Engine
4.6L 8-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 81 of 106 complaints with a usable failure date.
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Lighting
84 complaint records2 crash reports
"HEADLIGHTS ARE NOT BRIGHT ENOUGH FOR NIGHT DRIVING, CONSUMER HAS TO USE HIGH BEAMS. PROBLEM HAS WORSEN OVER TIME.*AK *YD..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse lighting parts in the directory →
Speed control
7 complaint records1 fire report
"PRODUCT RECALL = -SPEED CONTROL. AUG. 2007. DEALER DISCONNECTED IN 2007-NOT REPLACED...CAR NOW W/NO OVERDERIVE/SPEED CONTROL = WASTES GAS. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse speed control parts in the directory →
Power train
5 complaint records
"WHILE STANDING STILL IN TRAFFIC VEHICLE SLOWLY DRIFTED BACKWARDS WHILE IN DRIVE GEAR. THIS OCCURRED WITH NO PRIOR WARNING AND EXPLANATION. THE BRAKE WAS APPLIED DURING THIS OCCURRENCE. *AK...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse power train parts in the directory →
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 07V336000 | Vehicle Speed Control | ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2007258 2007-08-07 | Electrical | 165,447 | On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The failure mode appears to be different than that of Recall 2005028 (05S28). |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 03181 Sep 2003 | Electrical System | REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT | |
| 03148 Jul 2003 | Power Train | NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT | |
| 03261 Jan 2003 | Power Train | NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT | |
| 02208 Oct 2002 | Equipment | CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH | |
| 02176 Sep 2002 | Exterior Lighting | LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
Show 55 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| 02107 May 2002 | Visibility | TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT | |
| 01246 Dec 2001 | Engine And Engine Cooling | ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT | |
| 01181 Sep 2001 | Power Train | BRAKE SHIFT INTERLOCK.*JB | |
| 01156 Aug 2001 | Visibility | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC | |
| 01157 Aug 2001 | Unknown Or Other | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC | |
| 0147 Mar 2001 | Engine And Engine Cooling | SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT | |
| 0015 Jan 2000 | Power Train | INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS | |
| 99222 Oct 1999 | Electrical System | SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT | |
| 99194 Sep 1999 | Service Brakes | INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT | |
| 99195 Sep 1999 | Equipment | SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT | |
| 99196 Sep 1999 | Equipment | INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT | |
| 7002 Sep 1999 | Steering | STEERING- POOR RETURNABILITY- HIGH EFFORT. *MJS | |
| 13190 Sep 1999 | Steering | INFORMATION REGARDING STEERING- POOR RETURNABILITY-HIGH EFFORT. *MJS | |
| 99152 Jul 1999 | Power Train | INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT | |
| 99139 Jun 1999 | Exterior Lighting | CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT | |
| 99111 Jun 1999 | Unknown Or Other | INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT | |
| 991210 Jun 1999 | Unknown Or Other | FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT | |
| 9996 May 1999 | Power Train | EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT | |
| 99816 May 1999 | Engine And Engine Cooling | FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT | |
| 99-8-15 May 1999 | Structure | SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT | |
| 9943 Mar 1999 | Power Train | INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT | |
| 98246 Dec 1998 | Electrical System | FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC | |
| 5203 Dec 1998 | Vehicle Speed Control | SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT | |
| 12217 Dec 1998 | Service Brakes | THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT | |
| 982310 Nov 1998 | Engine And Engine Cooling | MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK | |
| 98216 Nov 1998 | Steering | A STEERING WHEEL MOVEMENT FELT WHEN DRIVING OVER ROUGH SURFACES. | |
| 12174 Nov 1998 | Engine And Engine Cooling | SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS | |
| 9883 Apr 1998 | Steering | A CONDITION WITH STEERING NIBBLE FELT IN THE STEERING WHEEL WHEN DRIVING ON ROUGH ROADS SUCH AS GROOVED PAVEMENT ON SOME VEHICLES. *TT | |
| 9887 Apr 1998 | Power Train | EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC | |
| 9888 Apr 1998 | Power Train | INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC | |
| 9852 Apr 1998 | Tires | INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC | |
| 9874 Apr 1998 | Engine And Engine Cooling | A NEW SILICONE GASKET AND SEALANT. *YC | |
| 982731 Apr 1998 | Electrical System | EXHIBITING A CUSTOMER CONCERN OF MIL ON AND DTCS OF 214 OR P0340. IF NORMAL DIAGNOSTICS FAILS TO RESOLVE THESE DTC'S AND CAMSHAFTPOSITION SENSOR HAS BEEN REPLACED, THOROUGHLY INSPECT THE WIRING AT THE CAMP HARD-SHELL FOR BROKEN OR FRAYED WIRING. *AK | |
| 985A5 Mar 1998 | Service Brakes | HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC | |
| 985A11 Mar 1998 | Service Brakes | SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC | |
| 985A13 Mar 1998 | Service Brakes | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC | |
| 985A6 Mar 1998 | Service Brakes | SOME VEHICLES MAY CYCLE WHEN BRAKES ARE APPLIED ON ROUGH ROADS OR ON AN INCLINE WHILE MAKING A SHARP TURN. *YC | |
| 9845 Mar 1998 | Service Brakes | AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC | |
| 9814 Jan 1998 | Service Brakes | SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT | |
| 97111097234 Nov 1997 | Electrical System | VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC | |
| 97090297184 Sep 1997 | Equipment | SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC | |
| BC2300970501 May 1997 | Suspension | AIR SUSPENSION FRONT HEIGHT SENSOR BALL STUD BREAKAGE. *TW | |
| BC105769705 May 1997 | Suspension | AIR SUSPENSION FRONT HEIGHT SENSOR BALL STUD BREAKAGE. *TW | |
| 9768 Mar 1997 | Unknown Or Other | FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD | |
| 97610 Mar 1997 | Engine And Engine Cooling | BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD | |
| 9751 Mar 1997 | Seats | INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD | |
| 9754 Mar 1997 | Suspension | SUSPENSION- FRONT- HEIGHT SENSOR UPPER MOUNT- SERVICE TIP. *JD | |
| 97511 Mar 1997 | Power Train | FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD | |
| BC3272970207 Feb 1997 | Electrical System | VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW | |
| BC3274970207 Feb 1997 | Exterior Lighting | REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS AND CAN RESULT IN ACTUATION OF THE SHOR... | |
| BC3288970206 Feb 1997 | Engine And Engine Cooling | VEHICLES MAY EXHIBIT A COLD START ENGINE FEAD BELT CHIRP NOISE. *TW | |
| 9735 Feb 1997 | Equipment | AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD | |
| BC0310972301 Jan 1997 | Unknown Or Other | SERVICE PROCEDURES FOR 4.6L 4V ENGINES. *JD | |
| BC1025097230 Jan 1997 | Electrical System | PASSIVE ANTI-THEFT SYSTEM. *JD | |
| BC0310970201 Jan 1997 | Engine And Engine Cooling | SERVICE PROCEDURES FOR 4.6L 4V ENGINES. *JD |
Showing 60 of 73 distinct bulletins on file for this vehicle.
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Do a full walk-around with every light on.Condensation inside a lens, a dim side, or a flickering tail light match this vehicle's lighting cluster.
- Test the throttle response and the cruise control on an open road.A surge, a hang in engine speed after lifting off, or cruise that will not set or cancel cleanly are the speed-control complaints on this vehicle.
- Drive it from a dead stop, twice, on a hill if you can.Shudder, hesitation, or a lurch under light throttle is how this vehicle's largest complaint cluster shows itself. Then ask for the transmission service history in writing; repeat repairs are a pattern, not a fluke.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Lincoln Mark Viii →