Engine
3.6L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 631 of 634 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 365 of 634 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Electrical system
395 complaint records13 fire reports3 crash reports
"TOTAL INTEGRATED POWER MODULE FUEL PUMP RELAY FAILED CAUSING THE FUEL PUMP TO RUN AFTER THE VEHICLE HAD BEEN TURNED OFF...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Engine & cooling
104 complaint records4 fire reports
"ENGINE SHUTS OFF WHILE DRIVING AND ALL ELECTRICAL GOES OUT WHILE DRIVING. TYPICALLY VAN RESTARTS FINE BUT DOES IT AGAIN WHILE DRIVING...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Fuel system
58 complaint records
"The TIPM is malfunctioning and causing the fuel pump to never turn of on the car. the only way to turn it off is to pull the fuse...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE19014 opened Sep 2019 | closed Feb 2026 | Seats | Active Head Rest Inadvertent Deployment The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year... |
| DP14004 opened Sep 2014 | closed Jul 2015 | Electrical System | Totally Integrated Power Module Failure In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM)... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 25V876000 | Equipment Adaptive/Mobility | Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and... | Normally free |
| 14V234000 | Electrical System | Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. | Normally free |
| 12V191000 | Equipment | CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. | Normally free |
| 12V141000 | Suspension | CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. | Normally free |
| 11V487000 | Engine And Engine Cooling | CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES... | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2024548 2024-08-15 | Label | 314,717 | Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". |
| 2019420 2019-08-21 | Other | 5,327 | Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. |
| 2018439 2018-08-21 | Seats And Restraints | 230 | On certain wheelchair-accessible vehicles, the bolts used to attach the removable seats to the floor may contain a defect and could break in the event of a crash, creating a risk of injury. |
| 2016575 2016-11-17 | Fuel System | 207 | On certain Amerivan 10 wheelchair accessible vehicles built on Dodge Grand Caravan and Chrysler Town and Country platforms, the crimp fasteners used to retain fittings in the fuel line may not be fully crimped or compressed. |
| 2015288 2015-06-26 | Suspension | 1 | On certain Amerivan 10 wheelchair accessible vehicles built on Dodge Grand Caravan and Chrysler Town and Country platforms, the upper rear mounts for the shock aborbers may separate from the chassis. |
Show 4 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2014167 2014-05-08 | Electrical | 106,904 | On certain vehicles, if the vent window switch (located in the driver's door armrest) is exposed to liquids, it could overheat. |
| 2012155 2012-05-03 | Other | 36 | On certain vehicles, the right side liftgate sensor may not function as intended, resulting in an increase in force required to stop the power liftgate during its final closing stages. |
| 2012118 2012-04-03 | Other | 26 | Certain vehicles may have been equipped with an incorrectly manufactured right rear hub and bearing assembly. Hub failure could result in wheel separation. A wheel separating from the vehicle could cause a loss of control and a crash. |
| 2011351 2011-09-27 | Engine | 30 | On certain vehicles equipped with a 3.6L engine, debris in the cylinder block (from the manufacturing process) could cause connecting rod bearing and crankshaft bearing damage. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 108463 Nov 2025 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE | |
| 108464 Nov 2025 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE | |
| 9100456 Nov 2024 | Seats | Incoming Vehicles with Deployed Active Head Rest (AHR) should have a through enquiry. If there is no Broken Pieces or Electrical failure, Direction to RESET the AHR following the Procedure. | |
| 9100229 Sep 2023 | Suspension | LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. | |
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 9100196 Jul 2023 | Equipment | Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used | |
| 1804823 Apr 2023 | Engine And Engine Cooling | wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK | |
| 9003357a Feb 2023 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. | |
| 9003357 Feb 2023 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. | |
| 3100122 Aug 2022 | Structure | Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural... | |
| 9004206 Jun 2022 | Power Train | Remanufactured Transmission Assembly 1. All Promaster (VF) 3.6L/62TE equipped vehicles: a) If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) must be replaced as they are one-time usage. | |
| S2209000004 Apr 2022 | Engine And Engine Cooling | If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. | |
| V51 Apr 2022 | Power Train | Customer Satisfaction Notification V51 Reprogram Powertrain Control Module | |
| 9004509 Mar 2022 | Fuel System | Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold | |
| 9004206 Mar 2022 | Parking Brake | Remanufactured Transmission Assembly 1. All Promaster (VF) 3.6L/62TE equipped vehicles: a) If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) must be replaced as they are one-time usage. | |
| S2109000004 Jul 2021 | Engine And Engine Cooling | Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. | |
| 9004330 Jun 2021 | Power Train | PLATE, TORQUE CONVERTER DRIVE For 3.6L with 62TE NOTE: FOR ALL PROMASTER VF 3.6L/62TE EQUIPPED VEHICLES: IF THE TRANSMISSION BRACKET TO THE TRANSMISSION CASE FASTENERS ARE REMOVED DURING SERVICING, THE FASTENERS Part Number 06511385A$ ARE ONE TIME USEAGE & MUST BE REPLACED &... | |
| S2008000113 Rev. Apr 2021 | Power Train | No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message | |
| S2008000113 Apr 2021 | Electrical System | No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message | |
| S1821000001 Apr 2021 | Power Train | Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders | |
| 3100121 Apr 2021 | Steering | Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required. | |
| 9004206 Apr 2021 | Parking Brake | Remanufactured Transmission Assembly 1. All Promaster (VF) 3.6L/62TE equipped vehicles: a) If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) must be replaced as they are one-time usage. | |
| 9004009 Apr 2021 | Power Train | Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. | |
| S2121000005 Apr 2021 | Power Train | 62TE 6-Speed Transmission Cracked Torque Converter (TC) Piston Repair Index, To Aid In Diagnosis And Repair | |
| 9003357 Mar 2021 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and not damaged or cut. | |
| 71060 Dec 2020 | Seats | Warranty Bulletin D-20-19 (X87) Active Head Restraint - Select 2012-2017 Dodge Grand Caravan/Chrysler Town & Country (RT) (Rev. B) | |
| 2303020 Nov 2020 | Seats | Active Head Restraint (AHR) Inadvertent Deployment - X87 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. | |
| 9004300 Sep 2020 | Engine And Engine Cooling | Cooler line, Power steering return The clips that hold the line to the core support are not available at this time and will need to be reused. Use care when opening and re-latching clip. | |
| S1121000006 Rev. Aug 2020 | Electrical System | (Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns | |
| S1121000006RevA Aug 2020 | Electrical System | (Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns | |
| S2008000113 Aug 2020 | Engine | No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle | |
| DOR-M3J3F-07 Jun 2020 | Engine And Engine Cooling | These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected. | |
| DOR-M9J4S-07 Jun 2020 | Engine And Engine Cooling | These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but parts on vehicles are not effected. | |
| 9004206 May 2020 | Power Train | Remanufactured Transmission Assembly 1. All Promaster (VF) 3.6L/62TE equipped vehicles: a) If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) must be replaced as they are one-time usage. | |
| 23-015-20 Apr 2020 | Equipment | Disinfectant Solution Recommended for COVID-19 | |
| 08-049-20 Apr 2020 | Equipment | Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary. | |
| 18-039-20 Apr 2020 | Fuel System | Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season | |
| S1508000480 Mar 2020 | Equipment | Speed Control Operates Intermittently | |
| 9004022 Dec 2019 | Suspension | Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. | |
| 31-006-19 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 31-004-19 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 31-003-19 Nov 2019 | Equipment | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 31-005-19 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 3100619 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 3100419 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 3100319 Nov 2019 | Structure | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 3100519 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 9003220 Aug 2019 | Equipment | RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". | |
| 9002706 May 2019 | Equipment Adaptive/Mobility | VALVE KIT, A/C Expansion For concern of noise while AC is running, prior to replacing this part, please call Thomas Rolo at (248) 931-0484. If no response in 15 minutes, proceed with repair. | |
| 9004076 May 2019 | Equipment | Oil Filter Adapter If replacing Oil Filter Adapter due to oil leak, please be aware a seal kit is available for repair. If replacing due to missing Spring Loaded Check Valve, a replacement spring and check valve are now available through MOPAR. | |
| TS-WI-0290 Sep 2018 | Seats | Service Bulletin sent to all dealers to inspect L-track bolts for correct torque and to incorporate torque check as part of regular maintenance | |
| 9003735 Oct 2017 | Exterior Lighting | Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L Pentastar engines, please note that there is a new diagnostic procedure available in DealerCONNECT for P-codes in relationship to cam phasers. | |
| 9003220 Oct 2017 | Equipment | RES / RHA / REB Radios That Support Bluetooth and Hands-Free 1. For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands; DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). | |
| 9003681 Aug 2017 | Equipment | Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| 9003109 Jun 2017 | Visibility | Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround... | |
| 9003694 Mar 2017 | Engine And Engine Cooling | Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. | |
| 9003687 Mar 2017 | Seat Belts | Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| 9003681 Mar 2017 | Seat Belts | Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. | |
| 9003220 Nov 2016 | Electrical System | RES / RHA / REB Radios That Supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). | |
| 05152029 Sep 2016 | Visibility/Wiper | Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. |
Showing 60 of 139 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Run the VIN against open recalls before you negotiate.This vehicle has 5 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Chrysler Town And Country →