Engine
4.6L 8-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 144 of 157 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 85 of 157 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Engine & cooling
29 complaint records1 crash report
"LEAKING COOLANT FROM THE PLASTIC INTAKE MANIFOLD. FORD WANT'S $500.00+ FOR A NEW ONE. I CAN GET ONE FROM EBAY FOR $150.00. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Speed control
27 complaint records8 crash reports
"VEHICLE EXPERIENCED SUDDEN ACCELERATION WHILE SLOWING DOWN FOR A RED LIGHT, THE SPEED CONTROL HAS BEEN DISCONNECTED. NLM..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse speed control parts in the directory →
Seat belts
24 complaint records3 crash reports
"1 PASSENGER SEAT BELT NOT FUNCTIONING PROPERLY 2 SPEED CONTROL NOT WORKING 3 PASSENGER SIDE HEADLIGHT NOT WORKING IN LOW BEAM ONLY HIGH BEAM..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse seat belts parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP05005 opened Sep 2005 | closed Jan 2006 | Engine And Engine Cooling | SPARK PLUG EJECTION FROM CYLINDER HEAD ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE... |
| EA05004 opened Feb 2005 | closed Jul 2005 | Seat Belts | FRONT SEAT BELT BUCKLE ASSEMBLY DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR... |
| SQ01014 opened Nov 2001 | closed Oct 2002 | Fuel System, Gasoline | POST REAR END COLLISION FIRES - led to recall 02I003000 There is no summary currently available |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 01V227001 | Seat Belts | VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. | Normally free |
| 00V412000 | Air Bags | VEHICLE DESCRIPTION: MINIVANS AND PASSENGER VEHICLES. A RESTRAINT CONTROL MODULE (RCM) OR A SIDE OR FRONT CRASH SENSOR MAY HAVE BEEN ASSEMBLED WITH ONE OR MORE OF THE SCREWS THAT MOUNT THE CIRCUIT BOARD IN THE HOUSING... | Normally free |
| 00V270000 | Air Bags | CERTAIN PASSENGER VEHICLES, LIMOUSINES, AND MINI VANS WERE BUILT WITH A NEWLY DESIGNED RESTRAINT CONTROL MODULE (RCM). | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2001194 2001-07-16 | Seats And Restraints | 78,402 | Certain passenger and sport utility vehicles, pickup trucks, and minivans equipped with seat belts supplied by TRW. It is possible that the driver's and/or front passenger's outboard seat belt buckle may not fully latch. |
| 2000304 2000-12-29 | Seats And Restraints | 1,897 | On certain vehicles, a restraint control module (RCM) or a side or front crash sensor may have been assembled with one or more of the screws that mount the circuit board in the housing missing. |
| 2000243 2000-10-24 | Seats And Restraints | 780 | On certain vehicles, the Restraint Control Module (RCM) may not recognize certain system faults that could result in an air bag or seat pre-tensioner unexpectedly activating during the self-test sequence at vehicle start-up. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| TSB 19-2026 Feb 2019 | Structure | Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. | |
| CSP 08B04 May 2008 | Fuel System | FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. *PE | |
| 07212 Oct 2007 | Engine And Engine Cooling | SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE | |
| 05N04 Dec 2005 | Engine And Engine Cooling | EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. | |
| 041601 Nov 2005 | Engine And Engine Cooling | WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 042421 Jun 2005 | Seat Belts | SAFETY BELT RETRACTION SPEED. *TT | |
| 18426 Feb 2005 | Equipment | AM FM AND CELLULAR PHONE RECEPTION INTERFERENCE . *EH | |
| 18383 Jan 2005 | Electrical System | AM/FM AND CELLULAR PHONE RECEPTION INTERFERENCE - SERVICE TIP. *TT | |
| 04251 Dec 2004 | Structure | ALUMINUM CORROSION - SERVICE TIP. *TT | |
| 04189 Dec 2004 | Visibility | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| 042107 Dec 2004 | Power Train | GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| 04217 Nov 2004 | Power Train | GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT | |
| 04174 Sep 2004 | Electrical System | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| 031404 Aug 2004 | Engine And Engine Cooling | ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. | |
| 041514 Aug 2004 | Visibility | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| 031501 Jul 2004 | Visibility | INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| 04111 Jun 2004 | Electrical System | STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| 02M01 Jun 2004 | Engine And Engine Cooling | CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6. *TT | |
| 17871 Jun 2004 | Electrical System | MULTIPLE DRIVEABILITY CONCERNS UNDER ACCELERATION CAUSED BY IGNITION COIL. *TT | |
| 17810 May 2004 | Power Train | TRANSMISSION FAILURE WHERE THERE IS A LARGE AMOUNT OF METAL OR DEBRIS IN THE PAN. *TT | |
| 17757 Apr 2004 | Exterior Lighting | INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| 03223 Jan 2004 | Electrical System | STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| 03256 Dec 2003 | Engine And Engine Cooling | ENGINE-ROMEO BUILT 4.6L 2V-TICK NOISE FROM ENGINE-ENGINES BUILT BEFORE 9/17/2003. *MJ | |
| 03228 Nov 2003 | Equipment | LACK OF AIR CONDITIONER (A/C) COOLING AND RESTRICTED/REDUCED AIR FLOW THROUGH THE A/C VENTS TYPICALLY DURING EXTENDED IDLING CONDITIONS. *TT | |
| 03203 Oct 2003 | Electrical System | MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT | |
| 03193 Sep 2003 | Exterior Lighting | EXCESSIVE MOISTURE IN THE HEADLAMP ASSEMBLY. *TT | |
| 03181 Sep 2003 | Electrical System | REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| 03164 Aug 2003 | Engine And Engine Cooling | SOME VEHICLES, EQUIPPED WITH THE 4.6L 2V ENGINE, WITH AN ENGINE BUILD DATE PRIOR TO 8/29/03 MAY EXHIBIT AN ENGINE TICK NOISE THAT IS PRESENT AT ALL TEMPERATURES DURING IDLE. 2004 MODELS INCLUDED. *TT | |
| 03157 Aug 2003 | Engine And Engine Cooling | GRINDING TYPE NOISE FROM THE TIMING CHAIN AREA. *TT | |
| 03144 Jul 2003 | Engine And Engine Cooling | ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| 0398 May 2003 | Fuel System | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| 16770 Apr 2003 | Vehicle Speed Control | SPEED CONTROL DEACTIVATION SWITCH ADJUSTMENT SERVICE PROCEDURE. *TT | |
| 0322 Feb 2003 | Engine And Engine Cooling | STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT MIL. *TT | |
| 03261 Jan 2003 | Power Train | NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| 16380 Nov 2002 | Engine And Engine Cooling | SERVICE CYLINDER HEAD GASKET FOR 4.6L APPLICATIONS. *TT | |
| 16401 Nov 2002 | Service Brakes | BRAKE BOOSTER PUSH ROD ADJUSTMENT. BRAKE PEDAL FEEL CONDITION. *MJ | |
| 16412 Nov 2002 | Engine And Engine Cooling | SULPHUR SMELL FROM EXHAUST UNDER INVESTIGATION (QSF). *MJ | |
| 02208 Oct 2002 | Equipment | CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| 02175 Sep 2002 | Air Bags | RESTRAINT SYSTEM-AIR BAG DEPLOYMENT STRATEGY WITH ADVANCED RESTRAINT SYSTEM. *MJ | |
| 02176 Sep 2002 | Exterior Lighting | LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ | |
| 02136 Jul 2002 | Power Train | ON SOME VEHICLES, THE BRAKE SHIFT INTERLOCK MAY BE INOPERATIVE, NOW ALLOWING THE OPERATOR TO MOVE THE SHIFT LEVER FROM THE PARK POSITION. STOP LAMP OPERATION MAY ALSO BE AFFECTED. *TT | |
| 16068 Jul 2002 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION AT 1100-1500 RPM. *TT | |
| 0297 May 2002 | Exterior Lighting | SOME VEHICLES PRODUCED BEFORE 3/5/2002 MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT | |
| 15850 May 2002 | Engine And Engine Cooling | SOME VEHICLES EQUIPPED WITH A 4.6L ROMEO ENGINE MAY EXHIBIT A SLIGHT OIL LEAK OR WEEP AT THE CYLINDER HEAD TO BLOCK JOINT. *TT | |
| 15875 May 2002 | Interior Lighting | SOME RETAIL CUSTOMERS MAY PERCEIVE THE OPERATION OF THE DASH LIGHT DIMMING FEATURE AS BEING FAULTY. *TT | |
| 15881 May 2002 | Engine And Engine Cooling | SUBJECT REGARDING ENGINE STUMBLE / HESITATION COLD ONLY CONDITION. *TT | |
| 15893 May 2002 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT AN INOPERATIVE ENGINE COOLING FAN. *TT | |
| 0274 Apr 2002 | Structure | SOME VEHICLES MAY EXHBIT A SQUEAK / CREAK NOISE COMING FROM THE LEFT FRONT OR RIGHT FRONT DOOR HINGE AREA. *TT | |
| 15793 Apr 2002 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT A SLIGHT OIL LEAK AT THE CYLINDER HEAD TO BLOCK JOINT. *TT | |
| 15802 Apr 2002 | Exterior Lighting | ON SOME VEHICLES THE HEADLAMPS REMAIN ILLUMINATED WHEN WIPERS ARE ACTIVATED AND THEN DEACTIVATED. *TT | |
| 15808 Apr 2002 | Visibility | SOME VEHICLES EQUIPPED WITH A ONE-TOUCH DOWN MODULE OR A DRIVERS DOOR MOUDLE MAY EXHIBIT A CONDITION WHERE THE DRIVERS WINDOW MOVES DOWN WHEN ONE OF THE OTHER WINDOWS IS OPERATED. *TT | |
| 15812 Apr 2002 | Equipment | OVERSPEED WARNING CHIME ACTIVATION WHEN TRAVELLING ABOVE 70 M PH / 110 KPH. *TT | |
| 0254 Mar 2002 | Engine And Engine Cooling | ON SOME VEHICLES EQUIPPED WITH THE 4.6L ENGINE, THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY HYDROPLANE ON THE WATER PUMP PULLEY WHENTHE BELT IS SPLASHED WITH WATER. *TT | |
| 0245 Mar 2002 | Electrical System | INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT | |
| 0222 Feb 2002 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT | |
| 15668 Feb 2002 | Engine And Engine Cooling | CONCERNS WITH HESITATION/STUMBLE , COLD ONLY , WHEN SHIFTING FROM PARK TO DRIVE OR PARK TO REVERSE. *TT | |
| 0214 Jan 2002 | Engine And Engine Cooling | SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT | |
| 01246 Dec 2001 | Engine And Engine Cooling | ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| 15415 Nov 2001 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT AN ENGINE VIBRATION BETWEEN 1100-1300 RPM WHEN THE TRANSMISSION IS PLACED IN EITHER PARK OR NEUTRAL. *TT | |
| 01213 Oct 2001 | Exterior Lighting | VEHICLES MAY EXHIBIT AN INTERMITTENT RAPID FLASHING OF THE TURN SIGNALS. *TT |
Showing 60 of 91 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Test the throttle response and the cruise control on an open road.A surge, a hang in engine speed after lifting off, or cruise that will not set or cancel cleanly are the speed-control complaints on this vehicle.
- Pull and release every belt.A belt that retracts slowly or a buckle that will not latch matches this vehicle's seat-belt cluster.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Mercury Grand Marquis →