Engine
3.7L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 696 of 697 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 453 of 697 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Electrical system
177 complaint records7 fire reports2 crash reports
"ELECTRICAL, AIRBAG SENSOR TO LEFT SIDE, ABG, ANTISKID SENSORS, FOLLOWING CODES BOO2013, BOO2813, B105892, C1020, C2100, U1417, PO441...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Engine & cooling
171 complaint records2 fire reports1 crash report
"TICKING SOUND COMING FROM EXHAUST MANIFOLD, ONLY WHEN ENGINE IS COLD, STILL CONTINUES WHEN WARMER NUT NOT AS NOTICEABLE...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Fuel system
124 complaint records1 crash report
"SOMETIMES WHEN VEHICLE COMES TO A COMPLETE STOP IT FEELS AS THOUGH IT IS BEING REAR ENDED EVEN THOUGH NO ONE IS BEHIND IT...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA19001 opened Apr 2019 | closed Sep 2024 | Air Bags | Electrical overstress - led to recall 20V024 The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 18V160000 | Fuel System, Gasoline | Chrysler (FCA US LLC) is recalling certain 2009-2012 Dodge Ram 1500 trucks currently, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri,... | Normally free |
| 17V824000 | Equipment | Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. | Normally free |
| 17V821000 | Power Train | Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and... | Normally free |
| 15V459000 | Air Bags | Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Ram 1500, 2500, 3500, 4500, and 5500 trucks manufactured January 18, 2011, to October 7, 2014, and equipped with the Electronic Vehicle Information Center... | Normally free |
| 13V038000 | Power Train | Chrysler is recalling certain model year 2009-2012 Ram 1500 trucks manufactured from February 27, 2008, through June 30, 2009, and from December 1, 2009, through October 20, 2011; model year 2009-2011 Dodge Dakota... | Normally free |
| 12V192000 | Equipment | CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 RAM 1500 TRUCKS, MANUFACTURED FROM JANUARY 5, 2012 THROUGH JANUARY 6, 2012. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2014449 2014-10-09 | Fuel System | 59,432 | On certain vehicles equipped with 6.7L diesel engines, an electrical connection at the fuel heater could overheat, potentially rendering the heater inoperative and causing a fuel leak and fuel odour. |
| 2013396 2013-11-07 | Steering | 6,674 | Certain Ram 4500 and 5500 four wheel drive vehicles may experience a fracture of the ball stud on the left outer tie rod assembly, potentially resulting in a loss of vehicle control and a crash causing injury and/or property damage. |
| 2013397 2013-11-07 | Steering | 48,517 | On certain 2008-2012 Ram 2500 and 3500 4x4, Ram 3500 cab chassis, and 2008 Ram 1500 Mega Cab 4x4 vehicles, the left outer tie rod ball stud could fracture, potentially resulting in a loss of vehicle control and a crash causing injury... |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 106241 Jul 2025 | Electrical System | LAMP - DOME | |
| 104974 Jun 2025 | Electrical System | LAMP - DOME | |
| 103774 May 2025 | Electrical System | LAMP - DOME | |
| 25-009-24 Dec 2024 | Unknown Or Other | "Dual EVAP System Extreme Duty Vapor Canister Filter Kit Customers operating fleet or severe/extreme duty gasoline vehicles in continuous dusty driving conditions can plug the single OE filter system and may experience a Malfunction Indicator Lamp (MIL) illumination. | |
| 101232 Oct 2024 | Power Train | Plate - Planetary |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| S2408000078 Jul 2024 | Electrical System | Replacement Totally Integrated Power Module (TIPM) Displays Incorrect Vehicle Identification Number (VIN) Current and Active | |
| 9100229 Sep 2023 | Suspension | LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. | |
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. | |
| 9100196 Jul 2023 | Equipment | Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used | |
| 1804823 Apr 2023 | Engine And Engine Cooling | wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK | |
| 9004470 Sep 2022 | Electrical System | CONNECTOR Trailer Tow,WIRING Trailer Tow,CONNECTOR 7 Way,WIRING Rear Bumper If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. | |
| 3100122 Aug 2022 | Structure | Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural... | |
| 9004470 Jun 2022 | Trailer Hitches | CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. | |
| 9004470 May 2022 | Trailer Hitches | CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. | |
| S2209000004 Apr 2022 | Engine And Engine Cooling | If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. | |
| V51 Apr 2022 | Power Train | Customer Satisfaction Notification V51 Reprogram Powertrain Control Module | |
| S1709000010 RevB Mar 2022 | Engine And Engine Cooling | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| S1709000010RevB Mar 2022 | Engine And Engine Cooling | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| S1709000010 Mar 2022 | Power Train | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| 9004470 Jan 2022 | Trailer Hitches | CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. | |
| S2109000004 Jul 2021 | Engine And Engine Cooling | Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. | |
| S2123000028 May 2021 | Seats | Noise From Under Seat With Occupant Seated. | |
| S1821000001 Apr 2021 | Power Train | Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders | |
| 9004009 Apr 2021 | Power Train | Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. | |
| 9003357 Mar 2021 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and not damaged or cut. | |
| 9004350 Mar 2021 | Engine And Engine Cooling | GEAR MOTOR, Transfer Case The gear motor assembly is shipped in AWD/2WD position. The transfer case needs to be positioned in AWD/2WD position to properly assemble gear motor to T-Case. Please reference Star Online publication S2121000003 for further details. | |
| S2121000003 Mar 2021 | Power Train | Transfer Case Gear Motor/Actuator Installation Guidelines. | |
| 9004351 Feb 2021 | Equipment | PLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for this pressure plate: 65RFE use 04799116A$... | |
| S2123000011 Feb 2021 | Visibility | Rattle Tapping Fluttering Noise From A Pillar Or Dash Driving At Highway Speeds | |
| 25-001-21 Feb 2021 | Fuel System | Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister filter.This kit should not be installed on... | |
| 2500121 Feb 2021 | Exterior Lighting | Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister filter.This kit should not be installed on... | |
| S1709000010 Rev. Jan 2021 | Engine And Engine Cooling | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| 9003968 Jul 2020 | Equipment | CONDENSER, Air Conditioning CONDITION 1: If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair instructions included on the... | |
| 9004267 Jun 2020 | Fuel System | FUEL, Tank Please be advised, do not replace fuel tanks with a fuel tank that has a different capacity than the vehicle was equipped with from the factory. Please do not attempt to upfit vehicles at the dealer with increased capacity tanks, they are not compatible. | |
| S2025000005 Jun 2020 | Electrical System | Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes P0407 ? EGR Sensor B Circuit Low, or P0408 ? EGR Sensor B Circuit High Set | |
| 23-015-20 Apr 2020 | Equipment | Disinfectant Solution Recommended for COVID-19 | |
| 08-049-20 Apr 2020 | Equipment | Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary. | |
| 18-039-20 Apr 2020 | Fuel System | Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season | |
| 9004081 Apr 2020 | Equipment | APPLIQUE, Storage Bin (Rambox) For concern of Rambox applique fading, do not replace the applique. This is due to wax or other chemical substance being used on a grain in molded color part. You can clean the applique using isopropyl alcohol. This is not a warrantable condition. | |
| S1508000480 Mar 2020 | Equipment | Speed Control Operates Intermittently | |
| V51 Dec 2019 | Power Train | Customer Satisfaction Notification V51 Reprogram Powertrain Control Module | |
| 9004022 Dec 2019 | Suspension | Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. | |
| 31-006-19 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 31-004-19 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 31-003-19 Nov 2019 | Equipment | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 31-005-19 Nov 2019 | Equipment | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 3100619 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 3100419 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 3100319 Nov 2019 | Structure | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 3100519 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 9003968 Aug 2019 | Engine And Engine Cooling | CONDENSER, Air Conditioning If it is determined that the A/C compressor does not engage due to a refrigerant leak at the receiver/drier plug on the A/C condenser, order the receiver/drier plug kit P/N 68447796A$ and follow the repair instructions included on the instruction... | |
| 9003220 Aug 2019 | Equipment | RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". | |
| 55488 May 2019 | Service Brakes | PadKit- Front Disc Brake | |
| 55502 May 2019 | Service Brakes | PadKit- Front Disc Brake | |
| 55429 May 2019 | Equipment | Mat Kit- Floor Front | |
| 55308 May 2019 | Equipment | Bin- Storage | |
| 55189 May 2019 | Equipment | Actuator-Multiaitr | |
| Volume 5 Issue 5 May 2019 | Equipment | Warranty Operations Newsletter ? Volume 5, Issue 5 | |
| 54935 May 2019 | Engine | Sensor-nitrous oxlde | |
| 55310 May 2019 | Structure | Run-Front Door Glass |
Showing 60 of 236 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Run the VIN against open recalls before you negotiate.This vehicle has 6 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Dodge Ram 1500 →