Engine
2.4L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 344 of 345 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 272 of 345 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Body & structure
166 complaint records1 fire report1 crash report
"THE DRIVERS SIDE REAR DOOR HANDLE CAME OFF IN MY HAND A YEAR AGO.NOW THE DRIVER SIDE FRONT DOOR HANDLE DID THE SAME THING...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse body & structure parts in the directory →
Brakes
30 complaint records4 crash reports
"TAKATA RECALL NEEDS TO ISSUE A RECALL ON AIR BAGS, THE LIGHT STAYS ON AND WONT GO OFF. WHAT IF IM INVOLVED IN A CAR CRASH? A RECALL NEEDS TO BE ISSUED ON TAG LIGHTS AND BREAK LIGHTS THE BULB KEEPS BLOWING OUT, WHY IS THIS?>..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Engine & cooling
29 complaint records2 fire reports
"WHEN DRIVING VEHICLE, IT COMPLETELY STALLS AND VEHICLE IS UNABLE TO START AGAIN FOR A FEW MINUTES. HAPPENS RANDOMLY WITHOUT NOTICE...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP22003 opened Sep 2022 | closed Dec 2023 | Engine | Loss of Motive Power The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain... |
| DP21003 opened Nov 2021 | closed Jun 2023 | Vehicle Speed Control | Throttle control system vulnerabilities The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on... |
| PE13007 opened Mar 2013 | closed Aug 2013 | Suspension | Rear Control Arm Failure - led to recall 13V354000 In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai) notified NHTSA that Hyundaiis conducting a safety recall (13V-354) involving approximately 239,000 vehicles involving model year (MY) 2006 through 2010 Hyundai Sonata... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 13V354000 | Suspension | Hyundai is recalling certain model year 2006-2010 Sonata vehicles manufactured March 1, 2005, through January 21, 2010; and model year 2006-2011 Azera vehicles manufactured September 27, 2005, through November 22, 2010... | Normally free |
| 13V113000 | Exterior Lighting | Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz,... | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2013325 2013-09-25 | Electrical | 110,104 | On certain vehicles, the stop lamp switch may fail and cause intermittent operation of the brake lights. Failure of the brake lights to illuminate when the brake pedal is depressed could result in a crash causing property damage and/or... |
| 2013280 2013-08-12 | Structure | 52,317 | On certain vehicles, road salt can corrode the rear crossmember assembly, which may ultimately lead to separation of the control arm at the mounting point. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| DTN DCS Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. | |
| DTN DL Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). | |
| 25-BD-012H TSB Nov 2025 | Exterior Lighting | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 24-BD-001H Feb 2024 | Visibility | This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side... | |
| 23-EM-005H Oct 2023 | Engine And Engine Cooling | This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. |
Show 45 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 23-BD-007H Apr 2023 | Structure | Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. | |
| 23-BD-002H Jan 2023 | Visibility | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 22-EM-010H Jul 2022 | Engine And Engine Cooling | Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement. | |
| 22-GI-006H Jul 2022 | Tires | Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. | |
| 21-AT-006H May 2021 | Power Train | Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicleâÂÂs ownerâÂÂs manual. ï· Use of other ATF may result in improper shift quality or other drivability conditions. | |
| 21-EM-004H Mar 2021 | Engine And Engine Cooling | This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps. | |
| 21-BR-002H Mar 2021 | Service Brakes | This bulletin provides best practice recommendations when performing brake service procedures. | |
| 21-EM-003H Mar 2021 | Engine And Engine Cooling | This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below. | |
| 20-BR-002H Nov 2020 | Service Brakes | This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area. | |
| 20-SS-004H Nov 2020 | Wheels | This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the âTire Balance Data Sheetâ must be fully completed including imbalance and Road Force Variation (RFV) data. | |
| 20-BD-014H Jul 2020 | Equipment | This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 20-SS-002H(1) May 2020 | Wheels | This bulletin provides information on tire maintenance best practices and procedures for dealers and customers to maximize tire life and performance. | |
| 20-BD-007H-1 May 2020 | Equipment | This bulletin describes the general guidelines to help disinfect and protect vehicle exterior/interior surfaces using recommended safe chemical products. | |
| 20-EE-003H Apr 2020 | Equipment | This bulletin provides information on identifying dealer stock vehicles with either: ⢠A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. ⢠A 30 Day alert - vehicle has not started and reported an SOC in 30 days. | |
| 20-AT-016H Apr 2020 | Equipment Adaptive/Mobility | The automatic transmission warranty repair policy authorizes in-dealership repairs of the following components for both OEM (new) and remanufactured automatic transmissions: | |
| 20-BD-007H Mar 2020 | Equipment Adaptive/Mobility | This bulletin describes the general guidelines to disinfect and protect vehicle interior surfaces using certain safe chemical products. | |
| 20-SS-001H Feb 2020 | Suspension | This bulletin describes the requirements for all wheel alignment and/or vehicle tracking claims and best practices when diagnosing and conducting alignment-related repairs for all models and model years. | |
| 20-BE-001H Jan 2020 | Electrical System | This bulletin provides guidelines to inspect the USB, head unit, and multi-box for common connection conditions. 2. This bulletin presents guidelines to inspect for common Android Auto and Apple CarPlay connection conditions. 3. | |
| 19-BE-011H-1 Nov 2019 | Back Over Prevention | The Blind Spot Detection (BSD) or Blind-Spot Collision Warning (BCW) is a system that measures the speed of and distance from the following vehicles by using two magnetic wave radar sensors attached in the rear bumper. | |
| 19-GI-006H Oct 2019 | Equipment Adaptive/Mobility | This bulletin provides instruction detailing the proper methodology for scanning and uploading captured GDS data files to the Techline Repository. Compliance with this bulletin ensures that the GDS data files are correctly transferred and matched with a Techline Case number. | |
| 19-FL-003H Apr 2019 | Electrical System | This bulletin provides the procedure to write the Vehicle Identification Number (VIN) during the replacement of the Engine Control Module (ECM) or Powertrain Control Module (PCM). Once the VIN has been programmed to the ECM/PCM, it cannot be removed or overwritten. | |
| 5NP-F8M5G-03 Feb 2017 | Equipment | Hyundai has announced an extended warranty for the motor driven power steering (MDPS) coupling on the following vehicles: ? 2011-2014 Sonata (YFa), 2011-2014 Sonata Hybrid (YF HEV) ? | |
| 5NP-S9D9P-10 Sep 2016 | Power Train | THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT). | |
| 5NP-B6E2P-10 Aug 2016 | Power Train | "THE PCM OR TCM CONTAINS LOGIC TO ADJUST SOLENOID DUTY AND LINE PRESSURE AS NEEDED TO COMPENSATE FOR NORMAL CLUTCH WEAR OVER THE LIFE OF THE TRANSAXLE. THIS BULLETIN PROVIDES THE PROCEDURES NECESSARY TO RESET (ERASE) AND RELEARN THE PCM/TCM ADAPTIVE VALUES. | |
| 5NP-E2D7G-09 Apr 2016 | Power Train | THE FOLLOWING VEHICLES ARE EQUIPPED WITH A 6-SPEED AUTOMATIC TRANSMISSION. THE ATF LEVEL MUST BE CHECKED BY THE FOLLOWING PROCEDURE. | |
| 15-01-005 Jan 2015 | Structure | HYUNDAI MODELS :SONATA, ELANTRA , GENESIS & GENESIS COUPE: ON CERTAIN VEHICLES THE INTERIOR CHROME PLATED DOOR HANDLES MAY WEAR DUE TO CONSISTENT USE. *LJ | |
| FIR-0909 Sep 2013 | Fuel System | HYUNDAI: PROCEDURE INFORMATION PROVIDED ON SYMPTOMS AND INSPECTION OF FUEL LEVEL SENDER WITH CERTAIN SYMPTOMS. MODELS 2006-2011 SONATA, 2012 GENESIS, 2010 TUCSON. *PE | |
| TSB-13-FL-003 May 2013 | Fuel System | HYUNDAI: INFORMATION REGARDING THE INSPECTION PROCEDURE FOR FUEL LEVEL SENDER AND SYMPTOMS OF CHECK ENGINE LIGHT ON, ERRATIC OR UNRESPONSIVE FUEL GAUGE OR FUEL GAUGE DOES NOT REACH FULL LEVEL AFTER FILLING UP. MODELS 2012-2014 GENESIS, 2006-2014 SONATA, 2010-2014 TUCSON. *PE | |
| TSB-13-FL-002 Apr 2013 | Fuel System | HYUNDAI: THE THROTTLE CONTROL (ETC) BODY, ON SOME VEHIICLES, NEEDS TO BE CLEANED AND PROCEDURAL INFORMATION IS BEING PROVIDED, DUE TO DEPOSITS FOUND AT VALVE-TO-BORE INTERFACE. | |
| TSB-13-FL-001 Mar 2013 | Power Train | HYUNDAI: DUE TO AN ERROR IN THE INTERNAL CONTROL MODULE READ ONLY MEMORY, INFORMATION IS PROVIDED REGARDING THE REPLACING OF THE PCM AND A POSSIBLE WARRANTY CLAIM. MODELS 2011-2013 ELANTRA, 2010-2013 GENESIS COUPE, 2010-2013 SANTA FE, 2006-2013 SONATA, 2010-2013 TUCSON. *PE | |
| 13-EE-001 Jan 2013 | Equipment | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| 12-AT-023 Oct 2012 | Equipment | SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| TSB-12-01-021 Aug 2012 | Power Train | HYUNDAI: INFORMATION PROVIDED REGARDING INSTALLATION OF INHIBITOR SWITCH BRACKET TO PREVENT SHOCK WHEN SHIFTING VEHICLE TO DRIVE OR REVERSE. MODELS 2010-11 TUCSON AND 2009-10 SONATA. *PE | |
| TSB-11-01-025 Aug 2011 | Electrical System | HYUNDAI: INFORMATION IS PROVIDED FOR THE ECU UPDATE FOR HEV ACTIVE AIR FLAP (AAF). *PE | |
| TSB-11-01-027-1 Aug 2011 | Tires | HYUNDAI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. PROCEDURE INFORMATION REGARDING 18 IN. WHEEL VEHICLES FOR TRACKING DIAGNOSIS AND REPAIR. *PE UPDATED 10/28/11. *PE | |
| TSB-11-BR-002 May 2011 | Service Brakes | HYUNDAI: ALL SONATA HYBRIDS. BRAKE BLEEDING PROCEDURE. *RM | |
| 11-AT-003 Feb 2011 | Power Train | HYUNDAI: THE PROCEDURE TO UPDATE SOFTWARE ON 2009-2010 SONATA. IMPROVES ACCELERATION FROM A STOP AND DECELERATION ON A COLD ENGINE. *RM | |
| SB-10-EM-006 Dec 2010 | Engine And Engine Cooling | HYUNDAI: A REVISED PROCEDURE FOR REPLACING THE TIMING CHAIN TENSIONERS. *RM | |
| TSB-10-01-023 Jun 2010 | Engine And Engine Cooling | HYUNDAI: AUTOMATIC TRANSAXLE ECM AND TCM UPDATE. PROVIDES A PROCEDURE TO UPDATE THE ECM AND TCM SOFTWARE TO THE MOST RECENT VERSIONS TO REVISE-ACCELERATION FEEL FROM A STOP OR BELOW 15MPH; SHIFT QUALITY WHEN DECELERATING TO A STOP AT ABOUT 30MPH WHEN THE ATF IS COLD. *PE | |
| TSB-10-01-022 Jun 2010 | Structure | HYUNDAI: ALARM SELF ACTIVATES; HOOD SWITCH PAD REPLACEMENT. VEHICLE ALARM SYSTEM MAY INTERMITTENTLY SOUND DUE TO LIGHT CONTACT OF THE HOOD SWITCH PAD WITH THE HOOD SWITCH. PROVIDES INSTRUCTIONS TO REPLACE THE HOOD SWITCH PAD WITH A REVISED PART. *PE | |
| TSB-10-GI-001 Apr 2010 | Equipment | HYUNDAI: LABEL REQUIREMENTS FOR VEHICLE LOADING TO COMPLY WITH FMVSS 110. EFFECTIVE 6/2/08, FMVSS 110 (FMVSS 110) SETS A THRESHOLD FOR CORRECTING LOAD CAPACITY INFORMATION INDICATED ON TIRE PLACARDS WHEN VEHICLE WEIGHT HAS BEEN INCREASED BEFORE RETAIL SALE. | |
| TSB-09-01-035 Dec 2009 | Engine And Engine Cooling | HYUNDAI: PROVIDES AN INSPECTION AND REPAIR PROCEDURE FOR S1 OXYGEN SENSORS TO CORRECT THIS CONDITION. SOME VEHICLES EQUIPPED WITH 3.3L ENGINES MAY SET DTC P0133 AND/OR P0153. *PE | |
| TSB-09-01-030 Nov 2009 | Electrical System | HYUNDAI: ECM UPDATE. PROVIDES A PROCEDURE TO UPDATE THE ECM SOFTWARE FOR MANUAL TRANSMISSION EQUIPPED VEHICLES TO THE MOST RECENT VERSION. VERIFY THE VERSION OF THE ECM ROM ID BEFORE ATTEMPTING TO UPDATE THE VEHICLES SOFTWARE. *PE | |
| TSB-09-01-029 Oct 2009 | Power Train | HYUNDAI: ECM AND TCM UPDATE. A PROCEDURE HAS BEEN PROVIDED TO UPDATE THE PCM WITH THE MOST RECENT CALIBRATION FOR VEHICLES WITH AN AUTOMATIC TRANSAXLES. *PE | |
| TSB-09-AT-018 Oct 2009 | Power Train | HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED; TRANSAXLE HELD IN 3RD GEAR FAIL SAFE. |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Walk the body slowly in daylight.Panel gaps, rust at the rockers and wheel arches, and cracked trim are this vehicle's structure complaints. Open and close the liftgate or trunk and look at the latch area.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Run the VIN against open recalls before you negotiate.This vehicle has 2 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Hyundai Sonata →