Engine
3.8L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 339 of 339 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 284 of 339 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Fuel system
119 complaint records
"WHILE REFILLING THE GAS TANK, AS THE GAS PUMP SHUTS OFF IT SPILLS GAS ALL OVER THE FLOOR. IT ALMOST SPILLED ALL OVERON ME...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Electrical system
73 complaint records
"AIR BAG LIGHT AND CHIME KEEP GOING OFF . I DON'T FEEL THAT ITS SAFE AND I'M DOCUMENTING IT IN CASE IT FAILS TO WORK AND I DON'T MAKE IT ...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Engine & cooling
48 complaint records2 fire reports
"I WAS DRIVING DOWN THE ROAD THE JEEP STARTED SPITTING AND SPUTTERING I PULLED OVER TO SEE WHAT WAS GOING ON AS I GO TO GET OUT IT BURSTED INTO FLAMES FROM UNDER THE HOOD THEN QUICKLY SPREAD THROUGHOUT THE WHOLE JEEP QUICKLY..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA15007 opened Dec 2015 | closed Jul 2016 | Air Bags | Air Bag Clockspring Wiring Failure - led to recall 16V290000 On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a... |
| PE15025 opened Jun 2015 | closed Dec 2015 | Air Bags | Air Bag Clockspring Wiring Failure In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag... |
| DP14004 opened Sep 2014 | closed Jul 2015 | Electrical System | Totally Integrated Power Module Failure In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM)... |
| PE11019 opened May 2011 | closed Nov 2011 | Air Bags | Airbag Clockspring Failure - led to recall 13V176000 In its July 29, 2011 response to ODI's May 27, 2011 information request letter, Chrysler provided 153 MY 2007-2008 owner reports, additional to the 28 ODI Vehicle Owner Questionnaires (VOQs), which related to the illumination of the air bag light (ABL) due to... |
| PE10032 opened Aug 2010 | closed Feb 2011 | Fuel System, Other | Fuel Spill During Refueling ODI found the rate of warranty claims related to fuel spit back on the subject vehicles is lower than other vehicles previously recalled to correct defects related to fuel spit back.Although the rate of complaints reported to the agency on the subject... |
Show 3 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE09037 opened Aug 2009 | closed Nov 2009 | Power Train | TRANSMISSION OVERHEATING / FIRE - led to recall 09V436000 IN A LETTER DATED NOVEMBER 3, 2009, CHRYSLER GROUP LLC (CHRYSLER), NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL OF APPROXIMATELY 161,000 MODEL YEAR (MY) 2007 AND 2008 JEEP WRANGLER VEHICLES BUILT WITH AUTOMATIC TRANSMISSIONS.CHRYSLER STATED THAT THESE... |
| EQ09006 opened Jul 2009 | closed Aug 2009 | Equipment | TOW BAR ASSEMBLY FAILURE THE DEFECTIVE TOW BAR ASSEMBLIES INVOLVED IN THIS RECALL WERE SUPPLIED TO CHRYSLER FOR USE ON SOME OF ITS JEEP WRANGLER VEHICLES.THE PURPOSE OF THIS INVESTIGATION WAS TO IDENTIFY ANY ADDITIONAL PURCHASERS OF IDENTICAL OR SUBSTANTIALLY SIMILAR DEFECTIVE... |
| PE07027 opened May 2007 | closed Aug 2007 | Power Train | ENGINE STALLING & ELECTRIC POWER LOSS - led to recall 07V291000 ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES... |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2016265 2016-05-27 | Airbag | 459,492 | On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag. |
| 2016216 2016-05-12 | Airbag | 35,110 | Certain vehicles which are subjected to dusty environments and/or extensive usage with top/doors removed, the clockspring assembly for the driver's airbag may become damaged and fail due to dust ingress. |
| 2010185 2010-06-04 | Brakes | 28,958 | On certain vehicles, the right and left front inner fender liners could contact the right front and left rear brake tubes respectively, which could cause a partial loss of braking at the affected wheel. |
| 2009333 2009-11-19 | Powertrain | 12,695 | On certain vehicles equipped with an automatic transmission, operating under rigorous off-road conditions could cause the transmission fluid temperature to elevate to the point of causing transmission failure. |
| 2007305 2007-09-17 | Brakes | 30,468 | On certain vehicles, software programmed into the Antilock Brake System (ABS) electronic control module may allow a momentary delay in braking when coasting up a hill during certain conditions. This could cause a crash without warning. |
Show 2 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2007221 2007-07-05 | Other | 8,804 | On certain vehicles, the Totally Integrated Power Module (TIPM) was programmed with software that may allow the engine to stall under certain operating conditions. This could cause a crash without warning. |
| 2006373 2006-12-27 | Brakes | 5,886 | On certain vehicles, the Anti-lock Brake System (ABS) control module software may cause the rear brakes to lock-up during certain braking conditions. This could result in a loss of vehicle control and cause a crash without warning. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. | |
| 23-015-20 Apr 2020 | Equipment | Disinfectant Solution Recommended for COVID-19 | |
| 08-049-20 Apr 2020 | Equipment | Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary. | |
| 31-006-19 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 31-003-19 Nov 2019 | Equipment | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. |
Show 9 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 31-005-19 Nov 2019 | Equipment | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 3100619 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 3100319 Nov 2019 | Structure | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 3100519 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 9003687 Mar 2017 | Seat Belts | Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| R2118796A Feb 2016 | Engine And Engine Cooling | Valve Body. These may cause over drive cycling. | |
| RL108213A$ Jan 2016 | Engine And Engine Cooling | NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~ | |
| 9003215 Feb 2015 | Engine And Engine Cooling | Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. | |
| 9002519 Mar 2013 | Equipment | 82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois,... |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Jeep Wrangler 2-DR 4X4 →