Engine
3.0L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 99 of 99 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 55 of 99 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Fuel system
21 complaint records
"Failure of High Pressure Fuel pump. My vehicle has low mileage, and BMW has had issues with High pressure fuel pump with same engine as my vehicle. I feel this defect is extended to more vehicles than was stated BMW...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Engine & cooling
21 complaint records3 fire reports
"TL* THE CONTACT OWNS A 2014 BMW X5. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 18V755000 (ENGINE). AFTER CONTACTING GEBHARDT BMW (4740 VALMONT RD, BOULDER, CO), THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE NOT AVAILABLE...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Body & structure
15 complaint records2 fire reports
"I HAVE THE SOFT-CLOSE DOOR OPTION AND ON THREE OCCASIONS MY DRIVERS REAR DOOR HAS UNLATCHED WHILE DRIVING. IT DID NOT OPEN BUT, RATHER, BECAME UNLATCHED RESULTING IN A WARNING...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse body & structure parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA23001 opened Mar 2023 | OPEN | Fuel System, Diesel | High pressure fuel pump failure - led to recall 24V957 The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500... |
| EA21002 opened Sep 2021 | OPEN | Air Bags | Desiccated Air Bag Inflator Rupture From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 24V527000 | Air Bags | BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series... | Normally free |
| 23V797000 | Air Bags | BMW of North America, LLC (BMW) is recalling certain 2014 X3 xDrive28i, X3 xDrive35i, X5 sDrive35i, X5 xDrive35i, and 2015 X4 xDrive35i vehicles. | Normally free |
| 21V907000 | Fuel System, Diesel | BMW of North America, LLC (BMW) is recalling certain 2013-2018 328d, 328d xDrive, 2014-2018 328d Sports Wagon, 328d xDrive Sports Wagon, 2014-2016 535d, 535d xDrive, 2015 740Ld xDrive, 2015-2017 X3 xDrive28d SAV, and... | Normally free |
| 21V586000 | Fuel System, Diesel | BMW of North America, LLC (BMW) is recalling certain 2014-2018 328d, 328d xDrive, X5 xDrive35d, 2014-2016 535d, 535d xDrive, 2015 740Ld xDrive, and 2015-2017 X3 xDrive28d vehicles. The high-pressure fuel pump may fail. | Normally free |
| 18V755000 | Engine And Engine Cooling | BMW of North America, LLC (BMW) is recalling certain 2013-2018 BMW 328d and 328d xDrive, 2014-2018 328d Sports Wagon and 328d xDrive Sports Wagon, 2014-2016 535d and 535d xDrive, 2015 740Ld xDrive, 2015-2017 X3... | Normally free |
| 16V683000 | Air Bags | BMW of North America, LLC. (BMW) is recalling certain model year 2015 BMW X3 sDrive28i, X3 xDrive28i, X3 xDrive35i, X3 xDrive28d, X4 xDrive28i and X4 xDrive35i vehicles, and model year 2014-2015 X5 xDrive35i, X5... | Normally free |
| 15V147000 | Air Bags | BMW of North America, LLC (BMW) is recalling certain model year 2015 BMW X5 xDrive 35d Sports Activity Vehicles (SAV) manufactured August 19, 2014, to February 16, 2015, and 2014-2015 BMW X5 xDrive 35i, X5 sDrive 35i,... | Normally free |
| 14V202000 | Latches/Locks/Linkages | BMW of North America, LLC (BMW) is recalling certain model year 2014 X5 SAV vehicles manufactured December 12, 2013, through March 10, 2014, and equipped with the Soft Close Automatic (SCA) option. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2024544 2024-08-15 | Label | 587,250 | Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". |
| 2024402 2024-07-11 | Airbag | 312 | Issue: On certain vehicles, the driver-front airbag inflator could rupture when the airbag deploys in a crash. If this happens, the airbag may not properly inflate and fragments could be propelled toward vehicle occupants. |
| 2023634 2023-11-24 | Airbag | 7 | Issue: On a small number of vehicles, the driver-front airbag inflator could rupture when the airbag deploys in a crash. If this happens, the airbag may not properly inflate and fragments could be propelled toward vehicle occupants. |
| 2021711 2021-11-19 | Engine | 12,702 | Issue: On certain vehicles, the exhaust gas recirculation (EGR) cooler could crack internally and leak. If this happens, you may notice the following symptoms: a warning symbol in the instrument cluster displaying a loss of coolant,... |
| 2021469 2021-07-29 | Fuel System | 3,486 | Issue: On certain vehicles equipped with a diesel engine, the high-pressure fuel pump may wear prematurely. This can cause reduced engine performance and could lead to a sudden engine stall. |
Show 3 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2018587 2018-10-26 | Engine | 10,368 | This recall was replaced by Transport Canada Recall No. 2021-711. On certain vehicles, the cooler for Exhaust Gas Recirculation (EGR) module may develop an internal leak and coolant could mix with diesel engine soot/sediment. |
| 2016461 2016-09-21 | Airbag | 395 | On certain vehicles, the housing of the driver's frontal airbag inflator may have been incorrectly welded during manufacturing and could separate from the base plate during an airbag deployment. |
| 2014142 2014-04-22 | Structure | 250 | On certain vehicles, the rear side door lock mechanisms may have been manufactured incorrectly. As a result, child door locks may disengage if the interior rear door handle is pulled, thereby allowing a rear door to be opened with a second... |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| B011125 Aug 2025 | WARRANTY EXTENSION | Engine | The Exhaust Gas Recirculation (EGR) Cooler (with EGR Valve) and the Auxiliary Exhaust Gas Recirculation (EGR) Cooler limited warranty for defects in materials and / or workmanship has been extended to 25 years without mileage limit as determined from the original first... |
| B011018 Sep 2025 | WARRANTY EXTENSION | Engine | The N57T diesel engine’s Auxiliary Exhaust Gas Recirculation (EGR) Cooler’s component-specific extended limited warranty (ELW) now includes more Model vehicles. |
| b011125 Sep 2026 | WARRANTY EXTENSION | Engine | The Exhaust Gas Recirculation (EGR) Cooler (with EGR Valve) and the Auxiliary Exhaust Gas Recirculation (EGR) Cooler limited warranty for defects in materials and / or workmanship has been extended to 25 years without mileage limit as determined from the original first... |
| B061026 Jan 2026 | Structure | Bumper Return | |
| B010122 Jan 2026 | Engine | N63TU1 CLASS ACTION SETTLEMENT SVC CAMPAIGN: OIL CONSUMPTION DIAGNOSIS/REPAIR |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| B061125 Feb 2025 | Engine | Fan Housing With Fan Return | |
| B067424 Oct 2024 | Engine | Engine Mount Return | |
| B010520 Jan 2024 | Engine And Engine Cooling | The vehicle demonstrates a power loss and the malfunction indicator lamp (MIL) on. The following fault codes may be stored in the DDE: 24CE00 Hot film air mass meter: Ratio of measured to calculated air mass too high 27F000 Charge air hose monitoring in idle: Charge air hose... | |
| B510819 Jan 2024 | Visibility | The basic conditions for initializing the power windows are not met. | |
| B611305 Jan 2024 | Electrical System | The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. | |
| B160623 Dec 2023 | Fuel System | Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (-... | |
| B653423 Nov 2023 | Electrical System | Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle. Depending on the vehicleâÂÂs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. | |
| B522319 Oct 2023 | Seats | Second seat row blocking access to third seat row, program seat modules. Visible stitching on first row sport seat. Third seat row backrest Bowden cable routing and length change. | |
| B660523 Oct 2023 | Forward Collision Avoidance | Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer complaints. | |
| B540421 Oct 2023 | Structure | This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry | |
| B520121 Aug 2023 | Seats | ?The front seat will not calibrate/initialize, and the stored faults cannot be deleted. | |
| B010122 May 2023 | Equipment | With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Isley, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North America, LLC. | |
| B651523 May 2023 | Electrical System | After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes repeatedly fails. | |
| B840822 Mar 2023 | Electrical System | The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. | |
| B010122 Dec 2022 | Equipment | With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Isley, et al. v. Bayerische Motoren Werke Aktiengesellschaft and BMW of North America, LLC. | |
| B010919 Dec 2022 | Fuel System | For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Fuel Injectors to 10 years/120,000 miles as determined by the vehicle's original in-service date. | |
| B650414 Oct 2022 | Seats | According to the customer, the airbag warning light was on, but it may not be illuminated when the vehicle arrives in the workshop. 1. ACSM fault code "930A60 - Seat occupancy detection, front passenger; malfunction" is stored. The fault may or may not currently be present. | |
| B170222 Sep 2022 | Engine And Engine Cooling | Coolant is leaking from under the car which is equipped with the S63 engine. A low coolant warning might also be displayed (CC Message ID166). | |
| B520419 Sep 2022 | Seats | The driver's side (left rear) of the 60/40 split 2nd row seat may intermittently not fully latch into position on one side (inner rail). | |
| B520422 Sep 2022 | Seats | When returning the 2nd row seat 60% (left) side from Easy-Entry: The seat stops moving before reaching the final home position, a check control message (CCM) appears alerting the customer that the seat back is unlocked. | |
| B520622 Sep 2022 | Seats | When returning the 2nd row seat 40% (right) side from Easy-Entry: The seat stops moving before reaching the final home position, a check control message (CCM) appears alerting the customer that the seat back is unlocked. | |
| B521919 Sep 2022 | Seats | The passenger's side (right rear) of the 60/40 split 2nd row seat may intermittently not fully latch into position on one side (inner rail). | |
| B540421 Sep 2022 | Visibility | The front sunroof glass seal has shrunk, creating a gap which can cause wind noise or excess water entry. | |
| B610120 Sep 2022 | Electrical System | Customer is unable to power up or charge accessories through a plug adapter inserted in the front 12-volt power socket plug. Alternatively, it will only operate when constant downward hand pressure is maintained. | |
| B662419 Sep 2022 | Equipment | Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. | |
| B662719 Sep 2022 | Lane Departure | The Lane Change Warning (LCW) yellow triangle symbol on either one, or both the exterior side view mirrors does not illuminate to alert the driver when it should. | |
| SIB660322 Aug 2022 | Electrical System | Driver Assistance reduced checked control message (CCM) appears. All or some of the system functions maybe inoperative. The following fault will be stored: 481CC6. | |
| SIB160222 Jul 2022 | Fuel/Propulsion System | The fuel gauge may indicate the incorrect fuel level (full and reserve). | |
| SIB650222 Jun 2022 | Air Bags | A check control message for the restraint system appears. In the Instrument cluster, the red air bag warning light lights up permanently. | |
| SIB662419 Jun 2022 | Equipment | Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected. | |
| SIB651312 May 2022 | Electrical System | The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. | |
| SIB011918 May 2022 | Engine And Engine Cooling | Component specific limited warranty extension. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle Nitrogen Oxide (NOx) Sensor(s) to: 10 years/120,000 miles as determined by the vehicle original in-service date. | |
| B513019 Mar 2022 | Structure | A groaning noise is present from the door frame of any door, most commonly when driving over rough roads or during body flex. This situation may be worse in vehicles which are regularly waxed in the area of the door jamb. | |
| B010122 Feb 2022 | Communication | BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Isley, et al. v. BMW of North America, et al. The Court has granted final approval of the settlement. | |
| B010222 Feb 2022 | Communication | BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the following class action: Isley, et al. v. BMW of North America, et al. The Court has granted final approval of the settlement. | |
| B011417 Sep 2021 | Fuel System | For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's engine high pressure fuel pump (shown) to: 10 years/120,000 miles as determined by the vehicle's original in-service date. | |
| B651312 Sep 2021 | Equipment | The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. | |
| B840221 Jun 2021 | Equipment Adaptive/Mobility | The discontinuation of 3G cellular communication for Combox, TCB 3G and ATM 3G (Telematics ControlModule) can no longer be supported by the cellular network provider starting February 2022. | |
| B840121 May 2021 | Equipment | TELEMATICS UNIT DEACTIVATION DUE TO 3G CELLULAR TECHNOLOGY DISCONTINUATION: The discontinuation of 3G cellular communication for Combox, TCB 3G and ATM 3G (Telematics ControlModule) can no longer be supported by the cellular network provider starting February 2022. | |
| B840221 May 2021 | Equipment | TELEMATICS UNIT RETROFIT TO 4G CELLULAR TECHNOLOGY: The discontinuation of 3G cellular communication for Combox, TCB 3G and ATM 3G (Telematics ControlModule) can no longer be supported by the cellular network provider starting February 2022. | |
| B010919 Nov 2020 | Fuel System | DIESEL FUEL INJECTORS: LTD WTY EXTENSION TO 10 YEARS/120,000 MILES: Zero-quantity adaptation injector cylinder 1: permitted filtered actuation duration 24BB00 correction too high zero-quantity adaptation injector cylinder 2: permitted filtered actuation duration 24BF00... | |
| B612315 Nov 2020 | Visibility | Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full: Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full.There are no faults stored in the system for the washer fluid level switch. | |
| B611820 Sep 2020 | Electrical System | BMW TURBOCORD PORTABLE EV 120 V/240 V CHARGER: The BMW-approved accessory TurboCord electric vehicle (EV) charger will not charge the vehicle. | |
| B310112 Aug 2020 | Suspension | CRACKING NOISES FROM THE FRONTAXLE AREA WHILE TURNING THE WHEELS, WHEN STATION: Cracking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers) or when turning the steering wheel while stationary. | |
| B340517 Jul 2020 | Service Brakes | TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: Ticking noise coming from front wheel while cornering without brakes applied, noticeable at low speeds. The vehicle must be moving. | |
| B610419 Jul 2020 | Electrical System | VEHICLE DOES NOT START BATTERY TOTALLY DISCHARGED: The customer's vehicle does not start due to a totally discharged battery. | |
| B650709 Jul 2020 | Electrical System | NAVIGATION SYSTEM - REPORTING MISSING OR INCORRECT ROADMAP DATA: Do not replace parts and do not program the vehicle. Roads can change by up to 15% every year. To ensure the best navigation experience, we do everything in our power to create the best maps. | |
| B010520 Jun 2020 | Engine And Engine Cooling | N47T/N57T EGR COOLER LTD WTY EXTENSION TO 10 YEARS WITHOUT MILEAGE LIMIT: The vehicle demonstrates a power loss and the malfunction indicator lamp (MIL) on. The intake manifold (intake system) is found to have thermal deformation or damage. | |
| B610419 Jun 2020 | Electrical System | VEHICLE DOES NOT START BATTERY TOTALLY DISCHARGED: The customer's vehicle does not start due to a totally discharged battery. | |
| B340517 Apr 2020 | Service Brakes | TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: This Service Information Bulletin (Revision 3) replaces SI B34 05 17 dated September 2017. Ticking noise coming from front wheel while cornering without brakes applied noticeable at low speeds. The vehicle must be moving. | |
| B513016 Apr 2020 | Parking Brake | TAILGATE UNINTENTIONALLY OPENS: This Service Information Bulletin (Revision 4) replaces SI B51 30 16 dated March 2018. Trunk/tailgate may open when vehicle is locked Trunk/tailgate may open while the vehicle is in motion usually after stopping such as a traffic light etc. | |
| B610920 Apr 2020 | Electrical System | CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction. | |
| B652214 Apr 2020 | Equipment | AUTOMATED ACTIVATION OF NAVIGATION SYSTEM DURING PDI/QC1: This Service Information Bulletin (Revision 2) replaces SI B65 22 14 dated October 2015. The INITIAL NAV enabling code no longer needs to be pre-ordered through the Parts department! | |
| B840214 Apr 2020 | Electrical System | CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION: This Service Information Bulletin (Revision 7) replaces SI B84 02 14 dated May 2019. ConnectedDrive/BMW Assist features are partially or completely inoperative. | |
| B010520 Apr 2020 | Power Train | N47T/N57T EGR COOLER - LTD WTY EXTENSION TO 10 YEARS WITHOUT MILEAGE LIMIT: The vehicle demonstrates a power loss and the malfunction indicator lamp (MIL) on. |
Showing 60 of 393 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Walk the body slowly in daylight.Panel gaps, rust at the rockers and wheel arches, and cracked trim are this vehicle's structure complaints. Open and close the liftgate or trunk and look at the latch area.
- Run the VIN against open recalls before you negotiate.This vehicle has 8 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask the dealer whether the warranty extension on file still applies to this VIN.The manufacturer issued 3 warranty extensions for this vehicle (see the service bulletins section). Extended coverage often runs by years or miles from the original sale, and a repair the seller paid for may have been free.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this BMW X5 →