Engine
5.3L 8-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 838 of 839 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 171 of 839 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Engine & cooling
442 complaint records4 fire reports4 crash reports
"6.2 engine failure second motor put in last week dealer took for test drive truck was towed back for second engine failure..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Power train
243 complaint records5 crash reports
"ENGINE IS JERKY READ ONLINE ISSUES HAVE A LEMON LAWSUIT . THE DEALERSHIP SAID IT WAS AN 02 SENSOR IT DIDNT FIXED THE ISSUES..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Electrical system
112 complaint records4 fire reports2 crash reports
"Driver side front marker light bulb not working after 700mi. Not a big problem but annoying enough for a 2 week old, $49,000 truck...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| EA26005 opened Aug 2026 | OPEN | Engine | Loss of motive power due to engine failure post recall remedy On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. |
| EA25007 opened Oct 2025 | OPEN | Engine And Engine Cooling | Loss of motive power due to engine failure The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. |
| RQ26001 opened Jan 2026 | closed Aug 2026 | Engine | Loss of motive power due to engine failure post recall remedy On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. |
| PE25001 opened Jan 2025 | closed Oct 2025 | Engine And Engine Cooling | Loss of motive power due to engine failure - led to recall 25V274 On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L... |
| PE21010 opened Apr 2021 | closed Aug 2023 | Air Bags | Air Bag Malfunction On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 26V083000 | Power Train | General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under... | Normally free |
| 25V274000 | Engine And Engine Cooling | General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. | Normally free |
| 24V797000 | Power Train | General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL... | Normally free |
| 21V985000 | Tires | General Motors (GM) is recalling certain 2019-2021 GMC Sierra 1500 and Silverado 1500 vehicles equipped with certain accessory road tires and a 17" spare tire. | Normally free |
| 21V495000 | Air Bags | General Motors, LLC. (GM) is recalling certain 2021 Chevrolet Silverado 1500 vehicles. The front driver's side air bag module may be missing one or more metal tabs that secure the plastic air bag cover to the housing. | Normally free |
| 20V811000 | Seat Belts | General Motors, LLC (GM) is recalling certain 2020 Chevrolet Bolt EV and 2021 GMC Canyon and Sierra 1500, 2500 and 3500, Yukon, Yukon XL, Cadillac Escalade and Escalade ESV and Chevrolet Blazer, Camaro, Colorado,... | Normally free |
| 20V792000 | Seat Belts | General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra... | Normally free |
| 20V684000 | Tires | General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5, GMC Acadia and Chevrolet Traverse vehicles and 2020-2021 Chevrolet Silverado 1500, GMC Sierra 1500 vehicles. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2026060 2026-02-12 | Powertrain | 46 | Issue: On certain vehicles, the recall repairs completed by a General Motors dealer during recall N242454440 (Transport Canada recall no. 2024-637) may not have been done correctly. As a result, a second repair is required. |
| 2025225 2025-04-24 | Engine | 49,848 | Issue: On certain vehicles, the connecting rods and/or crankshaft components may not have been manufactured properly. As a result, the engine could make abnormal noises and a warning light may turn on. |
| 2024637 2024-10-24 | Powertrain | 52,309 | Issue: Over time, the transmission control valve could wear and lose pressure. If this happens, the transmission could shift harshly and could cause the rear wheels to lock up. |
| 2024060 2024-02-01 | Lights And Instruments | 273,306 | Issue: On certain vehicles, a software problem could cause the lower beam headlamps not to turn on as it becomes dark outside if the multi-function switch is in the "OFF" or "PARKING LAMP" position. |
| 2024061 2024-02-01 | Structure | 249,132 | Issue: On certain trucks, water could leak into the exterior tailgate switch. As a result, the tailgate could unlatch and open unexpectedly while parked. |
Show 6 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2022160 2022-03-31 | Accessories | 1,520 | Issue: This recall is a new notification for owners that purchased a soft or hard tri-fold tonneau cover from a General Motors dealer. On certain trucks, the bed-cover could come loose while driving and detach from the truck. |
| 2021767 2021-12-17 | Tires | 14 | Issue: This recall affects certain trucks equipped with optional 18", 20", or 22" wheels and tires. The spare tire has a smaller diameter than the tires on the truck. |
| 2021602 2021-09-29 | Brakes | 248 | Issue: On certain trucks, the bolts that attach the brake pressure modulator valve (BPMV) assembly may not be properly tightened. As a result, water can enter the BPMV and cause a short circuit. |
| 2020645 2020-12-23 | Seats And Restraints | 41 | Issue: On certain vehicles, the seat belts may have been installed with the wrong bolts. As a result, the seat belt may not be properly attached and may not work as designed in a crash. |
| 2020624 2020-12-17 | Seats And Restraints | 71,484 | Issue: On certain trucks, the seat belt brackets for the front-row centre seat may not be properly attached to the seat frame. As a result, the seat belt could detach, and may not work as designed in a crash. |
| 2020530 2020-11-06 | Tires | 629 | Issue: Certain vehicles were built with tires that may have been cured too long. As a result, the sidewall could crack or the tread and belts could separate. This could lead to a sudden loss of air pressure and could cause a tire failure. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 22-NA-244 May 2024 | WARRANTY EXTENSION | Electrical System | This service bulletin provides information about GM Accessories - Dealer-Installed, Repaired or Replaced During Warranty Coverage Period. |
| PIT6477D Oct 2026 | Unknown Or Other | This preliminary PI was created to advise techniians in the field that they will not be able to perform a GDS automated bleed with the scan tool dues to a issue with the software in the scan tool | |
| PIT5698F Sep 2026 | Unknown Or Other | This PI provides Diagnostics tips on how the LIN bus works and how to diagnosis it. | |
| PIP5700H Sep 2026 | Unknown Or Other | This PI communicates the proper part numbers for transmission connectors and internal harness to prevent confusion when ordering | |
| PIP4902W Sep 2026 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| PIP6127A Aug 2026 | Unknown Or Other | This document assists GM dealer technicians with diagnosing torque converter concerns to ensure torque converter replacement is necessary. | |
| PIC6551C Aug 2026 | Unknown Or Other | This Preliminary information communicates to dealer to perform a MEC reset for wireless projection issues | |
| PIT6031B Aug 2026 | Unknown Or Other | This Preliminary information communicates an issue where an aftermarket autostop device or rear taillights is causing a dead battery. | |
| PIP6127 Jul 2026 | Unknown Or Other | This document assists GM dealer technicians with diagnosing torque converter concerns to ensure torque converter replacement is necessary. | |
| PIT5680B Jul 2026 | Unknown Or Other | This PI provides information to repair the door water deflector which is not sealed properly allows water into the door jam/sill area. | |
| PIT5509N Jul 2026 | Unknown Or Other | This PI provides diagnostic tips for diagnosing electric trailer brakes issues. | |
| PIT5099J Jul 2026 | Unknown Or Other | PI to help diagnose A/C concern | |
| PIT6473F Jul 2026 | Unknown Or Other | This PI was created to help avoid unnecessary front camera module replacements | |
| PIT5767B Jul 2026 | Unknown Or Other | This PI provides a diagnostic tip on poor a/c performance due to a condenser issue and instructions to replace the ac condenser. | |
| PIT6532 Jul 2026 | Unknown Or Other | The purpose of this PI is to inform dealer technicians of a normal cab pressure relief valve noise to avoid unnecessary part replacement | |
| PIT5966F Jun 2026 | Unknown Or Other | This Preliminary information communicates an issue with an OTA pending message still displayed after an OTA event and how to reset/clear the message. | |
| PIT6523 Jun 2026 | Unknown Or Other | This PI provides diagnostic steps for dealer technicians to verify the condition and ensure that part replacement is necessary | |
| PIT6132E Jun 2026 | Unknown Or Other | This Preliminary information communicates an issues with the HVAC making a hum buzz noise when the blower is set to a higher speed. Engineering is working on a new HVAC door seal material to correct the noise. | |
| PIP6115 May 2026 | Unknown Or Other | The document advise technicians after an engine repair involving removal of the camshaft actuators, the vehicle may set p1101 P0172 and or stalls when taken off idle. | |
| PIT5509M May 2026 | Unknown Or Other | This PI provides diagnostic tips for diagnosing electric trailer brakes issues. | |
| N25-250552 May 2026 | SOFTWARE UPDATE | Unknown Or Other | • Improvements to OnStar functionality. |
| PIC6551B May 2026 | Unknown Or Other | This Preliminary information communicates to dealer to perform a MEC reset for wireless projection issues | |
| PIC6423A May 2026 | Unknown Or Other | Pi created to provide GM dealers with information on gathering information for projection issue | |
| PIT5687B May 2026 | Unknown Or Other | This PI provide diagnostic tip for an SES MIL with DTC P16A7 and/or P16AF. Dealers are to inspect for a loose connection. | |
| PIT6247B May 2026 | Unknown Or Other | This Preliminary information communicates direction to find information at www.gmupfitter.com for Police and Special Service Vehicles. | |
| PIT5689N Apr 2026 | Unknown Or Other | This Preliminary information communicates that some customers may comment that after an auto-stop event the engine does not restart and to inspect the engine ground strap. Temporarily on hold while PIE0572 is active. PIE0572 has now ended and reinstating the PI. | |
| PIT3271Q Apr 2026 | Unknown Or Other | This preliminary information communicates information about how to determine if a wheel and tires size change is available. | |
| PIT6473E Mar 2026 | Unknown Or Other | This PI was created to help avoid unnecessary front camera module replacements | |
| N25-250552 Mar 2026 | SOFTWARE UPDATE | Unknown Or Other | Improvements to OnStar functionality. |
| PIT6473D Mar 2026 | Unknown Or Other | This PI was created to help avoid unnecessary front camera module replacements | |
| PIT6473C Mar 2026 | Unknown Or Other | This PI was created to help avoid unnecessary front camera module replacements | |
| PIP4902V Mar 2026 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. | |
| PIP6104 Mar 2026 | Unknown Or Other | This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect. | |
| PIT6473B Mar 2026 | Unknown Or Other | This Preliminary Information communicates direction for different audio issues with RPO UQA, UQF, UQS, or NKD | |
| PIT6425D Mar 2026 | Unknown Or Other | This Preliminary information communicates to the field on how to diagnosis a GPS issue with the Telematic module with no DTC'ss | |
| PIT5744F Feb 2026 | Unknown Or Other | This Preliminary information communicates information on how to disable the Side Blind Zone Detection and Park Assist systems when a customer removes the pickup box from the vehicle to install an aftermarket bed or body. | |
| PIT5697E Feb 2026 | Unknown Or Other | This Preliminary information communication provides information to the technician on installing Regular Production Option Code UVC Rearview Camera. Technician will need to reference the latest version of General Motors Up-fitter Integration Bulletin 152. | |
| PIT6489 Feb 2026 | Unknown Or Other | This preliminary information communicates an issue with the engine running after the ignition is turned off and diagnostic help to isolate a possible Fuel Pump Control Module issue. | |
| PIP5865L Feb 2026 | Unknown Or Other | This Preliminary information communicates the possibility of DTC P30BF failing on low mile vehicles due to the possibility of the cylinder 1/2 sliding barrel binding on intake camshaft. | |
| PIT6483 Feb 2026 | Unknown Or Other | This preliminary information communicates an issue with aftermarket LED headlights causing IPC warning messages and MIL along with several low speed lan DTCs. | |
| N25-250552 Feb 2026 | SOFTWARE UPDATE | Unknown Or Other | Improvements to OnStar functionality. During the update process, your radio may stay on up to 5 minutes after you exit the vehicle. This is expected behavior when an update package is onboard the vehicle. Do not service your vehicle during installation. |
| PIP5921B Jan 2026 | Unknown Or Other | This Preliminary information communicates the possibility of DTC p0011 p0016 and potential for a rattle or ticking noise to occur from the Intake Cam Actuator, or cover plate screws backing out and making contact with Cam carrier | |
| PIP5865K Jan 2026 | Unknown Or Other | This Preliminary information communicates the possibility of DTC P30BF failing on low mile vehicles due to the possibility of the cylinder 1/2 sliding barrel binding on intake camshaft. | |
| N252515590 Jan 2026 | SERVICE CAMPAIGN | Electrical System | Certain vehicles listed above, may have a condition in which the body-to-chassis ground strap may be corroded. Dealers will replace the ground strap. |
| N252494003-02 Jan 2026 | SERVICE CAMPAIGN | Engine | Certain vehicles listed above, may have a condition where the connecting rod and/or crankshaft engine components in these vehicles may have manufacturing defects that can lead to engine damage and engine failure. |
| PIT6425C Jan 2026 | Unknown Or Other | This Preliminary information communicates to the field on how to diagnosis a GPS issue with the Telematic module with no DTC's | |
| PIT6400A Jan 2026 | Unknown Or Other | This PI Communications information on an alternative product dealers can use to perform 19-NA-255: Wax Coating on Frame Peeling, Metal Shows Corrosion/Rusting due to issue with getting product from current supplier listed in the bulletin. | |
| PIT6344A Jan 2026 | Unknown Or Other | This Preliminary information communicates an issue with blower motor speed changing when air flow is blocked by snow. | |
| PIP6098 Jan 2026 | Unknown Or Other | This PI advised dealer technicians of possible causes of diesel fuel contamination in gasoline powered vehicles and advises of warranty direction. | |
| PIP5700G Jan 2026 | Unknown Or Other | This PI communicates the proper part numbers for transmission connectors and internal harness to prevent confusion when ordering | |
| PIP4902U Jan 2026 | Unknown Or Other | This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance. | |
| PIT5828E Jan 2026 | Unknown Or Other | This Preliminary Information communication provides information to the technician about customers that may request the factory Integrated Trailer Brake Controller Regular Production Option Code (JL1) be installed on their Full-Size Pickup or SUV when the vehicle was not ordered... | |
| N252534200 Jan 2026 | SERVICE CAMPAIGN | Unknown Or Other | General Motors has decided to conduct a voluntary emissions recall. A Vehicle Emissions Control Information (VECI) label with correct information may not be present. Dealers are to install a new VECI label. |
| PIT6276B Jan 2026 | Unknown Or Other | This Preliminary information communicates an issue with a service keyless entry message caused by aftermarket door handle covers and they should be removed. | |
| PIT5689M Dec 2025 | Unknown Or Other | This Preliminary information communicates that some customers may comment that after an auto-stop event the engine does not restart and to inspect the engine ground strap. Temporarily on hold while PIE0572 is active. PIE0572 has now ended and reinstating the PI. | |
| PIT5984A Dec 2025 | Unknown Or Other | This Preliminary information communicates a diagnostic tip for an issue where the starter stays engaged after the engine starts. Dealers are to suspect/monitor the crankshaft position sensor. | |
| N25-250552 Dec 2025 | SOFTWARE UPDATE | Unknown Or Other | Improvements to OnStar functionality. During the update process, your radio may stay on up to 5 minutes after you exit the vehicle. This is expected behavior when an update package is onboard the vehicle. Do not service your vehicle during installation. |
| PIT6132D Nov 2025 | Unknown Or Other | This Preliminary information communicates an issues with the HVAC making a hum buzz noise when the blower is set to a higher speed. Engineering is working on a new HVAC door seal material to correct the noise. | |
| PIT5214G Nov 2025 | Unknown Or Other | This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical... | |
| PIT6451 Nov 2025 | Unknown Or Other | This PI communicates information that Engineering is aware of concern and working to correct false Service Trailer Turn Signal Message when operating the power tailgate with no trailer connected. |
Showing 60 of 1393 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Run the VIN against open recalls before you negotiate.This vehicle has 8 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask the dealer whether the warranty extension on file still applies to this VIN.The manufacturer issued 1 warranty extension for this vehicle (see the service bulletins section). Extended coverage often runs by years or miles from the original sale, and a repair the seller paid for may have been free.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Chevrolet Silverado 1500 →