Engine
5.7L 8-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 177 of 204 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 84 of 204 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Brakes
122 complaint records12 crash reports
"BRAKES MAKE A GRINDING SOUND AFTER I JUST CHANGED THEM AND THEY ARE SCRAPING ON THE ROTOR AND ARE CAUSING GRINDING. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Steering
22 complaint records
"CONSUMER WAS TRAVELING ON HIGHWAY AND POWER STEERING WENT OUT WITHOUT PRIOR NOTICE. DEALERSHIP WAS AWARE OF PROBLEM. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse steering parts in the directory →
Tires
17 complaint records1 crash report
"NOTICEABLE VIBRATION AT SPEEDS GREATER THAT 60 MPH. REPLACED TIRES WITH NO REDUCTION. ALL OTHER MODELS ON DEALER LOT HAS SIMILAR VIBRATION PROBLEMS.( DOT NUMBER: TIRE SIZE: 245/75/16 )..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse tires parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE10010 opened Mar 2010 | closed Jan 2011 | Service Brakes, Hydraulic | Brake line corrosion failure The Office of Defects Investigation (ODI) received Defect Petition DP10-003 on March 2, 2010, requesting the investigation of model year (MY) 2003 Chevrolet Silverado 2500HD 4WD pickup trucks for corrosion failures of the vehicle brake lines.DP10-003 was... |
| PE05020 opened Apr 2005 | closed Sep 2005 | Service Brakes, Hydraulic | UNWANTED LOW-SPEED ABS ACTIVATION - led to recall 05V379000 IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN... |
| EA02015 opened Aug 2002 | closed Jan 2004 | Vehicle Speed Control | THROTTLE STICKING CLOSED THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. |
| EA01018 opened Dec 2001 | closed Dec 2002 | Seat Belts | SEAT BELT ANCHORAGE SEPARATION |
| PE01023 opened Jul 2001 | closed Dec 2001 | Seat Belts | SEAT BELT ANCHORAGE SEPARATION ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER... |
Show 1 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA99011 opened May 1999 | closed Feb 2001 | Steering | ERRATIC POWER STEERING ASSIST WHILE DRIV THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 00V122000 | Seat Belts | VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2001263 2001-11-01 | Electrical | 63,484 | Certain vehicles: Light duty trucks. passenger vehicles and sport utility vehicles. Certain vehicles do not comply with the requirements of C.M.V.S.S. NO. |
| 2000270 2000-11-17 | Brakes | 116,675 | On certain vehicles, the body cross sill may contact the front, right-hand brake pipe. This could eventually wear a hole in the brake pipe over the normal life of the vehicle and result in a brake fluid leak. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 17-NA-073 Feb 2023 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. | |
| PIP4723F Jan 2022 | Fuel System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIP4723D Jan 2020 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIC4696E Nov 2019 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| 17NA073 Sep 2019 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIC4696D Sep 2019 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| 17NA073 Feb 2019 | Equipment | This warranty administration bulletin provides information regarding the field action courtesy transportation policy. | |
| PIC4696C May 2018 | Equipment Adaptive/Mobility | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. | |
| PIP4723C Sep 2017 | Fuel System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| 17-NA-073 Mar 2017 | Equipment | This warranty administration bulletin provides policy information with the field action courtesy transportation policy. | |
| PIP4723B Feb 2017 | Electrical System | This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and Vehicle Data Recorder tools, giving... | |
| PIP4138P Dec 2016 | Engine | This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308. | |
| 16NA260 Aug 2016 | Equipment | THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBRATION CONCERNS. | |
| PIC4696B Dec 2015 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| PIP5346 Nov 2015 | Power Train | This Preliminary Information communication provides information to the technician about cooler line fittings that come with the 4T65E General Motors remanufactured transmission may not be the same as Original equipment manufacturer quick connect verses inverted flare. | |
| PIC4696A Oct 2015 | Equipment | This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. | |
| PIP4404F Oct 2015 | Engine | This Preliminary Information communication provides information to the technician vehicles with a slight rough idle. Technician should compare the concern with a like vehicle. | |
| PIP5280 Apr 2015 | Fuel System | This Preliminary Information communication provides information to the technician about vehicles that may have a buzz noise at idle after fuel pressure regulator replacement. Technician will need to gain access to the fuel pump. | |
| PIT3098E Dec 2014 | Exterior Lighting | This Preliminary Information communication provides information to the technician about vehicles that have a lean to the left or right. Technician will need to measure fender wheel-opening heights, front and rear, to quantify vehicle lean. | |
| Recalls Jun 2014 | Equipment | Vehicle Recalls | |
| 05-06-04-035D May 2014 | Fuel System | This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle. | |
| 99-08-51-007F Feb 2014 | Equipment Adaptive/Mobility | Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. | |
| PIP5169 Jan 2014 | Engine | This Preliminary Information communication provides information to the technician about vehicles that are setting Diagnostic Trouble Code P0300 after engine repairs. Technician will need to ensure that injector connectors for cylinder 5-7 and 6-8 are not crossed. | |
| PI0281D Jan 2014 | Structure | Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. | |
| 130089009 Sep 2013 | Engine And Engine Cooling | Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules | |
| PIP4404E Aug 2013 | Steering | This Preliminary Information communication provides information to the technician vehicles with a slight rough idle. Technician should compare the concern with a like vehicle. | |
| PIP4138N Aug 2013 | Electrical System | This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308. | |
| PI0969 May 2013 | Engine And Engine Cooling | This preliminary informational bulletin provides information on High Oil Pressure on Startup After Engine Replacement Concern. | |
| PIP4138M Jan 2013 | Engine | This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308. | |
| PIP4138L Dec 2012 | Power Train | This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp on, engine misfire, and/or engine noise. Technician may find Diagnostic Trouble Codes P0300-P0308. | |
| PIP3259J Dec 2012 | Power Train | This Preliminary Information communication provides information to the technician about vehicles that may have a planetary gear whine noise in first and second gear. Technician should compare the noise to a like vehicle. | |
| PIP3720D Nov 2012 | Power Train | This Preliminary Information communication provides information to the technician with the axel setup information from American Axle Manufacturing. | |
| PIP5072 Oct 2012 | Power Train | This Preliminary Information communication provides information to the technician about vehicles that have slip in forward ranges immediately after replacing the input housing. | |
| PIP-4138K Jan 2011 | Engine And Engine Cooling | GM: THE SERVICE ENGINE SOON LIGHT IS ON, THERE IS ALSO A MISFIRE OR ENGINE NOISE. THERE ARE MULTIPLE POSSIBLE CAUSES. *RM | |
| 08089-B Nov 2008 | Electrical System | GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE | |
| 08-089 Jun 2008 | Equipment | BUICK CADILLAC CHEVROLET GMC HUMMER OLDSMOBILE PONTIAC SAAB SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. | |
| 3340 Sep 2006 | Suspension | LEFT FRONT AXLE SHAFT DIFFICULT TO REMOVE. AXLE DIFFERENTIAL LEAK SEAL SHAFT. *KB | |
| 020525006 Jan 2006 | Service Brakes | ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS. *TT | |
| 010730038B Oct 2005 | Power Train | THE SERVICE ENGINE SOON LAMP IS ILLUMINATED, NO 3RD AND 4TH GEAR, THE TRANSMISSION DOES NOT SHIFT CORRECTLY, THE TRANSMISSION FEELS LIKE IT SHIFTS TO NEUTRAL OR A LOSS OF DRIVE OCCURS. *TT | |
| 020730024A Aug 2005 | Power Train | DIAGNOSIS OF CRACKED OR BROKEN TRANSMISSION CASE. *TT 2006 AND PRIOR CARS AND LIGHT DUTY TRUCKS. *TT | |
| 020307002 Mar 2005 | Suspension | REVISED FRONT CASTER AND CAMBER ADJUSTMENT PROCEDURE. ORIGINAL NOT YET RECEIVED. *TT | |
| 040604088 Mar 2005 | Engine And Engine Cooling | REPLACEMENT OF CONNECTOR WHEN REPLACING FUEL TANK MODULE/FUEL PUMP MODULE. *TT | |
| 040139007 Jun 2004 | Equipment | LOSS OF HEATING VENTILATION AIR CONDITIONING. SYSTEM MODE AND OR TEMPERATURE CONTROL. *EH | |
| 00149D Jan 2004 | Electrical System | MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE. VARIOUS MODELS INCLUDING 1996 - 1999 P32 MODELS. SIT BULLETIN 1416475. *TT | |
| 01599 Jan 2004 | Power Train | 4L60E, 4L65E FORWARD AND LOW REVERSE WAVED STEEL CLUTCH PLATE APPEARANCE CHANGE. *TT | |
| 01119A Jan 2004 | Engine And Engine Cooling | ROLL-OUT FOR THE GEN III SMALL BLOCK ENGINES WITH IRIDIUM SPARK PLUGS. ALSO INCLUDES 2003/2004 M/L VANS. *TT | |
| 3005 Jan 2004 | Equipment | 93-00 FULL SIZE UTILITIES (GMT 400 OLD STYLE ONLY) AC BLOWS WARM AND THE HIGH SIDE PRESSURE IS TOO HIGH. *MJ | |
| 3058 Jan 2004 | Engine And Engine Cooling | GOODWRENCH ENGINE AND REPLACEMENT CRANKSHAFT INFORMATION. *TT | |
| 3121 Jan 2004 | Engine And Engine Cooling | EXHAUST VIBRATION RESONANCE OR MOAN. (2004-2005 GMC DENALI) *SC | |
| 01349A Nov 2003 | Fuel System | 6.5L L49 L56 L57 L65 DIESEL ENGINE REQUIRING FUEL INJECTION PUMP REPLACEMENT. MODELS P32/P42 1994-1999 INCLUDED. *TT | |
| 01409 Nov 2003 | Power Train | THE NVG 136 ALL WHEEL DRIVE (AWD) TRANSFER CASE AND THE 236 AND 246 NVG SELECTABLE TRANSFER CASE SHUDDER ON TURNS. *TT | |
| 01410 Nov 2003 | Power Train | POOR PERFORMANCE FROM A STOP IN 2WD, AUTO OR 4WD HI. 2003, 2003 CADILLAC EXT ALSO INCLUDED. *TT | |
| 00149C Nov 2003 | Electrical System | MALFUNCTION INDICATOR LAMP ON WITH A P0300 SET AND A MISFIRE. VARIOUS MODELS INCLUDING THE 1996-1999 P32 AND THE 1996-2002 GMC C/K TRUCK. *TT | |
| 010730002C Aug 2003 | Power Train | MALFUNCTION INDICATOR LAMP (MIL) IS ON; THE TRANSMISSION IS STUCK IN THIRD GEAR; AND / OR THE INSTRUMENT CLUSTER IS INOPERATIVE. *TT | |
| 020421005A Feb 2003 | Power Train | SLIPS IN 4-WHEEL DRIVE, NOISE, VIBRATION, LEAKS, HOT ODOR. *TT | |
| 020525006A Dec 2002 | Service Brakes | ANTILOCK BRAKE (ABS) ACTIVATION AT LOW SPEEDS ON VARIOUS MODELS INCLUDING THE 1995 AND 1996 ENVOY. *TT | |
| 990730016A Oct 2002 | Power Train | DIAGNOSTIC INFORMATION FOR INTERMITTENT TRANSMISSION DOWNSHIFT, SLIP, BUSY/CYCLING TCC OR NOISY COOLING FAN. *TT | |
| 020849007 Sep 2002 | Structure | CENTER CONSOLE LID HARD TO OPEN OR CLOSE. *TT | |
| 010601029B Jul 2002 | Engine And Engine Cooling | SOME CUSTOMERS MAY COMMENT ON HIGHER THAN EXPECTED ENGINE OIL CONSUMPTION. *TT | |
| 020604023A Jun 2002 | Engine And Engine Cooling | SOME CUSTOMERS MAY COMMENT ON A MILD TO SEVERE ENGINE PING (COMMONLY REFERRED TO AS SPARK KNOCK) USUALLY WORSE DURING ACCELERATION AND / OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP. *TT |
Showing 60 of 91 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Drive one straight highway stretch and one slow parking lot.Wander or a shimmy over bumps at speed, and heavy or dropped assist at low speed, are the two faces of this vehicle's steering cluster. A clunk on turn-in points at the linkage.
- Read the tire date codes and look for uneven wear.Uneven wear on this vehicle often points back to the suspension. Four different date codes tell their own story.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this GMC Yukon →