Engine
2.4L 4-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 102 of 102 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Body & structure
42 complaint records
"The front passenger door handle does not open the door. Door must be opened from the outside only. Part is on back order..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse body & structure parts in the directory →
Power train
20 complaint records
"Vehicle recalled, left at Dealership on October 10th 2025. Dealership and Toyota corporate have failed to rectify the recall...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Steering
10 complaint records
"The vehicle is unstable and easy to lose control! The vehicle height is asymmetrical! The vehicle body shakes! The tires are abnormally worn! The geometry deviation of the vehicle's rear axle is too large..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse steering parts in the directory →
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 26V514000 | Suspension | Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 Tacoma Hybrid and 2024-2025 Tacoma vehicles. | Normally free |
| 26V179000 | Equipment | Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Toyota Tundra, Tacoma Hybrid, Tacoma, RAV4 Hybrid, Land Cruiser Hybrid, Lexus GX550, 2024-2026 Tundra Hybrid, 2025 Sequoia Hybrid, Crown... | Normally free |
| 25V656000 | Power Train | Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2025 Tacoma and Tacoma Hybrid vehicles. The front driveshaft constant-velocity (CV) joint may deform and break. | Normally free |
| 25V595000 | Electrical System | Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025... | Normally free |
| 25V058000 | Service Brakes, Hydraulic | Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Tacoma 4-wheel drive vehicles. The rear brake hoses can be damaged if mud and dirt builds up inside the rear wheels. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2025521 2025-10-01 | Powertrain | 362 | Issue: On certain trucks, the front axle shaft(s) may not have been manufactured properly. As a result, the axle shaft(s) could break and prevent you from fully turning the steering wheel. |
| 2025363 2025-07-07 | Brakes | 11,086 | Issue: Under certain conditions, the rear brake hoses could become damaged. Over time, the brake hoses could fail and cause a brake fluid leak. If this happens, there could be reduced braking. |
| 2025051 2025-02-06 | Brakes | 5,149 | This recall was replaced by Transport Canada recall no. 2025-363. Issue: Under certain conditions, the rear brake hoses could become damaged. Over time, the brake hoses could fail and cause a brake fluid leak. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| T-TT-0755-24 Apr 2026 | Structure | The condition is for vehicles equipped with an accessory Power Port or Tire Inflator. During the installation process of the Power Port or Tire Inflator, the pre-wire connector is removed from the dummy cap (which is attached to the harness) and is left attached when power is... | |
| T-SB-0016-26 Feb 2026 | Electrical System | Some 2024 – 2026 model year Tacoma vehicles may exhibit a “chirp” noise from the HVAC magnetic clutch upon engagement. | |
| T-SB-0055-24 Rev2 Jan 2026 | Unknown Or Other | Some 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. | |
| T-SB-0093-25 Dec 2025 | Structure | Some 2024 – 2025 model year 4WD Tacoma and Tacoma Hybrid vehicles may exhibit a condition where the 4WD lights are flashing and a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs) present: •P277111 – Four Wheel Drive (4WD) Low Switch Circuit... | |
| T-SB-0058-23 Rev1 Jun 2025 | SERVICE CAMPAIGN | Electrical System | The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. The procedures outlined in this Service Bulletin aid in locating, inspecting, and repairing refrigerant leaks. |
Show 25 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| T-TT-0779-25 Apr 2025 | Electrical System | To assist with the early detection and early resolution of audio related concerns you may be asked to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by FTS and/or FPE. | |
| T-SB-0013-24 Rev1 Feb 2025 | Electrical System | The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Another feature, Add/Remove Key, is also available. | |
| T-SB-0021-25 Feb 2025 | Engine | Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. | |
| T-SB-0015-25 Jan 2025 | Electrical System | Some 2021 – 2025 model year Toyota vehicles may require the download and installation of vehicle specific software or configuration software when the Electronic Control Unit (ECU) is replaced. GTS+ software has been modified to indicate when configuration software is required. | |
| T-SB-0016-25 Jan 2025 | Structure | Some 2024 – 2025 model year Tacoma and Tacoma Hybrid vehicles equipped with an accessory roof rack may exhibit an abnormal vibration from the accessory roof rack while driving. New roof rack bumpers have been developed to address this vibration. | |
| T-SB-0013-25 Jan 2025 | Unknown Or Other | Long-term or off-site storage requires special care to maintain vehicle condition. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage conditions. | |
| T-SB-0011-25 Jan 2025 | Electrical System | When certain vehicle ECUs are replaced, the ECU Security Key must be written in order for that ECU to communicate on the vehicle network. The GTS+ Software Health Check Results screen has been enhanced to help identify if a replacement ECU requires an ECU Security Key. | |
| T-SB-0104-23 Dec 2024 | Wheels | TSB: During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. | |
| T-SB-0035-24 Rev2 Dec 2024 | Structure | Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. | |
| T-SB-0038-24 Rev2 Dec 2024 | Structure | To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. | |
| T-SB-0039-24 Rev2 Dec 2024 | Structure | The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. | |
| T-SB-0004-24 Rev2 Dec 2024 | Unknown Or Other | 2025 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. | |
| T-SB-0104-23 Rev2 Dec 2024 | Unknown Or Other | During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. | |
| T-SB-0061-23 Rev2 Dec 2024 | Structure | Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. | |
| T-SB-0113-24 Dec 2024 | Unknown Or Other | Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: •Careful inspection for paint chips/scratches and body dents/dings. | |
| T-SB-0062-23 Rev2 Dec 2024 | Structure | Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. | |
| T-SB-0021-24 Rev2 Nov 2024 | Unknown Or Other | A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. | |
| T-SB-0023-24 Rev1 Jun 2024 | Unknown Or Other | Long-term or off-site storage requires special care to maintain vehicle condition. The following guidelines should be performed to minimize vehicle component / part degradation due to extended vehicle storage conditions. | |
| T-SB-0104-23 Rev1 Jun 2024 | Unknown Or Other | During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. | |
| T-SB-0004-24 Rev1 Jun 2024 | Unknown Or Other | 2025 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. | |
| T-SB-0021-24 Rev1 Jun 2024 | Unknown Or Other | A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. | |
| T-SB-0021-24 Apr 2024 | Unknown Or Other | A battery in a stored vehicle is subject to conditions that can reduce its performance and service life. These conditions include storage period, temperature, parasitic drain, and battery load. | |
| T-SB-0023-24 Apr 2024 | Unknown Or Other | Long-term or off-site storage requires special care to maintain vehicle condition. The following guidelines should be performed to minimize vehicle component / part degradation due to extended vehicle storage conditions. | |
| T-PANT-2024-004- Mar 2024 | Engine And Engine Cooling | This is to advise of various price adjustments that will affect Toyota Genuine Motor Oil and Long Life Coolant, effective March 1, 2024. These products are ordered through the Toyota Complete Maintenance Care (TCMC) website. | |
| T-SB-0004-24 Feb 2024 | Equipment | TSB: 2025 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Walk the body slowly in daylight.Panel gaps, rust at the rockers and wheel arches, and cracked trim are this vehicle's structure complaints. Open and close the liftgate or trunk and look at the latch area.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Drive one straight highway stretch and one slow parking lot.Wander or a shimmy over bumps at speed, and heavy or dropped assist at low speed, are the two faces of this vehicle's steering cluster. A clunk on turn-in points at the linkage.
- Run the VIN against open recalls before you negotiate.This vehicle has 5 recall campaigns on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Toyota Tacoma →