONDITION FROM THE LEFT FRONT OF THE ENGINE. *TT |
Showing 60 of 411 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Read the tire date codes and look for uneven wear.Uneven wear on this vehicle often points back to the suspension. Four different date codes tell their own story.
- Run the wipers and washers, and test every window.Slow or stuck regulators, streaking wipers, and windshield cracks are this vehicle's visibility complaints.
- Test the throttle response and the cruise control on an open road.A surge, a hang in engine speed after lifting off, or cruise that will not set or cancel cleanly are the speed-control complaints on this vehicle.
- Run the VIN against open recalls before you negotiate.This vehicle has 9 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford Explorer →