Engine
2.0L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 134 of 135 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 105 of 135 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Air bags
38 complaint records11 crash reports
"I WAS INVOLVED IN AN ACCIDENT WHICH I WAS HIT ON THE DRIVERS SIDE. THE SIDE AIR BAGS DID NOT DEPLOY. THE AIR BAGS IS WAY I BROUGHT THIS VEHICLE. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse air bags parts in the directory →
Engine & cooling
21 complaint records
"2006 HYUNDAI TUCSON GLS 2.7L HAS LEAKING VALVE COVER GASKET CAUSING OIL TO DRIP INTO THE ALTERNATOR CAUSING FAILURE OF ALTERNATOR...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Electrical system
16 complaint records2 fire reports
"2006 HYUNDAI TUCSON GLS 2.7L HAS LEAKING VALVE COVER GASKET CAUSING OIL TO DRIP INTO THE ALTERNATOR CAUSING FAILURE OF ALTERNATOR...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE09003 opened Jan 2009 | closed Apr 2009 | Vehicle Speed Control | STOP LAMP SWITCH FAILURE - led to recall 09V122000 BY LETTER DATED APRIL 15, 2009, HYUNDAI NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 09V122) TO REPLACE THE STOP LAMP SWITCHES ON MANY OF ITS MODEL YEAR 2005-2008 VEHICLES.SEE RECALL 09V122 FOR A COMPLETE LIST. |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 13V113000 | Exterior Lighting | Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz,... | Normally free |
| 09V280000 | Exterior Lighting | HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR... | Normally free |
| 09V122000 | Exterior Lighting | HYUNDAI IS RECALLING 532,633 MY 2006-2007 ACCENT, ENTOURAGE, SONATA, MY 2007 AZERA, ELANTRA AND SANTA FE, MY 2005-2007 TUCSON AND MY 2007-2008 VERACRUZ VEHICLES. | Normally free |
| 07V197000 | Air Bags | ON CERTAIN VEHICLES, STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED THAT A SMALL STATURE ADULT DRIVER NOT WEARING A SEAT BELT AND INVOLVED IN A FRONTAL OR NEAR... | Normally free |
| 06V445000 | Air Bags | ON CERTAIN SPORT UTILITY VEHICLES, DURING STATIC AIR BAG DEPLOYMENT TESTING CONDUCTED BY NHTSA USING FIFTH PERCENTILE FEMALE DUMMIES INDICATED IF A SMALL STATURED ADULT DRIVER, NOT WEARING A SEAT BELT, IS INVOLVED IN A... | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2013325 2013-09-25 | Electrical | 110,104 | On certain vehicles, the stop lamp switch may fail and cause intermittent operation of the brake lights. Failure of the brake lights to illuminate when the brake pedal is depressed could result in a crash causing property damage and/or... |
| 2009120 2009-04-23 | Lights And Instruments | 67,976 | On certain vehicles, the stop lamp switch may have been incorrectly installed during vehicle assembly. This could prevent proper brake lamp operation. |
| 2006293 2006-11-03 | Airbag | 27,123 | On certain vehicles, if a small statured adult driver, not wearing a seatbelt, is involved in a frontal or near frontal crash, deployment of the driver airbag may result in an insufficient margin of compliance as measured by the test dummy... |
| 2005329 2005-10-27 | Label | 490 | Certain vehicles do not comply with the requirements of CMVSS 120. The compliance label does not contain the rim size information as required by the Standard. Correction: Dealers will install an updated compliance label. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| DTN DCS Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. | |
| DTN DL Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). | |
| 25-BD-012H TSB Nov 2025 | Exterior Lighting | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 24-BD-001H Feb 2024 | Visibility/Wiper | This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side... | |
| 23-EM-005H Oct 2023 | Engine And Engine Cooling | This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. |
Show 41 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 23-BD-007H Apr 2023 | Structure | Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. | |
| 23-BD-002H Jan 2023 | Visibility | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 22-EM-010H Jul 2022 | Engine And Engine Cooling | Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement. | |
| 22-GI-006H Jul 2022 | Tires | Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. | |
| 21-AT-006H May 2021 | Power Train | Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicleâÂÂs ownerâÂÂs manual. ï· Use of other ATF may result in improper shift quality or other drivability conditions. | |
| 21-EM-004H Mar 2021 | Equipment | This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps. | |
| 21-BR-002H Mar 2021 | Equipment | This bulletin provides best practice recommendations when performing brake service procedures. | |
| 21-EM-003H Mar 2021 | Engine And Engine Cooling | This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below. | |
| 20-BR-002H Nov 2020 | Service Brakes | This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area. | |
| 20-SS-004H Nov 2020 | Tires | This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the âTire Balance Data Sheetâ must be fully completed including imbalance and Road Force Variation (RFV) data. | |
| 20-BD-014H Jul 2020 | Exterior Lighting | This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 20-SS-002H(1) May 2020 | Wheels | This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. | |
| 20-BD-007H-1 May 2020 | Equipment | This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products. | |
| 20-EE-003H Apr 2020 | Equipment | This bulletin provides information on identifying dealer stock vehicles with either: ⢠A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. ⢠A 30 Day alert - vehicle has not started and reported an SOC in 30 days. | |
| 20-AT-016H Apr 2020 | Equipment | The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: | |
| 20-BD-007H Mar 2020 | Equipment Adaptive/Mobility | This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products. | |
| 20-SS-001H Feb 2020 | Suspension | This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years. | |
| 20-BE-001H Jan 2020 | Electrical System | This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. | |
| 19-BE-011H-1 Nov 2019 | Back Over Prevention | The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. | |
| 19-GI-006H Oct 2019 | Equipment Adaptive/Mobility | This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number. | |
| 19-FL-003H Apr 2019 | Power Train | This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot be removed or overwritten. | |
| 19-DS-001H-1 Feb 2019 | Wheels | This bulletin provides information for inspecting and replacing front or rear wheel bearing hub assemblies for any model Hyundai vehicle. This procedure is applicable when there is noise such as a whirring/roaring/grinding/rumbling/etc. | |
| 5NP-S5Q6C-05 Apr 2018 | Fuel System | This bulletin describes the procedure to replace the fuel tank bands on certain 2005-2007 MY Tucson (JM) vehicles. The fuel tank bands may become corroded over time and cause the fuel tank to become loose. | |
| 5NP-H6A7M-03 Feb 2017 | Structure | In some areas, a vehicle's underbody may exhibit corrosion due to road salt usage. As a precautionary measure, cavity wax coating is applied to the internal surfaces of underbody components, and an undercoating spray is applied to the bottom exterior surfaces of specified... | |
| 5NP-S9D9P-10 Sep 2016 | Power Train | THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT). | |
| 5NP-B6E2P-10 Aug 2016 | Power Train | "THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET (ERASE) AND RELEARN THE PCM/TCM ADAPTIVE VALUES. | |
| 14-01-018 Jul 2014 | Structure | CAVITY WAX PREVENTATIVE PROCEDURE TO APPLY TO FRONT AND REAR UNDER BODY. *LJ | |
| 14-01-018 May 2014 | Equipment | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| TSB-09-AT-018 Oct 2009 | Engine And Engine Cooling | HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED; TRANSAXLE HELD IN 3RD GEAR FAIL SAFE. | |
| TSB-09-AT-013 Jul 2009 | Power Train | HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). | |
| TSB-09-01-018 Jun 2009 | Exterior Lighting | HYUNDAI SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. STOP LAMP SWITCH REPLACEMENT (CAMPAIGN 092). THIS BULLETIN DESCRIBES THE PROCEDURE TO REMOVE, REPLACE, AND ADJUST THE STOP LAMP SWITCH. *PE | |
| 08-FL-006 May 2008 | Engine And Engine Cooling | TUCSON P0171, P0174 (SYSTEM TOO LEAN) AIR FILTER HOUSINGS FOR 2.0L AND 2.7L ENGINES. *PE | |
| 0701001 Jan 2007 | Air Bags | DRIVER AIR BAG COVER MODULE REPLACEMENT. *KB | |
| 0650016 Dec 2006 | Electrical System | ESC (ESP) HECU AND YAW RATE SENSOR INTERCHANGEABILITY. *KB | |
| 0620004 Nov 2006 | Engine And Engine Cooling | 2.0L CYLINDER HEAD AND TIMING BELT SYSTEM - PART UPDATE. *KB | |
| 0650003 Mar 2006 | Service Brakes | ABS PUMP SELF-CHECK NOISE. *TT | |
| 0601001 Jan 2006 | Electrical System | ESC (OR ESP) ECM (ELECTRONIC CONTROL MODULE) REPROGRAMMING PROCEDURE - CAMPAIGN 922. *TT | |
| 0550013 Dec 2005 | Tires | TIRE PRESSURE MONITORING SYSTEM (TPMS) AND SCAN TOOL INFORMATION. *TT | |
| 0550014 Dec 2005 | Tires | TPMS SENSOR REMOVAL AND INSTALLATION SERVICE PROCEDURES. *TT | |
| 0550011 Nov 2005 | Equipment | HI SCAN PRO HARDWARE ISSUE-FALSE CONTROL AREA NETWORK (CAN) DIAGNOSTIC TROUBLE CODES (DTCS). *AK | |
| 01011901 Aug 2005 | Tires | TIRE PRESSURE MONITORING SYSTEM WILL BE AVAILABLE IN THE 2006 TUCSON. *NM |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Watch the airbag warning light through a full key cycle.It should light on start and go out within seconds. A light that stays on, or never lights at all, means the system needs attention. Run the VIN for inflator recalls specifically.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Run the VIN against open recalls before you negotiate.This vehicle has 5 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Hyundai Tucson →