Engine
1.6L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 66 of 66 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 55 of 66 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Engine & cooling
30 complaint records
"RUNNING HOT SMOKING LOUD TICKING TURNING OF IN THE MIDDLE OF HIGH WAY STEERING WHEEL LOCKED & NOW ITS NOT CRANKING UP AT ALL. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Electrical system
16 complaint records1 crash report
"DRIVING 45 MPH CAR SUDDENTLY SHUTS OFF COAST TO SIDE OF HIGHWAY VERY DIFICULT TO STEER WAITED 5 TO 10 MINUTES RESTARTED CAR AND DROVE HOME. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Power train
9 complaint records
"WHEN I DRIVE DOWN THE STREET MY CAR WILL GO OUT OF DRIVE THE I WILL HAVE TO STOP THE CAR THEN TURN IT OFF. THEN TURN IT BACK ON...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 14V460000 | Service Brakes, Hydraulic | General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Aveo and 2009 Pontiac G3 vehicles. | Normally free |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIP4902W Sep 2026 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. | |
| PIT3271Q Apr 2026 | Unknown Or Other | This preliminary information communicates information about how to determine if a wheel and tires size change is available. | |
| PIP4902V Mar 2026 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. | |
| PIP6104 Mar 2026 | Unknown Or Other | This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect. | |
| PIP4902U Jan 2026 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIT5214G Nov 2025 | Unknown Or Other | This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical... | |
| 13598 Sep 2025 | Unknown Or Other | New Vehicle Monitoring Programs Section in IVH | |
| PIC5650M Aug 2025 | Unknown Or Other | This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. | |
| PIP5601C Jul 2025 | Unknown Or Other | This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC. | |
| PIP4902S Jun 2025 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. | |
| 25-NA-156 Jun 2025 | Wheels | This service bulletin provides information on Tire Sidewall Irregularities. | |
| 00-06-01-026R Jun 2025 | Engine | This service bulletin provides information on replacing the intake manifold when the engine is replaced after severe internal engine damage. | |
| PIT5074R May 2025 | Unknown Or Other | This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads. | |
| 23-NA-153 May 2025 | Engine | The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay. | |
| PIT5962B Dec 2024 | Unknown Or Other | This Preliminary information communicates a GM part number for reflective high temperature heat or insulating tape when repairing wiring harnesses. | |
| 04-06-01-029K Oct 2024 | Steering | This informational bulletin explains Unscheduled Supplemental Services and the importance of GM Simplified Maintenance Schedules. | |
| 10-00-89-009F Oct 2024 | Unknown Or Other | This service bulletin provides information on key code security rules and information on GM keycode look-up applications (U.S). | |
| 01-06-01-011Q Oct 2024 | Engine | This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption. | |
| 20-NA-132 Oct 2024 | Electrical System | This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements. | |
| 07-00-89-037T Oct 2024 | Unknown Or Other | This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs. | |
| 04-06-04-051J Sep 2024 | Engine | This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive. | |
| 23-NA-219 Sep 2024 | Structure | This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories. | |
| 20-NA-138 Sep 2024 | Engine | This bulletin provides information on Policies Applicable to All U.S. Dealers for Engine and Transmission Assembly Replacement Under Warranty, Policy or Customer Enthusiasm and information on Submission of Warranty Transaction in Global Warranty Management. | |
| 08-07-30-026I Sep 2024 | Power Train | This service bulletin provides information on some vehicles that may rock or move slightly forward or rearward while in Park at start up after cold soak. This condition may be accompanied by a clunk noise. | |
| 18-NA-146 Sep 2024 | Unknown Or Other | This warranty administration bulletin provides policy information, proper labor operation selection and causal part identification for warranty transactions (U.S. Only). | |
| 02-00-89-002X Sep 2024 | Unknown Or Other | This service bulletin provides information for dealers/technicians on When and How to Submit a Field Product Report (FPR) (U.S. and Canada Dealers Only). | |
| PIT3271P Sep 2024 | Unknown Or Other | This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. | |
| 24-NA-174 Aug 2024 | Unknown Or Other | The bulletin provides direction on how to locate the Temporary Service Part (TSP) form in GlobalConnect. | |
| General Communication Aug 2024 | SERVICE CAMPAIGN | Electrical System | Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). |
| 05-03-08-002J Aug 2024 | Suspension | This service bulletin provides information to dealership personnel on diagnosis and replacement of shock absorber and strut due to fluid leak. | |
| 18-NA-073 Aug 2024 | Engine | This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement. | |
| 01-00-89-010S Aug 2024 | Unknown Or Other | This service bulletin provides information on a guide to help reduce repeat visits for the same customer concern. | |
| 07-06-01-016J Aug 2024 | Engine | This service bulletin provides information on Internal Engine Noise or Damage After Oil Filter Replacement. | |
| 00-06-01-012N Aug 2024 | Engine | This service bulletin advises about the possible issues that may occur when using a scotch brite pad or highly abrasive disk on gasket sealing surfaces or reused parts. | |
| 05-06-04-022V Aug 2024 | Fuel/Propulsion System | This bulletin provides information on the TOP TIER Detergent Gasoline Licensed Brands and the TOP TIER Diesel Fuel Licensed Brands that are recommended for use in all GM vehicles and the TOP TIER FUELS website URL. | |
| 16-NA-222 Aug 2024 | Engine | This bulletin provides information on Engine Concerns that could result from lack of scheduled maintenance, improper service or aftermarket calibrations. | |
| 09-06-04-026Y Aug 2024 | Electrical System | This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2. | |
| 01-06-01-011P Aug 2024 | Engine | This service bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption. | |
| PI0754G Jul 2024 | Visibility/Wiper | This PI provides information on Rear and Side Tempered Glass Spots (Quench Marks) and that they are a normal characteristic. | |
| 16-NA-158 Jul 2024 | Unknown Or Other | This service bulletin describes the U.S. Dealer Special Tool Loan Program process. | |
| 24-NA-141 Jul 2024 | Power Train | GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. | |
| 99-04-20-002O Jul 2024 | Power Train | This service bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operation. | |
| 04-06-04-051I Jun 2024 | Fuel/Propulsion System | This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive. | |
| 16-NA-383 Jun 2024 | Engine | This service bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up. | |
| 18-NA-099 Jun 2024 | Unknown Or Other | This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim. | |
| 18-NA-125 Jun 2024 | Electrical System | This service bulletin provides information for engine oil life monitor operation calculation. | |
| 24-NA-098 Jun 2024 | Electrical System | This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information. | |
| 20-NA-016 Jun 2024 | Unknown Or Other | This Warranty Administration bulletin provides information on customer vehicles concern results in a manufacturer repurchase from the customer, GM depends on the dealership to host and administer the repurchase closing and intake of the returning vehicle. | |
| 18-NA-125 May 2024 | Electrical System | This service bulletin provides information for engine oil life monitor operation calculation. | |
| 08-07-30-035H May 2024 | Power Train | This bulletin provides information on the harmful effects of water or ethylene glycol in transmission fluid. | |
| 16-NA-119 May 2024 | Unknown Or Other | This warranty administration bulletin provides policy information to cover GMs policy on performing GM covered vehicle services and maintenance on vehicles originating/sold in Canada. | |
| 09-00-89-008G May 2024 | Unknown Or Other | This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process. | |
| 06-00-89-029V May 2024 | Seats | This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability. | |
| 10-08-110-001K Apr 2024 | Unknown Or Other | This service bulletin provides information on proper use of floor mats. | |
| 13-08-116-001J Apr 2024 | Electrical System | The intent of this service bulletin is to identify aftermarket ALDL or DLC interface devices as potential sources for causing multiple customer concerns that do not have other diagnostic methods to identify them. | |
| 15-00-89-004G Apr 2024 | Engine | This service bulletin provides technicians with information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage. | |
| 00-03-10-006P Apr 2024 | Wheels | This service bulletin provides information for dealers/technicians on Tire Radial Force Variation (RFV). | |
| 20-NA-132 Apr 2024 | Equipment | This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements. | |
| 10-08-45-001H Mar 2024 | Electrical System | This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish. | |
| 20-NA-132 Mar 2024 | Equipment | This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements. |
Showing 60 of 971 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Chevrolet Aveo →