Engine
3.0L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 1,404 of 1,426 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 1,220 of 1,426 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Suspension
1,090 complaint records1 fire report9 crash reports
"WENT TO PULL OUT OF MY INTEGRAL GARAGE AND A 6 INCH PIECE OF THE LEFT REAR COIL SPRING FELL OUT ON THE GARAGE FLOOR. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse suspension parts in the directory →
Glass & wipers
104 complaint records2 fire reports1 crash report
"2002 TAURUS, BLOWER WORKED INTERMITTENTLY FOR THE PAST COUPLE OF WEEKS, AND ONLY WORK ON HIGH SPEED. MILEAGE:56,000. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse glass & wipers parts in the directory →
Speed control
77 complaint records16 crash reports
"BRAKE AND ACCELERATOR PEDALS ARE TOO CLOSE TOGETHER, WHEN APPLYING BRAKE CONSUMER APPLIES ACCELERATOR PEDAL AT THE SAME TIME.*AK *TT..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse speed control parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE12033 opened Oct 2012 | closed Jun 2013 | Vehicle Speed Control | Speed control cable damage On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago... |
| EA08018 opened Aug 2008 | closed Jun 2011 | Suspension | Front Suspension Coil Spring Fracture To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. |
| RP03001 opened Oct 2003 | closed Mar 2004 | Service Brakes, Hydraulic | BRAKE/ACCELERATOR PEDAL APPLICATION MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL... |
| RQ03008 opened Oct 2003 | closed Mar 2004 | Exterior Lighting | BRAKE LIGHT SWITCH FAILURE - led to recall 04V106000 FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 04V106000 | Exterior Lighting | CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. | Normally free |
| 03V087000 | Visibility | CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. | Normally free |
| 02V266000 | Service Brakes, Hydraulic | CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2004092 2004-03-12 | Lights And Instruments | 70,813 | On certain vehicles, a malfunctioning stop lamp switch and/or associated wiring may render the stop lamps inoperable or cause them to stay on all the time. |
| 2002187 2002-10-11 | Other | 40,145 | On certain vehicles equipped with adjustable pedals, the manufacturing process of the subject Taurus adjustable pedal assembly resulted in variability in lateral pedal spacing ranging from 41mm to 85mm. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| TSB 20-2233 Jul 2020 | Structure | This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. | |
| TSB 19-2026 Feb 2019 | Structure | Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. | |
| CSP-13B04 Jun 2013 | Vehicle Speed Control | FORD: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPEED CONTROL CABLE IS SUSCEPTIBLE TO DAMAGE AND CAN DISCONNECT DURING HOOD MAINTENANCE AND ALSO INTERFERE WITH FULL THROTTLE RETURN TO IDLE AFTER RELEASING ACCELERATOR PEDAL. MODELS 2000-2003 TAURUS, SABLE. *PE | |
| 04208 Jan 2006 | Engine And Engine Cooling | CAMSHAFT TICK NOISE - 3.0L 4V ENGINE ONLY. *TT | |
| 05224 Nov 2005 | Latches/Locks/Linkages | POWER LOCK CONCERNS - SERVICE TIP. *TT |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 05227 Nov 2005 | Visibility | POWER WINDOW CONCERNS - SERVICE TIP. *TT | |
| 052212 Nov 2005 | Engine And Engine Cooling | BUCK/JERK AND MISS DURING DRIVE CYCLE ABOVE 3000 RPM - NO DTC - 3.0L 2V GAS AND FFV ENGINE. *TT | |
| 18719 Jul 2005 | Fuel System | MALFUNCTION INDICATOR LAMP COMING ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175 (FUEL SYSTEM TOO RICH OR LEAN). *TT | |
| 042421 Jun 2005 | Seat Belts | SAFETY BELT RETRACTION SPEED. *TT | |
| 18614 May 2005 | Engine And Engine Cooling | SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT | |
| 18471 Mar 2005 | Equipment | RKE INOPERATIVE. *EH | |
| 05310 Feb 2005 | Seat Belts | SAFETY BELT WEB STOP BUTTON SERVICE. *EH | |
| 18411 Feb 2005 | Electrical System | MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0133, P1131 OR P2195. *TT | |
| 04251 Dec 2004 | Structure | ALUMINUM CORROSION - SERVICE TIP. *TT | |
| 042514 Dec 2004 | Electrical System | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0316 OR P030X - NO CRANK BATTERY DISCHARGED. *TT | |
| 04189 Dec 2004 | Visibility | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| 042107 Dec 2004 | Power Train | GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT | |
| 04223 Nov 2004 | Visibility | GRUNTING NOISE FROM FRONT POWER WINDOW GLASS IS POWERED TO THE FULL UP POSITION. *EH | |
| 04174 Sep 2004 | Electrical System | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS. VARIOUS MODELS INCLUDING 2004 F-SERIES. *TT | |
| 041712 Sep 2004 | Electrical System | MALFUNCTION INDICATOR LAMP MIL AND DIAGNOSTIC TROUBLE CODES DTCS P0172 P0175. *EH | |
| 031506 Aug 2004 | Visibility | WATER IN THE BLOWER CASE OR ON THE PASSENGER SIDE FLOOR, AN INOPERATIVE CLIMATE CONTROL BLOWER MOTOR, A MOTOR THAT OPERATES ON HIGH SPEED ONLY, AND/OR A BLOWER MOTOR RESISTOR FAILURE. VEHICLES BUILT 5/1/2001 TO 12/15/2003. *TT | |
| 041514 Aug 2004 | Visibility | REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR. *TT | |
| 17358 Aug 2004 | Power Train | GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT | |
| 17960 Aug 2004 | Electrical System | MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0171/P0174, P1131/P1151, AND/OR P2195/P2197 IN CONTINUOUS MEMORY. *TT | |
| 031501 Jul 2004 | Visibility | INOPERATIVE ELECTRIC REAR WINDOW DEFROSTER (HEATED BACKLITE) GRID LINES, INTEGRAL ANTENNA CONCERNS. *TT | |
| 04111 Jun 2004 | Electrical System | STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| 02M01 Jun 2004 | Engine And Engine Cooling | CUSTOMER SATISFACTION PROGRAM 02M01 SUPPLEMENT #4. CERTAIN FORD 2000 THROUGH 2003 VEHICLES EQUIPPED WITH A TUBE-MOUNTED EGR PRESSURE SENSOR - ADDITIONAL EGR PRESSURE SENSOR WARRANTY COVERAGE. *TT SUPPLEMENT #3. *MJ SUPPLEMENT #6. *TT | |
| 17681 Apr 2004 | Equipment | AUTOLOCKS AND (RKE) REMOTE KEYLESS ENTRY INOPERATIVE. *TT | |
| 17703 Apr 2004 | Engine And Engine Cooling | TICKING NOISE FROM LEFT CYLINDER HEAD WITH WARM ENGINE. *TT | |
| 17564 Feb 2004 | Fuel System | FUEL GAUGE DOES NOT READ FULL AFTER FILLING TANK. *MJ | |
| 0415 Jan 2004 | Engine And Engine Cooling | LOWER ENGINE OIL LEAKS 3.0L 2V VULCAN ENGINE. DIAGNOSTIC SERVICE TIPS. *TT | |
| 03223 Jan 2004 | Electrical System | STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401. ADDITIONAL SYMPTOMS MAY INCLUDE RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY. *TT | |
| 17503 Jan 2004 | Engine And Engine Cooling | SURGE AT A STEADY SPEED BETWEEN 35 AND 45 MPH WITH NO OTHER DRIVEABILITY CONCERNS. *TT | |
| 17416 Dec 2003 | Fuel System | FUEL GAUGE DOES NOT READ FULL. *MJ | |
| 17434 Dec 2003 | Engine And Engine Cooling | MALFUNCTION INDICATOR LAMP (MIL) ON WITH CONTINUOUS MEMORY DIAGNOSTIC TROUBLE CODES (DTC'S) P0172/P0175 (SYSTEM TOO RICH). *TT | |
| 17355 Nov 2003 | Fuel System | FUEL GAUGE WHICH DOES NOT READ COMPLETELY FULL WHEN THE FUEL TANK IS FILLED. *TT | |
| 17281 Oct 2003 | Vehicle Speed Control | SURGE AT CRUISE. *TT | |
| 03181 Sep 2003 | Electrical System | REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| 17224 Sep 2003 | Engine And Engine Cooling | INTERMITTENT ROLLING IDLE ON VEHICLES EQUIPPED WITH A 3.0L 2-VALVE ENGINE. *TT | |
| 17225 Sep 2003 | Steering | STEERING COLUMN LOCK DISCONTINUED. *TT | |
| 17234 Sep 2003 | Engine And Engine Cooling | ENGINE OIL LEAKS FROM THE FILTER AREA ON VEHICLES WITH A 3.0L 2-VALVE ENGINE. *TT | |
| 17094 Aug 2003 | Suspension | RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT | |
| 03144 Jul 2003 | Engine And Engine Cooling | ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT | |
| 03148 Jul 2003 | Power Train | NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| 16982 Jul 2003 | Engine And Engine Cooling | CLUNKING/POPPING NOISE FROM THE PASSENGER SIDE OF THE ENGINE COMPARTMENT UPON ACCELERATION AND/OR DECELERATION. *TT | |
| 03123 Jun 2003 | Power Train | TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT | |
| 03111 Jun 2003 | Engine And Engine Cooling | ENGINE COOLING FAN INDUCED BODY BOOM, ROUGH ENGINE IDLE SENSATION OR UNUSUAL ENGINE NOISE AT IDLE WHEN THE ENGINE COOLING FAN IS IN THE HIGH SPEED MODE. *TT | |
| 0398 May 2003 | Fuel System | MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT | |
| 0361 Mar 2003 | Engine And Engine Cooling | MALFUNCTION INDICATOR LAMP ON WITH OR WITHOUT ROUGH RUNNING, LACK OF POWER, SURGE OR POOR FUEL ECONOMY WITH DIAGNOSTIC TROUBLE CODES P0401, P0402, P1400, P1401. *TT *JB | |
| 16678 Mar 2003 | Power Train | AX4S TRANSAXLE MAY EXHIBIT NO REVERSE ENGAGEMENT CONDITION. *TT *JB | |
| 16679 Mar 2003 | Fuel System | NEW PUSH TYPE FUEL CLIP AND CONNECTOR REMOVAL INSTRUCTIONS. *TT *JB | |
| 16710 Mar 2003 | Suspension | RATTLING OR CLUNKING NOISE FROM THE FRONT SUSPENSION UNDER NORMAL DRIVING CONDITIONS. *TT *JB | |
| 0335 Feb 2003 | Engine And Engine Cooling | IDLE AIR CONTROL (IAC) VALVE DIAGNOSTIC SERVICE TIPS. *TT | |
| 0322 Feb 2003 | Engine And Engine Cooling | STREAMLINED DIAGNOSTIC PROCEDURE FOR VEHICLES WITH MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0401, P0402, P1400 OR P1401, OR RUNS ROUGH, LACKS POWER, SURGE, POOR FUEL ECONOMY, AND THE ABOVE LISTED DTCS WITHOUT MIL. *TT | |
| 0325 Feb 2003 | Visibility | GRUNTING NOISE FROM FRONT POWER WINDOW AFTER GLASS IS POWERED TO THE FULL-UP POSITION. *TT | |
| 16613 Feb 2003 | Engine And Engine Cooling | VEHICLES WITH VERY LOW ODOMETER MILES, MAY EXHIBIT A HIGHER THAN NORMAL TEMPORARY START-UP FAST IDLE (1600-2500 RPM THAT DECREASES SLOWLY). NO SERVICE NECESSARY. *TT | |
| 02111 Nov 2002 | Fuel System | FUEL PRESSURE RELIEF VALVE (SCHRADER VALVE) DISCONTINUED. *TT | |
| 02236 Nov 2002 | Visibility | ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT | |
| 02221 Nov 2002 | Engine And Engine Cooling | ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ | |
| 02223 Nov 2002 | Engine And Engine Cooling | DRIVEABILITY-MALFUNCTION INDICATOR LAMP (MIL) WITH P0316 WHEN USING WINTER BLEND REFORMULATED FUELS AT TEMPERATURES ABOVE 50 DEGREES F (10 DEGREES C) DURING WINTER MONTHS-ROUGH OR ROLLING IDLE AFTER HOT SOAK RESTART P0191. |
Showing 60 of 95 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Find the roughest road nearby.Clunks over bumps, a droning hum that changes when the car leans, or a corner that sits low are this vehicle's suspension complaints. Wheel bearings and control arm bushings lead the parts list.
- Run the wipers and washers, and test every window.Slow or stuck regulators, streaking wipers, and windshield cracks are this vehicle's visibility complaints.
- Test the throttle response and the cruise control on an open road.A surge, a hang in engine speed after lifting off, or cruise that will not set or cancel cleanly are the speed-control complaints on this vehicle.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford Taurus →