Engine
2.4L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 3,373 of 3,377 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 2,308 of 3,377 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
This file is almost entirely about one engine family, and it became one of the largest engine-defect stories in the federal record.
Steering
1,175 complaint records6 fire reports21 crash reports
"STEERING WHEEL/COLUMN "RATTLES" WHEN GOING 15-20 MPH OVER ROUGH ROAD. STEERING HAS A LOOSE FEEL IN THESE INSTANCES. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse steering parts in the directory →
Engine & cooling
1,013 complaint records86 fire reports21 crash reports
One frequently described issue: Theta II engine bearing failure
The 2.4-liter and 2.0-liter turbo Theta II engines in the 2011 Sonata are the subject of a well-documented pattern of connecting-rod bearing failure: a knocking noise that grows with engine speed, followed by seizure, sometimes at highway speed. The engines were the subject of federal recall campaigns, an extended warranty on the engine itself, and later federal enforcement action over how the recalls were handled. The advice writes itself: a replaced engine is a plus on this car, and an original one at high mileage is a question.
"TAKATA RECALL IT STARTED LIKE 3 WEEKS AGO SOUNDS LIKE THE MOTOR IS KNOCKING. THEN A WEEK AGO MY AIRBAG LIKE WONT GO OFF...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts named in the editorial file
Complete Engine Assembly
Buy it now on eBayNamed by the editorial note above, not by the federal record. Opens a live eBay search for this vehicle; confirm fitment.
Electrical system
446 complaint records30 fire reports14 crash reports
"AIRBAG LIGHT COMES ON RANDOMLY AND WILL GO OFF AND COME BACK ON AGAIN RANDOMLY, WORRIED THAT AIRBAG WILL RANDOMLY DEPLOY..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| DP22003 opened Sep 2022 | closed Dec 2023 | Engine | Loss of Motive Power The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain... |
| EA21003 opened Dec 2021 | closed Feb 2024 | Engine | Engine Fires - led to recall 23V877 On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on... |
| DP21003 opened Nov 2021 | closed Jun 2023 | Vehicle Speed Control | Throttle control system vulnerabilities The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on... |
| PE19003 opened Mar 2019 | closed Dec 2021 | Unknown Or Other | Non-crash Vehicle Fires - led to recall 21V727000 During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle... |
| DP18003 opened Aug 2018 | closed May 2019 | Unknown Or Other | Non-crash Vehicle Fires - led to recall 19V204000 In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and... |
Show 3 more closed investigations
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE18003 opened Mar 2018 | closed Aug 2019 | Seat Belts | Air bags may be disabled during crash - led to recall 18V363000 The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. |
| RQ17004 opened May 2017 | closed Dec 2021 | Engine | Scope and Timeliness - led to recall 19V063000 NHTSA opened Recall Query (RQ) 17-004 to investigate the timeliness and scope of Hyundai?s Theta II GDI engine recalls (Recall Nos. 15V-568 and 17V-226), and Hyundai?s compliance with reporting requirements. |
| PE10035 opened Aug 2010 | closed Feb 2011 | Steering | Steering Shaft Separation - led to recall 10V457000 The Office of Defects Investigation (ODI) is aware of 7 complaints and field reports and 10 warranty claims on the subject vehicles that allege the intermediate steering shaft became loose or in some cases separated from the upper steering column and/or the... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 18V934000 | Fuel System, Gasoline | Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. | Normally free |
| 18V137000 | Seat Belts | Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. | Normally free |
| 17V617000 | Seat Belts | Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. | Normally free |
| 17V152000 | Seat Belts | Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. | Normally free |
| 16V190000 | Steering | Hyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured December 11, 2009, to October 31, 2010. | Normally free |
| 15V759000 | Exterior Lighting | Hyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is... | Normally free |
| 15V629000 | Suspension | Hyundai Motor America (Hyundai) is recalling certain model year 2011 Elantra vehicles manufactured November 12, 2010, to March 31, 2011, and Sonata vehicles manufactured December 11, 2009, to February 28, 2010,... | Normally free |
| 15V568000 | Engine | Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or... | Normally free |
Show 6 more recall campaigns
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 14V434000 | Power Train | Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. | Normally free |
| 14V433000 | Service Brakes, Hydraulic | Hyundai Motor Company (Hyundai) is recalling certain model year 2011 Sonata vehicles manufactured from December 11, 2009, through September 1, 2010. | Normally free |
| 13V113000 | Exterior Lighting | Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz,... | Normally free |
| 10V457000 | Steering | HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009, THROUGH SEPTEMBER 10, 2010. | Normally free |
| 10V426000 | Steering | HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009, THROUGH SEPTEMBER 10, 2010. | Normally free |
| 10V070000 | Latches/Locks/Linkages | HYUNDAI-KIA HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2011 SONATA VEHICLES MANUFACTURED FROM DECEMBER 11, 2009 THROUGH FEBRUARY 15, 2010. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2024080 2024-02-08 | Brakes | 353,849 | Issue: On certain vehicles, brake fluid could leak into the control module for the antilock brake system (ABS) and cause it to short circuit. Note: This recall replaces recall R0246 (Transport Canada recall number 2023-527). |
| 2021612 2021-10-01 | Engine | 51,508 | Issue: Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. |
| 2020592 2020-12-02 | Engine | 14,549 | Issue: On certain vehicles equipped with a 1.6 L GDI, 2.0 L GDI, or 2.4 L MPI engine, the connecting rod bearings could wear prematurely. |
| 2019640 2019-12-16 | Engine | 275,533 | Issue: Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. |
| 2019130 2019-03-11 | Engine | 255,370 | Issue: Hyundai Auto Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. |
Show 12 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2019012 2019-01-10 | Engine | 7,027 | Issue: When repairs were completed under recall campaign 2015-428 (Hyundai #R0101) or 2017197 (Hyundai #R0130), the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. |
| 2018261 2018-05-15 | Airbag | 41,067 | On certain gasoline and hybrid engine vehicles, the circuits within the airbag control unit may become damaged. |
| 2017146 2017-03-15 | Seats And Restraints | 64,106 | On certain vehicles, the connections between the front seat belts and the floor mounted seat belt anchor pretensioners may not have been attached properly during assembly. |
| 2016310 2016-06-16 | Suspension | 14,866 | On certain vehicles, the front suspension coil springs may be susceptible to corrosion. Over time, corrosion could cause the springs to fail, potentially damaging front tires and causing rapid air loss and/or tire failure, which could... |
| 2016149 2016-04-07 | Steering | 13,137 | On certain vehicles, the electric power steering (EPS) control circuit board could become damaged and fail. If this occurs, a red "EPS" warning lamp will illuminate in the instrument cluster to inform the driver that steering assist is no... |
| 2015469 2015-10-15 | Suspension | 14,866 | On certain vehicles, the front suspension coil springs may be susceptible to corrosion. Over time, corrosion could cause the springs to fail, potentially damaging front tires and causing rapid air loss and/or tire failure, which could... |
| 2015428 2015-09-25 | Engine | 33,786 | On certain vehicles, the engine crankshaft may not have been properly cleaned to remove metallic debris during manufacturing. |
| 2014321 2014-08-01 | Brakes | 11,227 | On certain vehicles, brake lines connecting the master cylinder to the Hydraulic Electronic Control Unit may be defective and could either leak, or restrict fluid flow in the brake line. |
| 2014323 2014-08-01 | Powertrain | 57,531 | On certain vehicles equipped with automatic transmissions, the shift cable may detach from the shift lever. As a result, the driver may not be able to select a different gear position, or place the transmission in the PARK position. |
| 2013099 2013-04-03 | Electrical | 254,784 | On certain vehicles, the stop lamp switch may fail and cause intermittent operation of the brake lights. Failure of the brake lights to illuminate when the brake pedal is depressed could result in a crash causing property damage and/or... |
| 2010321 2010-09-23 | Steering | 11,534 | On certain vehicles, the steering column intermediate shaft universal joint connection may have been improperly assembled or insufficiently tightened. |
| 2010074 2010-03-11 | Other | 84 | On certain vehicles, if a front inside door lock switch is held in the locked position while the inside door handle is pulled, the door latch inside handle lever may become out of position relative to the door latch master link. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 24-01-073H Sep 2024 | WARRANTY EXTENSION | Exterior Lighting | Some 2011-14MY Sonata (YF) vehicles may experience inoperative brake lights that may be caused by melting/deformation of the rear combination housing lamps. |
| 26-BE-022H TSB Aug 2026 | WARRANTY EXTENSION | Air Bags | The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use. |
| 26-BE-022H DN Aug 2026 | WARRANTY EXTENSION | Air Bags | The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use for original & subsequent owners. |
| 26-BE-022H DCS Aug 2026 | WARRANTY EXTENSION | Air Bags | The warranty coverage for the clock spring has been extended to 15 years with unlimited mileage from the date of original retail delivery or date of first use. |
| DTN DCS Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| DTN DL Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). | |
| P33 OL Dec 2025 | Electrical System | In response to this trend, we engineered a software upgrade that addresses the social media theft method and made it available to owners of eligible models free of charge at authorized Hyundai dealers since early 2023. | |
| TRW Settlement Notice Dec 2025 | Air Bags | Hyundai has settled a class action lawsuit that alleges that certain Hyundai and Kia Class Vehicles (defined below) contain defective ZF-TRW airbag control units (“ZF-TRW ACUs”) that are vulnerable to a condition called electrical overstress, which may cause the vehicles’... | |
| TRW Summary Notice Dec 2025 | Air Bags | A Class Action settlement regarding the TRW Airbag was recently decided. Based on the Class Action, customers are eligible for certain settlement benefits. Impacted vehicles are also noted below. | |
| TRW Settlement DCS Dec 2025 | Air Bags | A Class Action settlement regarding the TRW Airbag was recently decided. Based on the Class Action, customers are eligible for certain settlement benefits. Please see attached for details. Impacted vehicles are also noted below. | |
| 25-01-089H TSB Dec 2025 | Electrical System | This bulletin provides the service procedure for installation of a key cylinder reinforcement protector assembly and two anti-theft decals on the front windows. | |
| 25-01-089H DN Dec 2025 | Electrical System | In addition to the Anti-Theft software provided under Service Campaign 993 (TSB 24-01-009H-1), a zinc reinforced ignition cylinder protector hardware upgrade is being made available to customers upon request. | |
| 25-01-089H DCS Dec 2025 | Electrical System | Upon customer's request ONLY, the Technical Service Bulletin (TSB) 25-01-089H provides the service procedure for installation of a key cylinder reinforcement protector assembly and two anti-theft decals on the front windows. | |
| 25-BD-012H TSB Nov 2025 | Exterior Lighting | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 24-01-009H-1 May 2024 | SERVICE CAMPAIGN | Electrical System | A class settlement against Hyundai Motor America (“HMA”) that had alleged that certain 2011 – 2022 model year Hyundai vehicles that were not equipped with an engine immobilizer (called the “Class Vehicles”) contain design flaws, including the failure to manufacture the Class... |
| 24-AT-002H Apr 2024 | Power Train | This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2. | |
| 24-BD-001H Feb 2024 | Visibility | This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side... | |
| 24-01-009H Feb 2024 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of... | |
| 23-01-014H-6 Jan 2024 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of... | |
| 23-01-014H-6 Dec 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of... | |
| 23-01-089H Dec 2023 | Exterior Lighting | Some 2011-14MY Sonata (YF) vehicles may exhibit inoperative brake lights that may be caused by melting/deformation of the rear combination housing lamps. | |
| 23-01-014H-6 Nov 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine... | |
| 23-01-014H-5 Oct 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine... | |
| 23-EM-005H Oct 2023 | Engine And Engine Cooling | This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. | |
| 23-BE-010H Aug 2023 | Electrical System | Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. | |
| 23-01-014H-5 Aug 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine... | |
| 23-01-014H-5 Jul 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-01-014H-5 Jun 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-01-014H-4 May 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-BD-007H Apr 2023 | Structure | Hyundai applies a Paint Protection Film (PPF) on new vehicles before delivery to dealerships. It provides a barrier between the paint and contaminants, such as rail dust, acid rain, and industrial fallout. In rare cases, the paint can become clouded under the PPF. | |
| 23-01-014H-4 Apr 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993) in response to an increase in thefts of certain Hyundai vehicles not equipped with engine immobilizers targeted through social media. | |
| 23-01-014H-3 Apr 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-BD-002H Jan 2023 | Visibility | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 22-EM-010H Jul 2022 | Engine And Engine Cooling | Follow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement. | |
| 22-GI-006H Jul 2022 | Tires | Effective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. | |
| DBPT3G Apr 2022 | Engine And Engine Cooling | Certain vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit abnormal noise or no crank/no start condition related to connecting rod bearing wear or damage. | |
| 22-01-033H Apr 2022 | Engine And Engine Cooling | Applicable vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit Abnormal Noise or No Crank/No Start condition. | |
| 22-EM-001H-1 Apr 2022 | Engine And Engine Cooling | The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subsequent owners. | |
| 22-EM-002H-1 Apr 2022 | Engine And Engine Cooling | The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 10 years or 120,000 miles from the date of original retail delivery or date of first use, whichever occurs first. | |
| 22-EM-004H Jan 2022 | Engine And Engine Cooling | This bulletin provides additional service diagnostic information and repair procedures related to Electric Waste Gate Actuator (EWGA) equipped vehicles listed below. | |
| 22-EM-001H Jan 2022 | Engine And Engine Cooling | The warranty coverage for engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subsequent owners. | |
| TXXI DBP Jan 2022 | Engine And Engine Cooling | The warranty coverage for certain Theta II engine long block repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to a Limited Lifetime Warranty and is valid for original and subsequent owners. | |
| 21-01-066H Nov 2021 | Engine And Engine Cooling | Applicable vehicles with 2.0L T-GDI and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326 and/or engine may exhibit Abnormal Noise or No Crank/No Start condition. | |
| T3GDBP20211103 Nov 2021 | Engine And Engine Cooling | Hyundai has launched a Service Campaign for applicable vehicles with 2.0L Turbo and 2.4L GDI engines that may experience the Check Engine warning lamp illuminated with DTC P1326. | |
| 21-EM-009H Jul 2021 | Engine And Engine Cooling | This bulletin provides additional service diagnostic information and repair procedures related to Electric Waste Gate Actuator (EWGA) equipped vehicles listed below. | |
| 21-EM-004H Mar 2021 | Engine And Engine Cooling | This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps. | |
| 21-BR-002H Mar 2021 | Service Brakes | This bulletin provides best practice recommendations when performing brake service procedures. | |
| 21-EM-003H Mar 2021 | Engine And Engine Cooling | This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below. | |
| 21-01-002H Jan 2021 | Engine And Engine Cooling | The warranty coverage for the engine long block for engine repairs or replacement related to connecting rod bearing damage as described in Campaign T3G (Seized and/or BCT No Pass Result Only) has been extended to 10 years or 120,000 miles from the date of original retail... | |
| 20-01-004H-3 Dec 2020 | Engine And Engine Cooling | Applicable vehicles with 2.0L Turbo and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine or update the engine ECU software based on the inspection results. | |
| 20-01-024H-2 Dec 2020 | Electrical System | Applicable vehicles with 2.0L Turbo and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine or update the engine ECU software based on the inspection results. | |
| 20-BR-002H Nov 2020 | Service Brakes | This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area. | |
| 20-SS-004H Nov 2020 | Tires | This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the âTire Balance Data Sheetâ must be fully completed including imbalance and Road Force Variation (RFV) data. | |
| 20-01-004H-2 Nov 2020 | Equipment | Applicable vehicles with 2.0L Turbo and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine or update the engine ECU software based on the inspection results. | |
| 20-01-024H-1 Nov 2020 | Engine And Engine Cooling | Applicable vehicles with 2.0L Turbo and 2.4L GDI engines may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine or update the engine ECU software based on the inspection results. | |
| 20-01-037H Sep 2020 | Engine And Engine Cooling | The warranty coverage for the engine long block has been extended to 10 years or 120,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners. | |
| 20-ST-001H-2 Sep 2020 | Steering | This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components. | |
| 20-ST-001H-1 Aug 2020 | Steering | This bulletin provides information regarding replacement of the column-mounted Motor Driven Power Steering (MDPS) system as separate components. | |
| 20-BD-014H Jul 2020 | Exterior Lighting | This bulletin provides information regarding condensation related to moisture accumulation in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. The TSB illustrates the various causes of condensation inside the lamp assembly. | |
| TXXI Dealer Best Jul 2020 | Engine | This Dealer Best Practice intends to inform dealers of a proposed settlement (âSettlementâ) for a class action lawsuit filed against Hyundai Motor America (âHMAâ). |
Showing 60 of 216 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Drive one straight highway stretch and one slow parking lot.Wander or a shimmy over bumps at speed, and heavy or dropped assist at low speed, are the two faces of this vehicle's steering cluster. A clunk on turn-in points at the linkage.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Run the VIN against open recalls before you negotiate.This vehicle has 14 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask the dealer whether the warranty extension on file still applies to this VIN.The manufacturer issued 5 warranty extensions for this vehicle (see the service bulletins section). Extended coverage often runs by years or miles from the original sale, and a repair the seller paid for may have been free.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Hyundai Sonata →