Engine
2.7L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 595 of 595 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 130 of 595 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Power train
161 complaint records1 fire report5 crash reports
"Throwing an Active Air Dam fault, I noticed this was an issue with the F150 Lightning. However it is also doing it on the gas 2022 F150...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Electrical system
128 complaint records1 crash report
"When driving the vehicle shut off power for 5sec but doesn’t shut off vehicle (all electrical off ) then kick back on ,idling high..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Fuel system
89 complaint records1 fire report
"Recall Number 25S75 issued July 08.2025 and still not fixed. That is over a year now, how long before they have to apply to the recall...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Federal defect investigations
Formal investigations opened by the federal safety agency into this vehicle. An investigation is the step between a complaint pattern and a recall; not every one results in one.
| Investigation | Status | Component | Subject |
|---|---|---|---|
| PE24019 opened Jul 2024 | closed Sep 2025 | Fuel System, Gasoline | Low-pressure fuel pump failure - led to recall 25V455 On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. |
| EA23002 opened Sep 2023 | closed Oct 2024 | Engine | Loss of Motive Power - led to recall 24V635 On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L... |
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 26V489000 | Back Over Prevention | Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. | Normally free |
| 26V104000 | Exterior Lighting | Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026... | Normally free |
| 25V729000 | Visibility | Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. | Normally free |
| 25V517000 | Exterior Lighting | Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles that were repaired incorrectly under recall 22V686. The parking lights may flicker when the headlights are activated. | Normally free |
| 25V515000 | Exterior Lighting | Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles that were repaired incorrectly under recalls 22V686 and 23V802. The parking lights may flicker when the headlights are activated. | Normally free |
| 25V455000 | Fuel System, Gasoline | Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. | Normally free |
| 25V315000 | Back Over Prevention | Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger,... | Normally free |
| 25V132000 | Electrical System | Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. | Normally free |
Show 15 more recall campaigns
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 24V852000 | Equipment | Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. | Normally free |
| 24V682000 | Exterior Lighting | Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. | Normally free |
| 24V635000 | Engine And Engine Cooling | Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. | Normally free |
| 23V896000 | Power Train | Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. | Normally free |
| 23V802000 | Exterior Lighting | Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. | Normally free |
| 23V509000 | Parking Brake | Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. | Normally free |
| 23V070000 | Power Train | Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. | Normally free |
| 22V842000 | Visibility | Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail. | Normally free |
| 22V686000 | Exterior Lighting | Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. | Normally free |
| 22V684000 | Air Bags | Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The right-side instrument panel cover may have been manufactured incorrectly, which can cause the air bag to not deploy as intended. | Normally free |
| 22V675000 | Wheels | Ford Motor Company (Ford) is recalling certain 2022 F-150 Raptor Series vehicles equipped with 37-inch tires. The lug nuts on the wheels may have been incorrectly tightened. | Normally free |
| 22V623000 | Structure | Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture. | Normally free |
| 22V253000 | Steering | Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The power-adjustable telescoping steering column connector wiring may be too short. | Normally free |
| 22V193000 | Electrical System | Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. | Normally free |
| 21V986000 | Structure | Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2026369 2026-07-28 | Visual System | 7,362 | Issue: Under certain conditions, a software problem could cause part of the rearview camera image to be blocked. Canadian regulations require the full rearview image to display while the transmission is in reverse gear. |
| 2026342 2026-07-14 | Lights And Instruments | 105 | Issue: This recall is for certain integrated trailer modules that were installed before delivery or purchased from a dealer as an aftermarket accessory. |
| 2026079 2026-02-20 | Lights And Instruments | 627,267 | Issue: On certain vehicles, a software problem with the integrated trailer module (ITRM) may cause the trailer lights not to work when towing. This problem could also cause the trailer brakes not to work on certain vehicles. |
| 2025691 2025-12-12 | Powertrain | 50,037 | Issue: On certain vehicles, a problem in the integrated park module could cause the park pawl not to engage when the transmission is shifted to the park (P) position. |
| 2025586 2025-10-24 | Lights And Instruments | 4,241 | Issue: On certain trucks, the recall repairs completed by a Ford dealer during recall 23S30 (Transport Canada recall no. 2023-340) may not have been done correctly. As a result, a second repair is required. |
Show 23 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2025587 2025-10-24 | Structure | 23,437 | Issue: On certain vehicles, the moonroof wind deflector may not have been attached properly. As a result, the deflector could detach from the vehicle. Note: This recall also affects certain Super Duty incomplete vehicles. |
| 2025415 2025-08-08 | Lights And Instruments | 197 | Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 22C22 (Transport Canada recall no. 2022-520) may not have been done correctly. As a result, a second repair is required. |
| 2025416 2025-08-08 | Lights And Instruments | 421 | Issue: On certain trucks, the recall repairs completed by a Ford dealer during recall 22C22 and 23C36 (Transport Canada recall nos. 2022-520 and 2023-638) may not have been done correctly. As a result, a third repair is required. |
| 2025366 2025-07-08 | Fuel System | 107,534 | Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, the engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. |
| 2025330 2025-06-13 | Tires | 11 | Issue: On certain F-150 Lightning (electric) models, the recall repairs completed by a Ford dealer during recall 22S45 (Transport Canada recall no. 2022-338) may not have been done correctly. As a result, a second repair is required. |
| 2025260 2025-05-09 | Visual System | 159,135 | Issue: On certain vehicles, a software problem could cause the rearview camera image not to display or to freeze when the transmission is shifted into reverse. |
| 2025106 2025-03-02 | Brakes | 10,627 | Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 22S17 (Transport Canada recall no. 2022-146) may not have been done correctly. As a result, a second repair is required. |
| 2025110 2025-03-02 | High Voltage | 216 | Issue: On certain F-150 Lightning (electric) trucks, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit. |
| 2024527 2024-09-13 | Lights And Instruments | 4,210 | Issue: On certain trucks, an unrelated over-the-air update to the body control module may have prevented the software update from recall 22C22 (Transport Canada recall no. 2022-520) from being received. |
| 2023705 2023-12-22 | Powertrain | 20,664 | Issue: On certain trucks, the rear axle hub bolt(s) could break and cause the axle shaft(s) splines to wear. If this happens, there could be a loss of power to the wheels. |
| 2023638 2023-11-29 | Lights And Instruments | 4,265 | Issue: On certain trucks, the software update completed by a Ford dealer during recall 22C22 (Transport Canada Recall 2022-520) may not have been done correctly. As a result, a second repair is required. |
| 2023639 2023-11-29 | Brakes | 1,408 | Issue: On certain F-150 Lightning (electric) trucks, a software problem could cause the electronic stability control (ESC) system not to return back to the default setting when the vehicle is started. |
| 2023405 2023-07-25 | Brakes | 171,442 | Issue: On certain trucks, the rear axle wiring harness could rub against the rear axle housing. Over time, this could cause damage to the wiring harness, and the electric parking brake could apply suddenly while driving. |
| 2023340 2023-06-09 | Lights And Instruments | 4,599 | Issue: On certain F-150 Lightning (electric) trucks, the rear lightbar could crack. If this happens, water could leak into the lightbar and cause the reverse lamps not to work, or they could flicker. |
| 2022650 2022-11-15 | Visual System | 106,044 | Issue: On certain trucks, the windshield wiper motor may fail. If this happens, the windshield wipers will not work. Safety Risk: Windshield wipers that do not work could affect a driver's visibility and increase the risk of a crash. |
| 2022520 2022-09-16 | Lights And Instruments | 20,389 | Issue: Under certain conditions, the parking lamps could flicker. As a result, the parking lights could be difficult to see. Canadian regulations require the parking lamps to stay on constantly when the headlights are turned on. |
| 2022521 2022-09-16 | Airbag | 25 | Issue: On certain trucks, a problem with the instrument panel cover may cause the passenger-front airbag not to inflate properly in a crash. |
| 2022507 2022-09-08 | Wheels | 218 | Issue: On certain F-150 Raptor models equipped with 37-inch tires, the wheel lug nuts may not have been properly tightened. As a result, the lug nuts could loosen or fall off. If this happens, a wheel could separate from the vehicle. |
| 2022461 2022-08-12 | Structure | 11,349 | Issue: On certain trucks, the insulators under the truck may have been installed in error. As a result, it could loosen and damage the driveshaft. If this happens, the driveshaft could break and cause a loss of power to the wheels. |
| 2022338 2022-06-24 | Tires | 220 | Issue: On certain F-150 Lightning (electric) models, the tire pressure monitoring system (TPMS) warning light may not turn on until the tire pressure is very low. |
| 2022279 2022-05-30 | Brakes | 1,238 | Issue: This recall is for accessory trailer brake controllers that were dealer-installed or sold as an accessory part at a Ford dealership. |
| 2022195 2022-04-14 | Airbag | 4,649 | Issue: On certain trucks, the wiring for the steering column squib may be too short. As a result, the wiring could be damaged or separate if the steering column is fully extended. |
| 2022146 2022-03-29 | Brakes | 95,896 | Issue: A software problem in the trailer brake controller could cause the trailer brakes not to apply when you brake. Note: This recall only affects vehicles equipped with the optional trailer brake controller. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| TSB 26-2408 Sep 2026 | Power Train | This bulletin supersedes 26-2309. Reason For Update: update the Model section to remove Aviator 10R80, update the Parts list to add 3.3L to W520514-S440, and add L1MZ-7Z490-G valve body separator plate for Aviator. | |
| TSB 26-2092 V2 Sep 2026 | Structure | This article supersedes TSB 25-2466 to add Bronco Sport, Escape, Maverick and Corsair, as well as removing Expedition and Navigator. One time use parts for Corsair and Bronco Sport were also added to the parts list. | |
| SYNC-26.2.8.5 F-150 Sep 2026 | SOFTWARE UPDATE | Unknown Or Other | 26C37 Recall remedy Prevents a potential rearview camera image obstruction caused by a menu displaying on top of it |
| TSB 26-2391 Sep 2026 | Electrical System | This bulletin updates 26-2206. Reason for update: update the Service Procedure to revise Steps 19-21, adding Step 22, and adding Figure 15-16 to clarify connector C316 location. | |
| TSB 26-2395 Aug 2026 | Power Train | This article supersedes 26-2287. Reason for update: update the labor operation numbers to add MT to operations C, F, G, H, J, K, L and M, and correct the part number LIMZ-4A015-B to L1MZ-4A015-B. |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| SSM 55100 Aug 2026 | Seats | For Various Ford and Lincoln vehicles, if diagnostics lead to the replacement of the front seat cushion cover J-clips, lower-level service parts are now available. | |
| SSM 55111 Aug 2026 | Fuel/Propulsion System | Some 2022-2026 F-150 Lightning vehicles may exhibit a reduced distance to empty (DTE) projection, a high voltage battery pack state of charge (SOC) that drops from 100% to less than 90% within 60 seconds of being driven, and an inability to reach a target SOC using the scheduled... | |
| SSM 55093 Aug 2026 | Structure | Some 2021-2026 F-150 vehicles may exhibit a concern of the windshield wipers not parking in the correct position on the windshield and/or over-traveling. This may be due to incorrect alignment of the wiper pivot arm on the wiper linkage assembly. | |
| SSM55059 Aug 2026 | Power Train | Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine, 2020-2026 Explorer vehicles equipped with a 3.3L hybrid engine, and 2020-2023 Lincoln Aviator vehicles equipped with a 3.0L EcoBoost hybrid engine may exhibit an illuminated powertrain malfunction (wrench)... | |
| PT-26.11.3 F-150 Jul 2026 | SOFTWARE UPDATE | Engine | 25S75 Recall remedy -Powertrain Control Module update to introduce logic to prevent low pressure fuel pump binding and maintain fuel flow to the engine. |
| SSM 55031 Jul 2026 | Electrical System | Some 2021-2026 Ford/Lincoln vehicles may exhibit various symptoms including but not limited to the auto start/stop system not operating as intended with a "Check Charging System" message in the instrument panel cluster (IPC) while the charging system is operating properly with... | |
| SSM 55028 Jul 2026 | Electrical System | Some 2021-2024 Ford and Lincoln vehicles may exhibit an "Updating SYNC" message on the vehicle center display screen after an over the air (OTA) update. | |
| SSM 55008 Jul 2026 | Unknown Or Other | Some 2021-2026 Ford vehicles may exhibit inoperative heated/cooled seats, heated steering wheel and/or front/rear defrost features after a remote start is performed through the Ford mobile application or with the key fob. | |
| TSB 26-2294 Jul 2026 | Power Train | This bulletin supersedes 26-2066. Reason for update: To remove "(2024 only)" from the Issue statement to include 2021-2025 vehicles that may exhibit a clicking sound coming from the gear shift lever. | |
| 26E04 Jul 2026 | Unknown Or Other | NEW VEHICLE DELIVERY HOLD - Emissions Recall 26E04 Certain 2021-2025 Model Year F-150, Maverick, Mustang, Ranger, Expedition, Bronco Sport, Explorer, Bronco, Navigator, and Aviator Vehicles Powertrain Control Module Software Update | |
| TSB 26-2309 Jul 2026 | Power Train | This bulletin supersedes 26-2241. Reason For Update: update the parts list to correct the claim quantity of the part number JB3Z-4B496-B from 3 to 6. | |
| TSB 26-2304 Jul 2026 | Power Train | This bulletin supersedes 25-2383. Reason for update: to add 2023-2026 F-150 2.7L vehicles. Some of the vehicles listed in the Model Statement may exhibit a vibration/shudder felt during light throttle tip in at highway speeds (8,9,10 gear) with no diagnostic trouble codes (DTC)... | |
| TSB 26-2297 Jun 2026 | Electrical System | Some of the vehicles listed in the model statement above equipped with SYNC4 may experience a blank center display screen or black center display after welcome animation. The rear-view camera will still function when shifting the vehicle to reverse under these conditions. | |
| BCMC-26.DG F-150 Jun 2026 | SOFTWARE UPDATE | Electrical System | Quality improvements include: -Addresses a false trailer brake fault message when starting the vehicle in cold weather |
| TSB 26-2287 Jun 2026 | Power Train | This article supersedes 25-2302. Reason for update: update the labor time allowance for F-150 vehicles, update the Parts list to replace the part number W716979-S439 with W721084-S439, and add a note for LV fluids XT-10-QLVC and CXT-10-LV6 "Transfer Case Fluid". | |
| SSM 54940 Jun 2026 | Service Brakes | Some 2021-2026 F-150 vehicles may exhibit a U2100:00 diagnostic trouble code (DTC) for initial configuration incomplete stored in the trailer control module (TRM). | |
| SSM 54941 Jun 2026 | Electrical System | Some 2022-2024 F-150 vehicles equipped with a perimeter alarm may exhibit a false alarm activation intermittently. This may be due to the software in the body control module (BCM). Monitor the BCM alarm event parameter identifications (PID). | |
| SYNC-26.2.8.3 F-150 Jun 2026 | SOFTWARE UPDATE | Unknown Or Other | Quality improvements include: -Privacy robustness updates -Resolves various user interface and data display bugs within the Towing menu |
| TSB 26-2264 Jun 2026 | Suspension | Some of the vehicles listed in the Model Statement above may exhibit a clunking noise from the rear suspension while turning at low speeds. This may be due to binding at the leaf spring clinch clips. | |
| ECG-26.2.11.4.1 F-150 May 2026 | SOFTWARE UPDATE | Unknown Or Other | Quality improvements include: - Enhanced system performance, disk usage limits and memory monitoring |
| TCU-26.2.11.3 F-150 May 2026 | SOFTWARE UPDATE | Electrical System | Quality improvements include: - Telematics Control Unit update to enhance connected features |
| TSB 26-2241 May 2026 | Power Train | This bulletin supersedes 25-2587. Reason For Update: update the Parts list to add the F-clutch friction plates HL3Z-7B164-D and the F-clutch steel plates PR3Z-7B164-A for the proper vehicle lines, replace the transfer case mounting bolt part number from W714288-S438 to... | |
| TSB 26-2233 May 2026 | Engine | This article supersedes TSB 26-2116 to clarify the prior approval statement. Some of the vehicles listed in the model statement above may exhibit an oil leak from the oil filter adapter to engine block mounting area. | |
| TSB 26-2238 May 2026 | Power Train | This article supersedes TSB 26-2130 to update labor operation to reprogram the PCM and check EVAP system from actual time to fixed time, and add extra time to reprogram coordinated modules (if required). | |
| SSM 54820 May 2026 | Steering | Some 2021-2023 F-150 vehicles may exhibit diagnostic trouble code (DTC) U023A:08 in the steering column control module (SCCM) after reprogramming the SCCM with no customer symptoms present. | |
| TSB 26-2226 May 2026 | Power Train | This bulletin supersedes 26-2046. Reason For Update: update the parts list to change the claim quantity of the C clutch friction plates (HL3Z-7B164-A), C clutch steel plates (HL3Z-7B442-F), D clutch steel plates (HL3Z-7B442-D), add the rear driveshaft flange CV joint-to-pinion... | |
| SSM 54795 May 2026 | Power Train | Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine and 2020-2026 Explorer vehicles equipped with a 3.3L hybrid engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0A1E stored in the powertrain control... | |
| TSB 26-2206 May 2026 | Forward Collision Avoidance | This article updates TSB 23-2146. Reason for update: clarify prior approval requirements Some of the vehicles listed in the Model statement above may exhibit diagnostic trouble codes (DTCs) C1001:31, U3000:89, and/or U3000:49 stored in the image processing module A (IPMA) and at... | |
| ITRM-26.B04 F-150 Apr 2026 | SOFTWARE UPDATE | Electrical System | 26C10 Recall remedy -Addresses instances where the trailer lights and trailer brakes may not function |
| SSM 54786 Apr 2026 | Electrical System | Some 2022-2024 F-150 vehicles may exhibit a condition where the intrusion alarm will activate without an external source. This may be due to the software in the body control module (BCM). Reprogramming or replacing the BCM may not resolve this condition. | |
| SSM 54783 Apr 2026 | Power Train | Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine and 2020-2026 Explorer vehicles equipped with a 3.3L hybrid engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0A1E stored in the powertrain control... | |
| TSB 26-2116 Apr 2026 | Engine | This article supersedes TSB 25-2323 to update the Service procedure, Parts list, and add a clarification note about Cost Cap and Prior approval process requirement for vehicles under NVLW. | |
| SSM 54719 Apr 2026 | Power Train | For 20212026 vehicles equipped with the 10R80 transmission, a new Transmission Clutch Circuit Leak Test has been introduced in the Ford Diagnosis and Repair System (FDRS). This test utilizes the pressure and vacuum transducer (PVT) when available. | |
| SSM 54720 Apr 2026 | Electrical System | Various 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). | |
| SSM 54714 Apr 2026 | Power Train | Some 2021-2026 F-150 PowerBoost vehicles may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P2884, P2885 and/or P2886 stored in the powertrain control module (PCM). | |
| SSM 54705 Mar 2026 | Unknown Or Other | Some 2021-2025 F-150 vehicles may exhibit an "Active Air Dam System Fault See Manual" warning message displayed in the instrument panel cluster (IPC) and/or an AAD hanging/not retracting. This may be due to a broken AAD actuator to air dam bolt or bolts. | |
| 24N12 S2 Mar 2026 | Engine | Certain 2021 - 2022 Model Year Various Vehicles Engine Valve Inspection Test This submission includes : Technical Instructions Updated wording and description with additional photo. | |
| TSB 26-2130 Mar 2026 | Electrical System | This article supersedes TSB 25-2246 to update the Service Procedure and add Step 2 to verify the EVAP system integrity after the coordinated software updates. | |
| TSB 25-2587 Mar 2026 | SERVICE CAMPAIGN | Power Train | Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: * Harsh 3-4, 4-5 upshifts * Harsh 5-3, 4-3 downshifts * Harsh reverse engagements These symptoms may be worse when cold. |
| SSM 54678 Mar 2026 | Engine | Some 2021-2026 F-150 vehicles equipped with a 5.0L/5.2L engine, 2021-2025 F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis vehicles equipped with a 6.8L/7.3L engine and 2021-2025 E-Series/F-650/F-750 vehicles equipped with a 7.3L engine may exhibit a rattle/scraping... | |
| SSM 54674 Mar 2026 | Power Train | For 2021-2026 vehicles equipped with the 10R80 transmission, a new Transmission Clutch Circuit Leak Test has been introduced in the Ford Diagnosis and Repair System (FDRS). This test utilizes the pressure and vacuum transducer (PVT) when available. | |
| SSM 54668 Mar 2026 | Lane Departure | Some 2021-2023 Mach-E and 2022-2024 F-150 vehicles may have customers or dealerships that wish to activate new BlueCruise features (example: Lane Change Assist). New BlueCruise features can only be activated/delivered via an over-the-air update (OTA). | |
| TSB 26-2096 Mar 2026 | Power Train | This article supersedes TSB 22-2495 to update symptoms in the TSB title and issue, and an update to labor times, changing from MT time to actual time with a limit. | |
| TSB 26-2092 Mar 2026 | Unknown Or Other | This article supersedes TSB 25-2466 to add Bronco Sport, Escape, Maverick and Corsair, as well as removing Expedition and Navigator. One time use parts for Corsair and Bronco Sport were also added to the parts list. | |
| TSB 26-2066 Feb 2026 | Power Train | This article supersedes TSB 25-2579 Reason for update: remove "Lightning" from Labor Times Description Some of the vehicles listed in the Model statement above equipped with a console GSM may exhibit at least one of the following conditions: * Clicking sound coming from the gear... | |
| TSB 26-2067 Feb 2026 | Power Train | Some of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to the software in the PCM. | |
| SSM 54601 Feb 2026 | Electrical System | Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. | |
| SSM 54592 Feb 2026 | Power Train | For 20172026 vehicles equipped with a 10R transmission, a revision to the Road Testing Vehicle procedure has been made in the WSM, located in Section 307-01 > Diagnosis and Testing. | |
| SYNC-25.1.9.7.1 F-150 Feb 2026 | SOFTWARE UPDATE | Visibility/Wiper | "25S49 Recall Remedy: -Infotainment software update to address frozen screens" |
| SSM 54585 Feb 2026 | Electrical System | Some 2021-2026 F-150 and 2024-2026 F-Super Duty vehicles equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls and/or bouncing back when using the one-touch close function.<br /> <br /> For vehicles included in Field Service... | |
| TSB 26-2046 Feb 2026 | Power Train | This bulletin supersedes TSB 25-2611. Reason For Update: Change the part number for the transmission fluid heat exchanger bolt (Expedition/Navigator) as well as change the claim/package quantities for HL3Z-7B442-F and HL3Z-7B164-C. | |
| SSM 54564 Feb 2026 | Structure | Some 2021-2026 F-150 and 2024-2026 F-Super Duty vehicles equipped with one-touch up/down front windows may exhibit a window not responding to one-touch controls and/or bouncing back when using the one-touch close function.<br /> <br /> For vehicles included in Field Service... | |
| SYNC-25.1.7.10.1 F-150 Feb 2026 | SOFTWARE UPDATE | Visibility/Wiper | "25S49 Recall Remedy: -Infotainment software update to address frozen screens" |
| SSM 54534 Jan 2026 | Electrical System | Some 2021-2025 F-150, 2022-2025 Expedition/Navigator, 2023-2025 F-Super Duty, 2024-2025 Ranger and 2026 Transit vehicles may exhibit a discharged battery and/or a no crank/no start condition. | |
| SYNC-25.2.1.6.5.2 F-150 Jan 2026 | SOFTWARE UPDATE | Electrical System | "Quality Improvements Include: - Bug Fixing and Feature improvements. - Resolves black screen issue caused when there is no SiriusXM disk space." |
Showing 60 of 476 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Run the VIN against open recalls before you negotiate.This vehicle has 23 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford F-150 →