Engine
3.0L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 317 of 318 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 270 of 318 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Speed control
181 complaint records1 fire report8 crash reports
"GAS PEDAL STICKS WHEN STARTING CAR. VERY STIFF UNTIL YOU TAP SEVERAL TIMES. SEEMS TO BE GETTING PROGRESSIVELY WORSE. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse speed control parts in the directory →
Engine & cooling
43 complaint records2 fire reports
"WHEN THE CAR ISN'T BEING DRIVEN BUT IS ON SOMETIMES THE GAS REVS UP BY ITSELF AND ENGINE JUST KEEPS RUNNING AND THE RPM RUNS UP, THE GAS ALSO ACCELERATES ON ITS OWN AND THE PEDAL STICKS. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Power train
33 complaint records1 crash report
"INSTANT ACCELERATION WHILE DRIVING APPROX.; 40 MPH HAD TO SHIFT TO NEUTRAL AFTER STEPPING ON ACCELERATOR SEVERAL TIMES ENGINE RETURNED TO NORMAL IDLE. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE12005 opened Mar 2012 | closed Oct 2012 | Vehicle Speed Control | Stuck throttle Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 06V119000 | Electrical System | CERTAIN PASSENGER VEHICLES BUILT FOR ONE SPECIFIC FLEET CUSTOMER WERE MODIFIED FOR OPTIONAL HANDS-FREE CELLULAR PHONE OPERATING CAPABILITY. | Normally free |
| 05V520000 | Visibility | ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2005356 2005-11-10 | Other | 13,581 | On certain vehicles, the windshield wiper motor may have been produced without grease applied to the output shaft gear. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| TSB 20-2233 Jul 2020 | Structure | This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. | |
| TSB 19-2026 Feb 2019 | Structure | Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. | |
| SSM 46085 Sep 2016 | Engine And Engine Cooling | The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. | |
| 0607 Dec 2006 | Power Train | EXTENDED WARRANTY COVERAGE FOR VEHICLES WITH HARD START WHEN OPERATING ON E85 FUEL, POWERTRAIN CONTROL MODULE (PCM) CALIBRATION. WARRANTY EXTENDED FOR 10 YEARS OR 100,000 MILES WHICH EVER COMES FIRST. SAMPLE CONSUMER LETTER ATTACHED. *KB | |
| 0655 Jan 2006 | Electrical System | FLEX FUEL - LONG CRANK/HARD START. *TT |
Show 7 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 05224 Nov 2005 | Latches/Locks/Linkages | POWER LOCK CONCERNS - SERVICE TIP. *TT | |
| 05227 Nov 2005 | Visibility | POWER WINDOW CONCERNS - SERVICE TIP. *TT | |
| 041601 Nov 2005 | Engine And Engine Cooling | WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT | |
| 052218 Nov 2005 | Engine And Engine Cooling | SPARK KNOCK, HESITATION ABOVE 3000 RPM, LOSS OF POWER, MISFIRE, AND POSSIBLE ENGINE DAMAGE DUE TO DETONATION AND PRE-IGNITION - 3.0L-2V VULCAN GAS/FFV. *TT | |
| 042421 Jun 2005 | Seat Belts | SAFETY BELT RETRACTION SPEED. *TT | |
| 18583 Apr 2005 | Engine And Engine Cooling | NO START/HARD START/ROUGH RUNNING DURING COLD WEATHER - INCORRECT SEASONAL FUEL BLEND. *TT | |
| 19087 | Electrical System | TENTHS DIGIT NOT DISPLAYED ON ODOMETER AFTER 10,000 MILES/KILOMETERS. *TT |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Test the throttle response and the cruise control on an open road.A surge, a hang in engine speed after lifting off, or cruise that will not set or cancel cleanly are the speed-control complaints on this vehicle.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Run the VIN against open recalls before you negotiate.This vehicle has 2 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford Taurus →