Engine
4.0L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 172 of 172 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 136 of 172 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Electrical system
80 complaint records3 fire reports
"2010 DODGE CARAVAN. CONSUMER WRITES IN REGARDS TO REPLACEMENT PARTS NOT AVAILABLE TO COMPLETE RECALL NOTICE REPAIRS. *SMD RECALL # 14V373000. *JB..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Engine & cooling
35 complaint records2 fire reports
"DRIVING ON INTERSTATE HWY AT APPROX 60 MPH WHEN THE VEHICLE/ENGINE TURNED OFF. GOT TO SHOULDER OF HWY AND WAS ABLE TO RESTART THE VEHICLE. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Brakes
22 complaint records
"TRAVELING AT 55MPH HUMMING /GROWLING NOISE FROM REAR. PULLED OVER NOISE STOPPED BOTH REAR WHEELS VERY HOT FRONTS WARM BUT COULD TOUCH DROVE CAR NOISE RETURNED 5DAYS LATER SAME ISSUE WITH HEAT...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP14004 opened Sep 2014 | closed Jul 2015 | Electrical System | Totally Integrated Power Module Failure In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM)... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 10V164000 | Suspension | THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN MOBILITY CONVERSIONS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. | Normally free |
| 10V148000 | Fuel System, Gasoline | THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN COMMERCIAL ENTERVANS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2024548 2024-08-15 | Label | 314,717 | Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". |
| 2020311 2020-07-08 | Airbag | 188,249 | Issue: On certain vehicles, the emblem on the steering wheel could become loose. If this happens, the emblem or its retainers could become projectiles when the airbag inflates in a crash. |
| 2019420 2019-08-21 | Other | 5,327 | Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. |
| 2018439 2018-08-21 | Seats And Restraints | 230 | On certain wheelchair-accessible vehicles, the bolts used to attach the removable seats to the floor may contain a defect and could break in the event of a crash, creating a risk of injury. |
| 2016575 2016-11-17 | Fuel System | 207 | On certain Amerivan 10 wheelchair accessible vehicles built on Dodge Grand Caravan and Chrysler Town and Country platforms, the crimp fasteners used to retain fittings in the fuel line may not be fully crimped or compressed. |
Show 5 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2015250 2015-06-04 | Electrical | 161,349 | On certain vehicles, the Wireless Ignition Node (a.k.a ignition switch) may allow the ignition key to inadvertently move from the ON position to the accessory (ACC) position while driving, causing the engine to shut off. |
| 2014261 2014-07-02 | Electrical | 97,496 | On certain vehicles, the Wireless Ignition Node (a.k.a ignition switch) may allow the ignition key to inadvertently move from the ON position to the accessory (ACC) position while driving, causing the engine to shut off. |
| 2014167 2014-05-08 | Electrical | 106,904 | On certain vehicles, if the vent window switch (located in the driver's door armrest) is exposed to liquids, it could overheat. |
| 2014031 2014-02-03 | Structure | 166 | On certain vehicles modified for wheelchair accessibility by the Liberty Motor Company Inc., the rear axle may fracture due to a combination of corrosion damage and operation on rough roads. |
| 2011096 2011-03-02 | Other | 41,970 | On certain vehicles, the Wireless Ignition Node (a.k.a ignition switch) may allow the ignition key to inadvertently move from the ON position to the accessory (ACC) position while driving, causing the engine to shut off. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 108463 Nov 2025 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE | |
| 108464 Nov 2025 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE | |
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. | |
| 9100196 Jul 2023 | Equipment | Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used | |
| S2209000004 Apr 2022 | Engine And Engine Cooling | If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. |
Show 41 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 9004509 Mar 2022 | Power Train | Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold | |
| 9004009 Apr 2021 | Power Train | Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. | |
| 23-034-20 Dec 2020 | Equipment Adaptive/Mobility | Active Head Restraint (AHR) Inadvertent Deployment - X91 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. | |
| 69920 Nov 2020 | Equipment | Warranty Bulletin D-20-19 (X87) Active Head Restraint - Select 2010-2017 Dodge Grand Caravan (RT) | |
| 23-030-20 Nov 2020 | Equipment | Active Head Restraint (AHR) Inadvertent Deployment - X87 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. | |
| 2303020 Nov 2020 | Seats | Active Head Restraint (AHR) Inadvertent Deployment - X87 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. | |
| 9004300 Sep 2020 | Engine And Engine Cooling | Cooler line, Power steering return The clips that hold the line to the core support are not available at this time and will need to be reused. Use care when opening and re-latching clip. | |
| S1121000006 Rev. Aug 2020 | Electrical System | (Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns | |
| S1121000006RevA Aug 2020 | Electrical System | (Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns | |
| 23-015-20 Apr 2020 | Equipment | Disinfectant Solution Recommended for COVID-19 | |
| 08-049-20 Apr 2020 | Equipment | Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary. | |
| 18-039-20 Apr 2020 | Fuel System | Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season | |
| 31-006-19 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 31-004-19 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 31-003-19 Nov 2019 | Equipment | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 31-005-19 Nov 2019 | Equipment | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 3100619 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 3100419 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 3100319 Nov 2019 | Structure | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 3100519 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 9003220 Aug 2019 | Equipment | RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". | |
| 9003687 Mar 2017 | Seat Belts | Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| 9003681 Mar 2017 | Seat Belts | Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| R4880213A$ Jun 2016 | Power Train | "SHAFT - AXLE HALF NOTE: THE JOINT BETWEEN THE SPLINES ON THE HALFSHAFT AND THE HUB AND BEARING IS AN INTERFERENCE FIT. THE HALFSHAFT NUT IS TO BE USED TO DRAW THE HUB AND BEARING ONTO THE HALFSHAFT SPLINES. THIS IS PARTICULARLY TRUE IF HUB AND BEARING IS ALSO BEING REPLACED" | |
| R4880213A Jun 2016 | Power Train | Shaft - Axle Half Note: The joint between the splines on the halfshaft and the hub and bearing is an interference fit. The halfshaft nut is to be used to draw the hub and bearing onto the halfshaft splines. This is particularly true if hub and bearing is also being replaced.~ | |
| RL108213A$ Jan 2016 | Engine And Engine Cooling | NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~ | |
| 9002887 Feb 2015 | Engine And Engine Cooling | Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009,... | |
| 23-024-14 Sep 2014 | Structure | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| 2302414 Sep 2014 | Equipment | Water In The Jack Storage Area This bulletin involves sealing the left side fascia support flange. The customer may describe water entering the jack storage compartment and/or a wet jack storage bag and/or wet jack storage compartment liner material. | |
| 23-014-14 Jun 2014 | Structure | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| 08-042-14 Apr 2014 | Electrical System | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| 9001645 Feb 2014 | Engine And Engine Cooling | Part Description: Short Runner Valve (Actuator) Issue Description: Issue 1~ JC,JS '08-09MY 3.5L only~ Caution - Do not replace the intake manifold for a short runner valve (SRV) fault (P1004 / P2008 / P2016 / P2017) or for a manifold tuning valve (MTV) fault (P1005 / P2077 /... | |
| 9002385 Feb 2014 | Structure | Part Description: Upper and Lower Sliding Door Rollers Issue Description: If you are replacing this part for a NOISE condition, please perform the following procedure:~ 1. | |
| 9002519 Mar 2013 | Equipment | 82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois,... | |
| 9002254 Feb 2013 | Power Train | 04766312A$, 04766313A$, 04862307A$, 04766311A$ - Power Steering Return Line Some customers, in extreme cold weather climates (beyond -40 deg C), may report a leaking power steering return line. | |
| 9002844 Feb 2013 | Exterior Lighting | 04894772A$, 04894773A$, 04894756A$, 04894757A$ - Quarter Panel and Tail Lamp Extension If the rear quarter panels and taillamp extentions have been replaced and the taillamps will not fit into the provided holes, you must modify the panel to add the lower grommet hole for 2008 ? | |
| 23-012-12REV.A Oct 2012 | Structure | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| SB-02-003-11 Sep 2011 | Suspension | CHRYSLER/DODGE: THE FRONT WHEEL BEARINGS IS HUMMING OR GROWLING. REMOVE AND REPLACE BOTH FRONT WHEEL BEARINGS, IF NECESSARY. *PE | |
| SB-08-021-10 Sep 2010 | Electrical System | CHRYSLER/DODGE: POWER SLIDING DOORS INOPERATIVE. THIS INVOLVES FLASH REPROGRAMMING THE POWER SLIDING DOOR MODULE REAR LEFT AND/OR RIGHT (DMRL/DMRR) WITH NEW SOFTWARE. POWER SLIDING DOORS WILL NOT OPEN FROM ANY OF THE SWITCHES. DOORS WILL WORK IN THE MANUAL MODE. | |
| TSB-23-005-10 Mar 2010 | Structure | CHRYSLER/DODGE: POWER SLIDING DOOR WILL NOT POWER OPEN. THE POWER SLIDING DOOR OF THE RIGHT AND/OR LEFT SIDE NOT OPENING WHEN USING THE INTERIOR OR EXTERIOR HANDLES OR INTERIOR B PILLAR BUTTON FROM FULL CLOSED POSITION BUT WORKS WITH REMOTE KEYLESS ENTRY AND THE FRONT ROW... | |
| SB-08-017-09 Oct 2009 | Structure | CHRYSLER/DODGE: POWER SLIDING DOOR MODULE. OVERLY SENSITIVE OBSTRUCTION DETECTION. VERIFYING THERE ARE NO MECHANICAL CONDITIONS THAT MAY LEAD TO SLOW DOOR OPERATION, MAKING MECHANICAL CORRECTIONS AS NECESSARY AND FLASH REPROGRAMMING BOTH POWER SLIDING DOOR MODULE'S (PSDM). *PE |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Run the VIN against open recalls before you negotiate.This vehicle has 2 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Dodge Caravan →