Engine
1.4L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 92 of 92 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 52 of 92 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Power train
34 complaint records2 fire reports
"WHILE USING CRUISE CONTROL AND RESUMING OR INCREASING THE SPEED TO A HIGHER SPEED, THE TRANSMISSION SLAMS INTO GEAR INSTEAD OF TRANSITIONING...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Electrical system
28 complaint records1 crash report
"LOSS OF TOTAL DASH DISPLAY AT ANY GIVEN TIME , HAVE TO DISCONNECT BATTERY FOR 5MINS RECONNECT TO REGAIN DASH BACK , THIS STARTED DAY 1 OF PURCHASE WHEN PULLING OFF THE CAR LOT ...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Engine & cooling
12 complaint records1 crash report
"THE RECALL WAS STOPPED AT 74 000 MILES AND NOW I NEED TO BUY A NEW CARE I HAVE AN OIL LEAK ON THE DRIVERS SIDE OF\ENGINE BY THE CAM SEAL, ACTUATOR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA19001 opened Apr 2019 | closed Sep 2024 | Air Bags | Electrical overstress - led to recall 20V024 The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 24V474000 | Tires | Chrysler (FCA US, LLC) is recalling certain 2014-2019 Fiat 500 vehicles. The tire pressure monitoring system (TPMS) warning light may not illuminate as intended. | Normally free |
| 16V302000 | Power Train | Chrysler (FCA US LLC) is recalling certain model year 2012-2016 Fiat 500 vehicles manufactured June 21, 2010, through January 12, 2016, equipped with a manual transmission. | Normally free |
| 15V291000 | Power Train | Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Fiat 500 battery electric vehicles manufactured March 8, 2013, to March 7, 2015. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2024548 2024-08-15 | Label | 314,717 | Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". |
| 2016217 2016-05-12 | Powertrain | 7,819 | On certain vehicles equipped with a manual transmission, clutch diaphragm springs may crack or become damaged, which could result in the driver being unable to shift gears, or potentially result in a loss of motive power. |
| 2015578 2015-12-04 | Lights And Instruments | 17,516 | Fiat Chrysler Automobiles (FCA) Canada is conducting a voluntary Customer Satisfaction Notification Program involving certain vehicles equipped with automatic transmissions. |
| 2015417 2015-09-22 | Airbag | 51 | Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 208 - Occupant Protection. Improper passenger airbag folding could prevent the airbag from inflating as intended. |
| 2014340 2014-08-07 | Airbag | 4,076 | On certain vehicles, the driver's knee airbag may have been folded incorrectly at time of assembly. This could cause irregular airbag deployment, which could increase the risk of injury to an unbelted driver in a crash that warrants airbag... |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 23-021-26 Jun 2026 | Structure | Broken Exterior Driver And/Or Passenger Door Handles XB2 Warranty Extension Customers may comment the following: ● One or both exterior door handles are broken. This bulletin involves replacing one or both exterior door handles. | |
| S2524000012 Oct 2025 | Unknown Or Other | High Voltage Air Conditioning Refrigerant Dye | |
| 31-001-25 REV. B Aug 2025 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| 31-001-25 REV. A Aug 2025 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| 31-001-25 Aug 2025 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 9100624 Jul 2025 | Engine | Verify Reman part number availability. Order the "R" part number for all orders: | |
| 31-001-24 Jul 2024 | Structure | "Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| S1408000384 Jan 2024 | Electrical System | Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On | |
| 1000123 Nov 2023 | Air Bags | Air Bag Warning Lamp Illumination Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) has been set: ? | |
| 9100229 Sep 2023 | Suspension | LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect. | |
| 9100226 Sep 2023 | Electrical System | Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. | |
| 93023 Aug 2023 | Equipment | Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B) | |
| 93120 Aug 2023 | Equipment | FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC | |
| 1000123 Aug 2023 | Electrical System | Air Bag Warning lamp Illumination Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) has been set: ? | |
| 9100196 Jul 2023 | Equipment | Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used | |
| 0700723 May 2023 | Engine And Engine Cooling | Water Quality When Mixed With Engine Coolant | |
| 1804823 Apr 2023 | Engine And Engine Cooling | wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK | |
| S1408000384 Feb 2023 | Electrical System | Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On | |
| 3100123 Feb 2023 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| 31-002-22 Dec 2022 | Structure | Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. | |
| 3100122 Aug 2022 | Structure | Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural... | |
| S2209000004 Apr 2022 | Engine And Engine Cooling | If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. | |
| 9004505 Mar 2022 | Equipment | Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any visually damaged battery to the supplier. Improper handling of damaged lithium ion batteries can cause property damage, serious injury or even death. | |
| 08-177-21 Nov 2021 | Hybrid Propulsion System | BEV/Hybrid - Showroom and Display Vehicle Battery Maintenance This information only bulletin discusses procedures that must be followed for BEV/Hybrid vehicles that are on display at dealership showrooms. | |
| S2108000163 Jul 2021 | Electrical System | No Start, Cannot Complete Module Replace, Proxi Or Module Proxi Configuration | |
| S2109000004 Jul 2021 | Engine And Engine Cooling | Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle. | |
| S1809000007 Jun 2021 | Engine And Engine Cooling | Customer Complaint May Include Engine Oil Leak Or Consumption | |
| S1809000007RevC Jun 2021 | Engine And Engine Cooling | Customer Complaint May Include Engine Oil Leak Or Consumption | |
| 9004386 Jun 2021 | Electrical System | WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Redacted Content | |
| S1608000226 Apr 2021 | Equipment | Battery Tester Warranty Code Procedures, Midtronics Charger Update Process | |
| S1821000001 Apr 2021 | Power Train | Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders | |
| S16080002261 Apr 2021 | Electrical System | Battery Tester Warranty Code Procedures, Medtronic Update Process | |
| 9004009 Apr 2021 | Power Train | Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. | |
| S1809000007 Rev. Mar 2021 | Engine And Engine Cooling | Customer complaint may include engine oil leak/consumption. | |
| 08-027-21 Feb 2021 | Power Train | Flash: Drivetrain Control Module (DTCM) Diagnostic and System Improvements This bulletin involves reprogramming the DTCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. | |
| 0802721 Feb 2021 | Power Train | Flash: Drivetrain Control Module (DTCM) Diagnostic and System Improvements This bulletin involves reprogramming the DTCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. | |
| 31-002-20 Oct 2020 | Structure | Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. | |
| 3100220 Oct 2020 | Structure | Aluminum Body Panel Corrosion Repair This bulletin involves inspecting and if necessary removing corrosion and refinishingthe suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels. | |
| S2008000118 Aug 2020 | Electrical System | HVAC Control Panel Illumination Inoperative | |
| S1508000374 Jul 2020 | Electrical System | Keys/Fobiks, Programming Keys With High Line BCM (L3 BCM) | |
| S2008000093 Jun 2020 | Electrical System | Blind Spot Or Park Assist Warnings, False Activation | |
| 23-015-20 Apr 2020 | Equipment | Disinfectant Solution Recommended for COVID-19 | |
| 08-049-20 Apr 2020 | Equipment | Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary. | |
| 18-039-20 Apr 2020 | Fuel System | Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season | |
| S2019000002 Apr 2020 | Steering | Hands On Steering Wheel Message In EVIC | |
| 08-027-20 Mar 2020 | Electrical System | 2.4L Ignition Coil Boot Replacement This bulletin involves replacing all four ignition coil insulating boots. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. | |
| 9004022 Dec 2019 | Suspension | Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. | |
| 31-006-19 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 31-004-19 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 31-003-19 Nov 2019 | Equipment | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 31-005-19 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 3100619 Nov 2019 | Structure | Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. | |
| 3100419 Nov 2019 | Visibility | Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass. | |
| 3100319 Nov 2019 | Structure | Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. | |
| 3100519 Nov 2019 | Structure | Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. | |
| 18-089-19 Nov 2019 | Engine | wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK | |
| 1808919 Nov 2019 | Engine And Engine Cooling | wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK | |
| 9003220 Aug 2019 | Equipment | RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". | |
| 9003791 Oct 2017 | Equipment | 1.4L FIRE Service Engine (Normally Aspirated) This engine in this kit will contain one of 8 different production full dress engines, but labeled as component engine 68275870AA or 71AA. | |
| 9003355 Sep 2017 | Engine And Engine Cooling | 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If a cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people. |
Showing 60 of 135 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Run the VIN against open recalls before you negotiate.This vehicle has 3 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Fiat 500 →