Engine
5.7L 8-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 237 of 237 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 149 of 237 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Electrical system
72 complaint records2 fire reports2 crash reports
"VEHICLE WAS PARKED AND UNOCCUPIED BUT RUNNING AND IT SLIPPED OUT OF GEAR AND ROLLED INTO A PARKED VEHICLE. CLAIM NUMBER 20-5560-F20..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Power train
70 complaint records10 crash reports
"MANUFACTURERS HAVE NOTIFIED ME BY MAILERS. DEALERSHIPS HAVE FAILED TO NOTIFY ME. WHEN I HAVE CONTACTED THEM, THEY NEVER HAVE PARTS IN STOCK...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Engine & cooling
28 complaint records
"MISFIRING AFTER SPARK PLUGS HAVE BEEN CHANGED. COIL WAS CHECKED AS WELL AS INJECTOR PULSE, WHICH WERE FINE. ENGINE LIGHTS STAYS ON AND MISFIRING HAPPENS WHEN CAR IS IDLE...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA21002 opened Sep 2021 | OPEN | Air Bags | Desiccated Air Bag Inflator Rupture From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. |
| EA16002 opened Feb 2016 | closed Jun 2016 | Power Train | Vehicle rollaway, engine on - led to recall 16V424000 On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 19V018000DO NOT DRIVE | Air Bags | Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. | Normally free |
| 18V332000 | Vehicle Speed Control | Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and... | Normally free |
| 17V741000 | Electrical System | Chrysler (FCA US LLC) is recalling certain 2014 Dodge Challenger, Charger, Durango, Chrysler 300, and Jeep Grand Cherokee vehicles equipped with a 3.6L engine and a 160 amp alternator. | Normally free |
| 17V435000 | Electrical System | Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. | Normally free |
| 17V097000 | Power Train | Chrysler (FCA US LLC) is recalling certain 2014-2017 Dodge Charger and Chrysler 300 vehicles equipped with all-wheel drive (AWD). | Normally free |
| 16V240000 | Power Train | Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Dodge Charger and Chrysler 300 vehicles manufactured February 15, 2011, to November 27, 2014, and 2014-2015 Jeep Grand Cherokee vehicles manufactured July... | Normally free |
| 14V634000 | Electrical System | Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014,... | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2024548 2024-08-15 | Label | 314,717 | Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". |
| 2019016 2019-01-11 | Airbag | 79,206 | Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. |
| 2018396 2018-07-27 | Accessories | 142 | Note: This recall affects the following Powertrain Control Modules (PCM) that were sold through dealers as high-performance accessories: - Mopar Stage 1 high performance Powertrain Control Modules (PCM), part numbers P5160023 and P5160025... |
| 2018269 2018-05-17 | Engine | 635,880 | On certain vehicles, an electronic fault may create a situation where the cruise control cannot be deactivated. |
| 2017574 2017-11-22 | Electrical | 687 | On certain vehicles equipped with 3.6L engines and 160 amp output alternators, the alternator may fail suddenly. |
Show 4 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2017341 2017-07-10 | Electrical | 29,625 | On certain vehicles equipped with electro-hydraulic power steering (“EHPS”), the alternator may fail suddenly. |
| 2017081 2017-02-15 | Powertrain | 5,206 | On certain all-wheel drive vehicles, the front propshaft bolts may be loose. This could result in the front propshaft disconnecting from the vehicle, which would lead to loss of motive power while driving and could also damage powertrain... |
| 2016184 2016-04-26 | Powertrain | 51,625 | On certain vehicles, the gear shift position indicators and warnings may not be sufficient to deter drivers from exiting the vehicle when the transmission is inadvertently left in a gear other than “Park”. |
| 2014446 2014-10-09 | Electrical | 16,080 | On certain vehicles equipped with 3.6L engines and 160 amp output alternators, the alternator may fail suddenly. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| S2621000003 REV.A Mar 2026 | Power Train | The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. | |
| S2608000010 Mar 2026 | Electrical System | Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH) | |
| 108463 Nov 2025 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE | |
| 108464 Nov 2025 | Service Brakes | PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE | |
| 31-001-25 REV. B Aug 2025 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 31-001-25 Aug 2025 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates | |
| S2208000138 REV.B Jul 2025 | Electrical System | Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed | |
| 103239 Feb 2025 | Air Bags | AIR BAG - SIDE CURTAIN | |
| 31-001-24 Jul 2024 | Structure | "Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| S1408000384 Jan 2024 | Electrical System | Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On | |
| 9100229 Sep 2023 | Suspension | LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. | |
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. | |
| 93023 Aug 2023 | Equipment | Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B) | |
| 93120 Aug 2023 | Equipment | FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC | |
| 9100196 Jul 2023 | Equipment | Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used | |
| 0815223 Jun 2023 | Electrical System | Fuel Pump Connector Replacement The technician may experience a crank/no start after the fuel pump module was replaced. This bulletin involves replacing the fuel pump connector harness (pigtail) when replacing the fuel pump module. | |
| 0700723 May 2023 | Engine And Engine Cooling | Water Quality When Mixed With Engine Coolant | |
| 1804823 Apr 2023 | Equipment | wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK | |
| 9003357a Feb 2023 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. | |
| 9003357 Feb 2023 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. | |
| S1408000384 Feb 2023 | Electrical System | Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On | |
| 3100123 Feb 2023 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| 31-002-22 Dec 2022 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| S2208000138RevA Oct 2022 | Service Brakes | Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed | |
| 3100122 Aug 2022 | Structure | Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural... | |
| S2208000138 Jul 2022 | Electrical System | Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed | |
| 9004557 Jun 2022 | Equipment | Overhead Console If the sunglasses holder door in the overhead console will not stay closed, inspect the Latch for damage. The Latch is now released for service under part number 68599540A$. | |
| S2208000131 Jun 2022 | Fuel System | No Start Condition After A Fuel Pump Replacement, Multiple Fuel System Level Related DTC?s Setting | |
| 68234120A Apr 2022 | Equipment | Panasonic 8.4" CTP/FCTP Radio, Update Failure | |
| 9004509 Apr 2022 | Seats | Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold For concerns of V8 oil filter leaks on 22MY and up vehicles: 1. | |
| S2209000004 Apr 2022 | Engine And Engine Cooling | If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. | |
| 9004509 Mar 2022 | Fuel System | Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold | |
| S1709000010 RevB Mar 2022 | Engine And Engine Cooling | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| S1709000010RevB Mar 2022 | Unknown Or Other | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| S1709000010 Mar 2022 | Power Train | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| S2109000004 Jul 2021 | Engine And Engine Cooling | Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. | |
| 9004386 Jun 2021 | Electrical System | WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Redacted Content | |
| S1809000007 Rev. May 2021 | Engine And Engine Cooling | Customer Complaint May Include Engine Oil Leak Or Consumption | |
| S1809000007 May 2021 | Engine | Customer Complaint May Include Engine Oil Leak Or Consumption | |
| S2008000113 Rev. Apr 2021 | Power Train | No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message | |
| S2008000113 Apr 2021 | Electrical System | No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message | |
| S1821000001 Apr 2021 | Power Train | Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders | |
| 3100121 Apr 2021 | Equipment Adaptive/Mobility | Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required. | |
| 9004009 Apr 2021 | Power Train | Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. | |
| 08-054-21 Apr 2021 | Power Train | High Beam Headlamps Flicker This bulletin involves installing jumper wires from the Power Distribution Center(PDC) to the headlamp connectors. | |
| 0805421 Apr 2021 | Power Train | High Beam Headlamps Flicker This bulletin involves installing jumper wires from the Power Distribution Center(PDC) to the headlamp connectors. | |
| 9003357 Mar 2021 | Engine And Engine Cooling | ADAPTER, Engine Oil Filter (Pentastar V6) All vehicles equipped with a 3.2L or 3.6L except for model year 2014 vehicles with leak concern: 1) Ensure the Oil Filter Adapter (OFA) Cap O-ring is seated in the proper groove in the cap and not damaged or cut. | |
| 9004361 Mar 2021 | Power Train | NAG1 Transmission Before installing the transmission with the engine, check for dowel pins (2) for alignment. If the pins are missing request to add the dowel pin first and then install the transmission | |
| S1809000007 Rev. Mar 2021 | Engine And Engine Cooling | Customer complaint may include engine oil leak/consumption. | |
| S1709000010 Rev. Jan 2021 | Engine And Engine Cooling | Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. | |
| 23-042-20 Dec 2020 | Equipment Adaptive/Mobility | Headlamp Condensation and Fogging This bulletin involves installing updated vent caps on the headlamp assembly. Customers may experience the following:One or both of the vehicle?s headlamp assemblies are fogged with a light layer of condensation on the inside of the lenses. | |
| 31-002-20 Oct 2020 | Structure | Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. | |
| 3100220 Oct 2020 | Structure | Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. | |
| S2025000001 Rev. Sep 2020 | Electrical System | (Revision A) Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level Sensor 1 Circuit Intermittent-Erratic Set. | |
| 18-073-20 Aug 2020 | Electrical System | Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. | |
| 1807320 Aug 2020 | Power Train | Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. | |
| S2008000113 Aug 2020 | Engine | No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle | |
| 9003704 Jul 2020 | Equipment | Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. | |
| S2008000093 Jun 2020 | Electrical System | Blind Spot Or Park Assist Warnings, False Activation | |
| S2008000081 Jun 2020 | Equipment Adaptive/Mobility | Cruise Control Inoperative. |
Showing 60 of 241 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Run the VIN against open recalls before you negotiate.This vehicle has 7 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Do not drive it home until the do-not-drive recall is confirmed repaired.At least one campaign on this vehicle carries a federal do-not-drive advisory. Confirm the repair with the dealer, by VIN, before taking delivery.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Chrysler 300 →