Engine
2.0L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 177 of 182 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 93 of 182 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Air bags
116 complaint records23 crash reports
"WAS INVOLVED IN A HEAD ON COLLISION AT 30 MPH. THE AIRBAGS NEVER DEPLOYED. IS THERE A SPEED AT WHICH THE AIRBAGS ARE SUPPOSED TO DEPLOY?*JB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse air bags parts in the directory →
Engine & cooling
16 complaint records1 fire report2 crash reports
"OIL FILTER GASKET WAS STUCK TO THE ENGINE CLOCK. AS A RESULT, A LEAK DEVELOPED, AND OIL BEGAN TO SPRAY ALL OVER THE VEHICLE, AND THE ENGINE SEIZED. *AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Seat belts
13 complaint records2 crash reports
"WHILE DRIVING 35-45 MPH AND TURNING TO THE LEFT CONSUMER'S VEHICLE WAS INVOLVED IN A SIDE IMPACT CRASH. SEAT BELT DIDN'T HOLD THE DRIVER, AND AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS ISSUED.*AK..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse seat belts parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE04041 opened Apr 2004 | closed Jul 2004 | Fuel System, Gasoline | POST-CRASH FUEL TANK LEAK - led to recall 04V370000 PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 05V479000 | Air Bags | CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. | Normally free |
| 05V395000 | Air Bags | CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. | Normally free |
| 04V370000 | Fuel System, Gasoline | DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. | Normally free |
| 04V208000 | Fuel System, Gasoline | DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE... | Normally free |
| 03V322000 | Air Bags | ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2004152 2004-05-06 | Fuel System | 8,255 | On certain vehicles, a fuel vapour tube hose clamp may not be positioned properly. The spring-type hose clamp contains ears that may be squeezed together with a tool to increase the diameter of the clamp to allow it to be installed on the... |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| DTN DCS Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. | |
| DTN DL Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). | |
| 25-BD-012H TSB Nov 2025 | Exterior Lighting | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 24-BD-001H Feb 2024 | Visibility | This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side... | |
| 23-EM-005H Oct 2023 | Engine And Engine Cooling | This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. |
Show 51 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 23-BD-007H Apr 2023 | Structure | Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. | |
| 23-BD-002H Jan 2023 | Visibility | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 22-EM-010H Jul 2022 | Engine And Engine Cooling | Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement. | |
| 22-GI-006H Jul 2022 | Tires | Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. | |
| 21-AT-006H May 2021 | Power Train | Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicleâÂÂs ownerâÂÂs manual. ï· Use of other ATF may result in improper shift quality or other drivability conditions. | |
| 21-EM-004H Mar 2021 | Engine And Engine Cooling | This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps. | |
| 21-BR-002H Mar 2021 | Service Brakes | This bulletin provides best practice recommendations when performing brake service procedures. | |
| 21-EM-003H Mar 2021 | Engine And Engine Cooling | This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below. | |
| 20-BR-002H Nov 2020 | Service Brakes | This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area. | |
| 20-SS-004H Nov 2020 | Wheels | This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the âTire Balance Data Sheetâ must be fully completed including imbalance and Road Force Variation (RFV) data. | |
| 20-BD-014H Jul 2020 | Exterior Lighting | This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 20-SS-002H(1) May 2020 | Wheels | This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. | |
| 20-BD-007H-1 May 2020 | Equipment | This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products. | |
| 20-EE-003H Apr 2020 | Equipment | This bulletin provides information on identifying dealer stock vehicles with either: ⢠A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. ⢠A 30 Day alert - vehicle has not started and reported an SOC in 30 days. | |
| 20-AT-016H Apr 2020 | Equipment Adaptive/Mobility | The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: | |
| 20-BD-007H Mar 2020 | Equipment Adaptive/Mobility | This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products. | |
| 20-SS-001H Feb 2020 | Suspension | This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years. | |
| 20-BE-001H Jan 2020 | Electrical System | This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. | |
| 19-BE-011H-1 Nov 2019 | Lane Departure | The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. | |
| 19-GI-006H Oct 2019 | Equipment Adaptive/Mobility | This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number. | |
| 5NP-S9D9P-10 Sep 2016 | Power Train | THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT). | |
| 5NP-B6E2P-10 Aug 2016 | Power Train | "THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET (ERASE) AND RELEARN THE PCM/TCM ADAPTIVE VALUES. | |
| TSB-09-AT-018 Oct 2009 | Engine And Engine Cooling | HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED; TRANSAXLE HELD IN 3RD GEAR FAIL SAFE. | |
| TSB-09-AT-013 Jul 2009 | Power Train | HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). | |
| TSB0740010 May 2008 | Power Train | AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED UPSHIFT OR DOWNSHIFT - GDS ANALYSIS. *PE | |
| 0740009 Aug 2007 | Power Train | AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. *KB | |
| 0640018 Dec 2006 | Power Train | AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB | |
| 0590003 Mar 2006 | Electrical System | OCCUPANT CLASSIFICATION SYSTEM (OCS) REPROGRAMMING. PASSENGER AIR BAG OFF INDICATOR LIGHT MAY NOT TURN OFF OR MAY SWITCH ON AND OFF WHEN SOME SMALLER STATURE ADULTS ARE SEATED IN THE RIGHT FRONT PASSENGER SEAT. *TT | |
| 0540008 Dec 2005 | Power Train | AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC | |
| 158 Nov 2005 | Power Train | REPROGRAMS ARE AVAILABLE FOR AUTOMATIC TRANSAXLE DRIVEABILITY ISSUES. TECHNET TIMES. HYUNDAI. *TT | |
| 0401003 Sep 2005 | Fuel System | FUEL PUMP REPLACEMENT. *MR SERVICE CAMPAIGN T13. *TT | |
| 01011901 Aug 2005 | Electrical System | AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM | |
| 153 May 2005 | Air Bags | OCCUPANT CLASSIFICATION SYSTEM (OCS) REPROGRAMMING. FIX-IT-RIGHT. HYUNDAI TECHNET TIMES. *TT | |
| 0590003 Apr 2005 | Air Bags | THE OCCUPANT CLASSIFICATION SYSTEM (OCS) PASSENGER AIR BAG OFF INDICATOR LIGHT MAY NOT TURN OFF OR MAY SWITCH ON AND OFF WHEN SOME SMALLER STATURE ADULTS ARE SEATED IN THE RIGHT FRONT PASSENGER SEAT. *TT FIT-IT-RIGHT OCCUPANT CLASSIFICATION SYSTEM (OCS) REPROGRAMMING. *TT | |
| 0540002 Apr 2005 | Power Train | PCM REPROGRAMMING INSTRUCTIONS FOR MILD DRIVELINE BUMP BETWEEN 2-10 MPH. *SC | |
| 0501002 Feb 2005 | Air Bags | AIR BAG CONTROL UNIT (ACU) REPROGRAMMING PROCEDURE (SERVICE CAMPAIGN 919). *TT | |
| 0450009 Sep 2004 | Power Train | FRONT KNUCKLE ASSEMBLY SNAP RING CONFIGURATION REVISED. *TT | |
| 0497002 Aug 2004 | Equipment | FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT | |
| 0440012 Aug 2004 | Power Train | AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. TO INCLUDE 2005 ELANTRA. *TT | |
| 0440011 Aug 2004 | Power Train | AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED ENGAGEMENT INTO DRIVE OR REVERSE. TO INCLUDE 2005 ELANTRA. *TT | |
| 0804 Aug 2004 | Equipment | FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM | |
| 0490010 Jun 2004 | Visibility | POWER WINDOW REGULATOR MOTOR.*MR | |
| 0450007 Jun 2004 | Steering | POWER STEERING PRESSURE HOSE TO OIL PUMP BOLT TORQUE SPECIFICATION SHOP MANUAL CORRECTION. *TT | |
| 0480001 May 2004 | Structure | REAR SPOILER FASTENER PART NUMBER INFORMATION. *MR | |
| 0490004 Mar 2004 | Electrical System | OCCUPANT CLASSIFICATION SYSTEM (OCS) PARTS REPLACEMENT. *MR | |
| 0490001 Jan 2004 | Air Bags | DUAL-STAGE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) REPAIR AFTER COLLISION. 2004 ACCENT ALSO INCLUDED. *TT | |
| 0436001 Jan 2004 | Engine And Engine Cooling | THIS BULLETIN DESCRIBES THE CHANGES TO THE ENGINE MANAGEMENT/ENGINE ELECTRICAL SYSTEM. *TT | |
| 033601401 Nov 2003 | Engine And Engine Cooling | SERVICE INFORMATION FOR SULEV (SUPER ULTRA LOW EMISSION VEHICLE) ELANTRA (ONLY APPLIED ON ELANTRA VEHICLES WITH CALIFORNIA EMISSIONS SPECIFICATION AND AUTOMATIC TRANSMISSION). *TT | |
| 0336024 Nov 2003 | Vehicle Speed Control | RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT | |
| 03360142 Nov 2003 | Engine And Engine Cooling | SERVICE INFORMATION FOR SULEAVE ELANTRA (ONLY APPLIED ON ELANTRA VEHICLES WITH CALIFORNIA EMISSIONS SPECIFICATION AND AUTOMATIC TRANSMISSION).*MR | |
| 01011901 | Air Bags | AIRBAG REPROGRAMMING GUIDE. *TT |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Watch the airbag warning light through a full key cycle.It should light on start and go out within seconds. A light that stays on, or never lights at all, means the system needs attention. Run the VIN for inflator recalls specifically.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Pull and release every belt.A belt that retracts slowly or a buckle that will not latch matches this vehicle's seat-belt cluster.
- Run the VIN against open recalls before you negotiate.This vehicle has 5 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Hyundai Elantra →