Engine
3.7L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 236 of 236 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 185 of 236 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Electrical system
78 complaint records5 fire reports1 crash report
"WHEN HEADLIGHTS ARE SWITCHED FROM LOW TO HIGH BEAM OR HIGH TO LOW BEAM , ONE HEADLIGHT GOES OFF TEMPORARILY. IT CAN LAST SECONDS OR DAYS...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Fuel system
74 complaint records
"I OWN A 2007 DODGE NITRO AND HAVE FOR 3 YEARS. GAS OVERFLOWS FROM THE GAS TANK EVERY TIME I FILL UP. THIS IS A SERIOUS SAFETY ISSUE. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Body & structure
29 complaint records
"THE DRIVER'S SIDE DOOR HANDLE SNAPPED APART, BREAKING THE PLASTIC HANDLE CLOSE TO THE INSIDE OF THE DOOR WHERE IN CONNECTS. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse body & structure parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP14004 opened Sep 2014 | closed Jul 2015 | Electrical System | Totally Integrated Power Module Failure In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM)... |
| PE07027 opened May 2007 | closed Aug 2007 | Power Train | ENGINE STALLING & ELECTRIC POWER LOSS - led to recall 07V291000 ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES... |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2020311 2020-07-08 | Airbag | 188,249 | Issue: On certain vehicles, the emblem on the steering wheel could become loose. If this happens, the emblem or its retainers could become projectiles when the airbag inflates in a crash. |
| 2013102 2013-04-05 | Powertrain | 1,036 | On certain vehicles, the tunnel heat shield may drop down and rub on the drive shaft, which could eventually result in the drive shaft breaking and loss of motive power. |
| 2009324 2009-11-12 | Other | 9,083 | On certain vehicles, high usage of the variable pause windshield wiper function (delay mode) may eventually affect primary wiper function, rendering the wiper system inoperable. |
| 2008372 2008-10-10 | Other | 720 | On certain vehicles equipped with a manual transmission, the park brake lever clutch drum may distort and reduce the effectiveness of the park brake system. |
| 2007305 2007-09-17 | Brakes | 30,468 | On certain vehicles, software programmed into the Antilock Brake System (ABS) electronic control module may allow a momentary delay in braking when coasting up a hill during certain conditions. This could cause a crash without warning. |
Show 3 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2007221 2007-07-05 | Other | 8,804 | On certain vehicles, the Totally Integrated Power Module (TIPM) was programmed with software that may allow the engine to stall under certain operating conditions. This could cause a crash without warning. |
| 2006373 2006-12-27 | Brakes | 5,886 | On certain vehicles, the Anti-lock Brake System (ABS) control module software may cause the rear brakes to lock-up during certain braking conditions. This could result in a loss of vehicle control and cause a crash without warning. |
| 2006218 2006-09-08 | Powertrain | 345 | On certain vehicles equipped with the 42RLE automatic transmission, the Powertrain Control Module (PCM) may cause a momentary lock up of the drive wheels if the vehicle is traveling over 65 kph and the operator shifts from drive to neutral... |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. | |
| 23-015-20 Apr 2020 | Equipment | Disinfectant Solution Recommended for COVID-19 | |
| 08-049-20 Apr 2020 | Equipment | Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary. | |
| 31-006-19 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 31-003-19 Nov 2019 | Equipment | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. |
Show 10 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 31-005-19 Nov 2019 | Equipment | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 3100619 Nov 2019 | Equipment | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 3100319 Nov 2019 | Structure | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 3100519 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 9003687 Mar 2017 | Seat Belts | Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| 68332810 Sep 2016 | Engine And Engine Cooling | Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. | |
| R2118796A Feb 2016 | Engine And Engine Cooling | Valve Body. These may cause over drive cycling. | |
| RL108213A$ Jan 2016 | Engine And Engine Cooling | NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~ | |
| 9003215 Feb 2015 | Engine And Engine Cooling | Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. | |
| 9002519 Mar 2013 | Equipment | 82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois,... |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Walk the body slowly in daylight.Panel gaps, rust at the rockers and wheel arches, and cracked trim are this vehicle's structure complaints. Open and close the liftgate or trunk and look at the latch area.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Dodge Nitro 4X4 →