Engine
2.5L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 200 of 200 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Power train
57 complaint records2 crash reports
"Three fuel injectors out of four have failed in a year’s time frame. Car shakes, stalls, hesitates, and is dangerous to drive. Waiting for fourth injector to fail...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Engine & cooling
54 complaint records1 crash report
"I was driving in the freeway and all of a sudden my engine power became week. I try to step accelerator but it did not cooperate...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Fuel system
33 complaint records
"Three fuel injectors out of four have failed in a year’s time frame. Car shakes, stalls, hesitates, and is dangerous to drive. Waiting for fourth injector to fail...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse fuel system parts in the directory →
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 23V181000PARK OUTSIDE | Trailer Hitches | Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original... | Normally free |
| 24V879000 | Back Over Prevention | Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. | Normally free |
| 22V746000 | Power Train | Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. | Normally free |
| 22V197000 | Engine And Engine Cooling | Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe and Santa Cruz vehicles. The oil supply pipe to the turbocharger may crack, which could result in an oil leak in the engine compartment. | Normally free |
| 21V524000 | Fuel System, Gasoline | Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2025636 2025-11-17 | Other | 332,486 | Issue : Hyundai Auto Canada is conducting an extended warranty campaign for certain vehicles as water could enter the horn assembly and cause the horn's electrical contacts to corrode. As a result, the horn may not work properly or at all. |
| 2024709 2024-11-20 | Visual System | 48,509 | Issue: On certain vehicles, the rearview camera may not have been manufactured properly. Over time, the camera could fail and cause the rearview camera image not to display. |
| 2024552 2024-09-23 | Label | 824,695 | Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus",... |
| 2023147 2023-03-17 | Electrical | 1,897 | Issue: Certain vehicles may be equipped with a 4-pin accessory trailer wiring harness kit that could fail. Over time, this could result in a short circuit that can cause the control module to overheat. |
| 2023016 2023-01-23 | Fuel System | 54 | Issue: On certain plug-in hybrid (PHEV) models, a defect in the fuel tank could cause it to leak at the seam. Safety Risk: A fuel leak can create the risk of a fire. |
Show 5 more Canadian recalls
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2022727 2022-12-16 | Electrical | 3,705 | Issue: Certain vehicles may have a programming error. As a result, the vehicles don't meet some of the anti-theft requirements in Canadian regulations. Safety Risk: A vehicle theft could create a safety risk. |
| 2022623 2022-10-31 | Seats And Restraints | 4,787 | Issue: On certain vehicles, there may be a problem with the driver and front passenger seat belt pretensioners. As a result, the seat belt pretensioners could explode in a crash. |
| 2022568 2022-10-06 | Powertrain | 9,427 | Issue: On certain vehicles, a fault in the transmission oil pump can cause the vehicle to enter "fail-safe mode". When this happens, a programming error can cause a sudden loss of power to the wheels after 20-30 seconds. |
| 2021792 2021-12-27 | Lights And Instruments | 300 | Issue: On certain vehicles, the instrument panel may show an inverted image when you start the vehicle in extremely cold temperatures. |
| 2021426 2021-07-09 | Fuel System | 2,285 | Issue: On certain vehicles, the connection between the high-pressure fuel pipe and fuel pump may not be properly sealed. As a result, a fuel leak could occur. Safety Risk: A fuel leak can create the risk of a fire. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 26-BE-001H-1 DN Feb 2026 | WARRANTY EXTENSION | Unknown Or Other | Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery... |
| 26-BE-001H-1 TSB Feb 2026 | WARRANTY EXTENSION | Unknown Or Other | Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery... |
| 26-BE-001H-1 DCS Feb 2026 | WARRANTY EXTENSION | Unknown Or Other | Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery... |
| Z09 OL Mar 2026 | WARRANTY EXTENSION | Unknown Or Other | Certain 2021 – 2023 model year Santa Fe, 2021 – 2023 model year Santa Fe Hybrid, and 2022 – 2023 model year Santa Fe Plug-In Hybrid vehicles may experience an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. |
| 26-BE-001H-2 TSB Sep 2026 | WARRANTY EXTENSION | Electrical System | Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery... |
| 26-BE-001H-2 DCS Sep 2026 | WARRANTY EXTENSION | Electrical System | Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery... |
Show 54 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 26-AT-005H TSB Jun 2026 | Power Train | This bulletin provides information related to a Transmission Control Unit (TCU) software update for some vehicles equipped with an 8-speed wet dual clutch transmission (8WDCT). | |
| 26-EE-003H TSB Apr 2026 | Engine | Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly. | |
| DTN DCS Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. | |
| DTN DL Apr 2026 | Air Bags | The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). | |
| 26-AT-001H TSB Mar 2026 | Power Train | Some Santa Cruz (NXT), Santa Fe (TMA, MX5A), and Sonata (DN8A) models may require replacement of the 8-speed wet dual clutch transmission (8WDCT) when the vehicle sets one of the high pressure electric oil pump (HP EOP) DTCs listed below. | |
| 26-AT-002H Feb 2026 | Power Train | Some Santa Fe (TMA) and Tucson (NX4A) vehicles equipped with a 2.5L GDI engine and 8 speed automatic transmission may have DTC U028700 (Lost Communication With Trans Fluid Pump Module) set by the transmission Electric Oil Pump (EOP). | |
| 26-EM-005H TSB Feb 2026 | Engine | Some Santa Fe (TMA) vehicles may have DTCs P218100, P2181F0, and/or P2181F1 (Cooling System Performance) set in the Electronic Control Unit (ECU), resulting in an illuminated Check Engine warning lamp. | |
| 26-FL-001H TSB Jan 2026 | Fuel/Propulsion System | Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI fuel injectors leaking internally. This may be caused by internal filter breakage in the injector. | |
| P33 OL Dec 2025 | Electrical System | In response to this trend, we engineered a software upgrade that addresses the social media theft method and made it available to owners of eligible models free of charge at authorized Hyundai dealers since early 2023. | |
| 25-01-089H TSB Dec 2025 | Electrical System | This bulletin provides the service procedure for installation of a key cylinder reinforcement protector assembly and two anti-theft decals on the front windows. | |
| 25-01-089H DN Dec 2025 | Electrical System | In addition to the Anti-Theft software provided under Service Campaign 993 (TSB 24-01-009H-1), a zinc reinforced ignition cylinder protector hardware upgrade is being made available to customers upon request. | |
| 25-01-089H DCS Dec 2025 | Electrical System | Upon customer's request ONLY, the Technical Service Bulletin (TSB) 25-01-089H provides the service procedure for installation of a key cylinder reinforcement protector assembly and two anti-theft decals on the front windows. | |
| 25-BD-012H TSB Nov 2025 | Exterior Lighting | This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. | |
| 25-BE-020H TSB Sep 2025 | Electrical System | This bulletin provides information related to the changes introduced in the 2025 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system as described in this TSB. | |
| 25-01-045H TSB Jul 2025 | SERVICE CAMPAIGN | Electrical System | A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system. |
| 25-AT-001H TSB May 2025 | Power Train | Certain Santa Fe (TMA) and Sonata (DN8/DN8A) vehicles equipped with 8-speed dual clutch transmissions (8DCT) may exhibit one of the DTCs listed below, related to the high pressure electric oil pump (HP EOP). | |
| 25-BE-002H TSB May 2025 | Electrical System | This bulletin provides information related to the changes introduced in the 2024 2nd Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. | |
| 25-01-024H-1 TSB May 2025 | SERVICE CAMPAIGN | Electrical System | Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon’s communication network. |
| 25-FL-001H Jan 2025 | Fuel/Propulsion System | Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI injectors leaking internally. This may be caused by internal filter breakage in the injector. | |
| 24-FL-004H Dec 2024 | Engine | This bulletin provides the procedure to update the Engine Control Module (ECM) and the Transmission Control Module (TCM) for 2021-2023MY Santa Fe (TMa) vehicles to improve operation of the Idle Stop and Go (ISG) system. | |
| 24-01-045H-2 Sep 2024 | SERVICE CAMPAIGN | Electrical System | A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system. |
| 24-01-045H-1 Aug 2024 | SERVICE CAMPAIGN | Electrical System | A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system. |
| 24-EM-001H Jul 2024 | Engine | Certain 20-22MY Sonata (DN8a), 21-23MY Santa Fe (TMa), and 22-23MY Tucson (NX4a) vehicles may experience a warning lamp illumination for a diagnostic trouble code P2181 that is related to the Integrated Thermal Management Module (ITM). | |
| 24-01-045H Jun 2024 | Electrical System | A software update is available for multiple vehicles equipped with either Display Audio 2.0V or the AVN 5th Gen Wide system. | |
| 24-01-009H-1 May 2024 | SERVICE CAMPAIGN | Electrical System | A class settlement against Hyundai Motor America (“HMA”) that had alleged that certain 2011 – 2022 model year Hyundai vehicles that were not equipped with an engine immobilizer (called the “Class Vehicles”) contain design flaws, including the failure to manufacture the Class... |
| 24-AT-001H Feb 2024 | Power Train | This bulletin provides the procedure for updating the automatic transmission TCU and ECU software (Santa Fe ONLY) to improve shift quality, judder with ISG enabled and hesitation when accelerating. | |
| 24-BD-001H Feb 2024 | Visibility/Wiper | This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side... | |
| 24-01-009H Feb 2024 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of... | |
| 23-01-014H-6 Jan 2024 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of... | |
| 23-01-014H-6 Dec 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), and anti-theft ignition cylinder protector campaign (Campaign 9A5) in response to an increase in thefts of... | |
| 23-01-014H-6 Nov 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine... | |
| 23-AT-006H-2 Nov 2023 | Power Train | This TSB provides information to diagnose the push button shifter operation. | |
| 23-BR-004H Nov 2023 | Service Brakes | Certain Tucson (NX4A), Santa Cruz (NXT), Santa Fe (TMA), and Santa Fe Hybrid (TMA HEV) vehicles may exhibit a brake judder condition. This bulletin describes the procedure to inspect the brakes, resurface or replace and perform a brake burnishing procedure. | |
| 23-01-014H-5 Oct 2023 | Electrical System | Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine... | |
| 23-EM-005H Oct 2023 | Engine And Engine Cooling | This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. | |
| 23-AT-008H-1 Sep 2023 | Power Train | If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. | |
| 23-AT-014H Aug 2023 | Power Train | The Shift-By-Wire (SBW) buttons have been made available as separate service parts for the SBW lever. If replacement of the SBW button is required due to one or more button plating peeling, replace the button(s) with a new one. Do not replace the complete SBW lever. | |
| 23-AT-012H Aug 2023 | Power Train | This bulletin provides information related to a Transmission Control Unit (TCU) software update for certain vehicles equipped with an 8-speed wet dual clutch transmissions (8WDCT) that improves the touch point learning variation. | |
| 23-AT-011H Aug 2023 | Power Train | This bulletin outlines changes to the service procedure regarding the replacement of 8-speed wet dual clutch transmissions (8WDCT) and associated transmission control unit (TCU). These changes only apply to vehicles equipped with Theta 2.5T engines. | |
| 23-AT-003H-1 Aug 2023 | Power Train | If you are servicing an 8-speed vehicle with a âCheck Engineâ light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness. | |
| 23-BE-010H Aug 2023 | Electrical System | Some models from service campaign 993 (IBU/BCM Software Update and Decals Application) equipped with the Hyundai OEM remote start system may exhibit the horn honking when remote starting the vehicle after receiving the software update. | |
| 23-AT-006H-1 Aug 2023 | Power Train | This TSB provides information to diagnose the push button shifter operation. If you are servicing a vehicle with any symptoms listed below or DTCs (listed on Page 2) , follow the Service Procedure on Page 3. | |
| 23-AT-009H Jul 2023 | Electrical System | If you are servicing an 8-speed DCT front-wheel-drive vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. | |
| 23-BE-007H Jul 2023 | Equipment | This Service Information bulletin provides information on how to update the Apple Carplay software from Hyundaiâs Navigation Updates page. The current version of Google Maps has 10 times the data transmission compared to the previous version. | |
| 23-AT-008H Jul 2023 | Power Train | If you are servicing an 8-speed front-wheel-drive vehicle equipped with automatic transaxle with one or more of the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. | |
| 23-01-014H-5 Jul 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-FL-002H-1 Jun 2023 | Engine And Engine Cooling | This bulletin provides the diagnostic procedure for the GDI injector(s) in certain 21-23MY Sonata, 21-22MY Santa Fe, certain 22MY Santa Cruz, and certain 21-23MY Tucson equipped with 2.5L GDI engines with one or more misfire DTC(s) due to internally leaking GDI injector(s) | |
| 23-01-014H-5 Jun 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-01-046H Jun 2023 | Engine And Engine Cooling | This bulletin provides the procedure to update the ECU and TCU software to correct the ROM ID and TCU software to optimize shift quality when accelerating. | |
| 23-01-036H-1 Jun 2023 | Parking Brake | Some Elantra (CN7A), Sonata (DN8A) and Santa Fe (TMA) vehicles may exhibit the Electronic Parking Brake (EPB) warning light on due to brake fluid entering the HECU electrical connector. DTC C1501 (EPB Switch Failure) may be present, but EPB performance remains unaffected. | |
| 23-01-046H May 2023 | Power Train | Certain 2022MY Santa Fe (TMa) 2.5L vehicles equipped with an 8-speed transmission will require an update to the ECU and TCU software to correct the ROM IDs and TCU software to optimize shift quality when accelerating. | |
| 23-01-014H-4 May 2023 | Electrical System | Certain Hyundai vehicles may not be equipped with an immobilizer. This bulletin provides the service procedure to update the IBU/BCM (Integrated Body Control Unit/Body Control Module), to revise the OEM Hyundai burglar alarm system operation and ignition start logic, and... | |
| 23-AT-002H May 2023 | Power Train | This bulletin provides service procedures to prevent possible moisture intrusion of the HP EOP (High Flow Electric Oil Pump) connector when servicing the 8-speed wet dual clutch transmission (8WDCT). | |
| 23-AT-004H May 2023 | Power Train | This TSB applies only if Recall 236 or Service Campaign T8N has been performed and the 8 speed wet dual clutch transmission (8WDCT) replacement is necessary related due to high pressure electric oil pump (HP EOP) DTCâs P1C2D03 (HP EOP Motor Position Sensor), P193B79 - HP EOP... |
Showing 60 of 86 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Smell for fuel and watch the first restart when hot.Hard starting when warm, hesitation under load, or any fuel odor near the tank or engine bay match this vehicle's fuel-system cluster. Check the recall table for fuel pump campaigns.
- Run the VIN against open recalls before you negotiate.This vehicle has 5 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask the dealer whether the warranty extension on file still applies to this VIN.The manufacturer issued 6 warranty extensions for this vehicle (see the service bulletins section). Extended coverage often runs by years or miles from the original sale, and a repair the seller paid for may have been free.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Hyundai Santa Fe →