Engine
3.5L 6-cyl
How to read this file. Complaint records are unverified owner submissions to the federal safety agency. Counts are raw, not adjusted for sales volume or vehicle age. Recall campaigns apply to the model; only a VIN check shows whether this car is affected or repaired. Parts shown are named by an editorial note or listed as a search directory; none is a diagnosis. Full methodology.
Fault profile
Complaint-component records on this vehicle, grouped by family. A complaint naming two systems counts once in each.
Complaints are owner-reported and not verified by the agency.
When it fails
The timing of this vehicle's reported failures, from the complaint file itself. A cluster tells you what to expect and when; it is shaped by reporting behavior as well as by the vehicle.
Vehicle age when the failure occurred
Years between the model year and the owner's reported failure date. Based on 180 of 181 complaints with a usable failure date.
Odometer when the failure occurred
Owner-reported mileage at failure, in 20,000-mile bands. Based on 143 of 181 complaints reporting a plausible odometer (500 to 500,000 miles; unverified).
Known issues
The component families with the most complaint records against this vehicle. Counts, crash and fire figures belong to the whole family, not to any single named issue. Parts listed are related system parts, not a diagnosis.
Engine & cooling
53 complaint records2 fire reports
"CAR STALLED AT LOW SPEED. STARTED AGAIN WHEN STOPPED AND IN PARK. DURING EVENT, NO POWER STEERING / BRAKES AVAILABLE. NOT A SAFE CONDITION...."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse engine & cooling parts in the directory →
Electrical system
32 complaint records1 fire report
"09 FORD FLEX. COMING UP ON A TURN AND MY CAR SHUTS OFF. I ROLLED TO THE CORNER PUT IT IN PARK AND RESTARTED THE CAR. THIS IS THE SECOND TIME SINCE I'VE HAD THE THIS CAR THAT IT SHUT OFF. THANK GOODNESS NO ONE IS HURT. MY CAR IS AT THE DEALERSHIP AS I TYPE. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse electrical system parts in the directory →
Brakes
32 complaint records4 crash reports
"AT MY LAST SERVICE AT MY DEALERSHIP, I WAS INFORMED THAT MY REAR BRAKES WERE WORN OUT AND NEEDED REPLACING WHILE MY FRONT BRAKES WERE STILL IN GOOD CONDITION. *TR..."- one owner's federal complaint about this system; it may not describe the issue named above
Parts
No specific part is named for this issue. Browse brakes parts in the directory →
Recall campaigns
Safety-recall remedies are normally provided at no charge. Under US federal law the mandatory free remedy applies when the vehicle was no more than 15 years old at the time the defect was determined; manufacturers often cover older vehicles voluntarily. Canadian rules differ. Confirm eligibility with the manufacturer using the VIN. Each campaign number links to the federal record.
| Campaign | Component | Summary | Remedy |
|---|---|---|---|
| 16V247000 | Air Bags | Ford Motor Company (Ford) is recalling certain model year 2009-2012 Ford Flex, 2008 and 2010-2012 Ford Taurus, 2008-2009 Ford Taurus X, 2008 Mercury Sable, 2009 and 2011 Lincoln MKS vehicles. | Normally free |
Transport Canada recalls
Recalls issued under Canadian law for this model year, from Transport Canada's Vehicle Recalls Database. Matched by model name, so a Canadian-market variant may appear here that was sold under another name in the US. Units are Canadian vehicles affected.
| Recall | System | Units (CA) | Summary |
|---|---|---|---|
| 2019281 2019-06-11 | Suspension | 12,211 | Issue: On certain vehicles, a buildup of dirt and mud could cause the rear suspension toe links to break. This could result in a sudden loss of vehicle stability. |
Service bulletins and warranty extensions
Manufacturer communications to dealers on file with the federal agency: repair instructions, service campaigns, and warranty extensions. A warranty extension means the manufacturer may pay for a repair the recall table does not cover.
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| SSM 54601 Feb 2026 | Electrical System | Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. | |
| SSM 52476 Apr 2024 | Equipment | All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. | |
| SSM 51536 Apr 2023 | Structure | For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. | |
| RFI20210317_810- Mar 2021 | Suspension | This SKU is a Control Arm. The customer communication requested return of unsold inventory to inspect the bushing orientation. If the bushing orientation is incorrect, it will prevent installation of the product. If the problem is not corrected, the product will be unusable. | |
| SSM 48070 Jul 2019 | Electrical System | Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. |
Show 16 more bulletins
| Bulletin | Type | Component | Summary |
|---|---|---|---|
| SSM 47797 Feb 2019 | Equipment | Some 2009-2017 Expedition/Navigator, 2009-2014 F-150/Mustang, 2008-2009 Sable, 2008-2019 Taurus/Flex/MKT, 2013-2019 Police Interceptor Sedan/Utility, and 2011-2019 Explorer vehicles may exhibit inoperative or intermittent HVAC blower motor function at various fan speed settings. | |
| SSM 47230 Apr 2018 | Equipment | Some 2007-2016 Edge/MKX/Flex/MKT/MKZ/MKS/Taurus/Police Interceptor Sedan/Explorer/Police Interceptor Utility vehicles equipped with AWD and built on or before 30-Jun-2016 may exhibit a propane or natural gas odor during idle or low speed driving. | |
| SSM 47201 Mar 2018 | Equipment | Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. | |
| SSM 47009 Jan 2018 | Equipment | The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). | |
| SSM 46412 Feb 2017 | Power Train | SOME 2007-2016 EDGE/MKX/FLEX/MKT/MKZ/MKS/TAURUS/TAURUS POLICE/EXPLORER/EXPLORER POLICE EQUIPPED WITH ALL WHEEL DRIVE (AWD) AND BUILT ON OR BEFORE 30-JUN-2016 MAY EXHIBIT A TICKING AND/OR KNOCKING NOISE COMING FROM THE DRIVELINE AREA. | |
| SSM 46332 Jan 2017 | Equipment | REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR LINCOLN VEHICLE. | |
| SSM 46132 Oct 2016 | Service Brakes | SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. | |
| SSM 46085 Sep 2016 | Engine And Engine Cooling | The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. | |
| TSB-14-0198 Oct 2014 | Engine And Engine Cooling | FORD: WITH AUXILIARY CLIMATE CONTROL SYSTEM ON, CAN SMELL AN EXHAUST ODOR IN VEHICLE. LIKE SULFUR, AFTER HARD DRIVING CONDITIONS OR ACCELERATION. MODEL 2009-14 FLEX. *PE. UPDATE. 06/11/15. *TA | |
| ASI-44531 May 2014 | Seats | LINCOLN/FORD: ON SOME VEHICLES AND TRUCKS, THERE IS A POPPING, SQUEALING, BINDING OR GRINDING NOISE COME FROM POWER SEATS WHEN MOVING BACKWARDS OR FORWARD. MODEL 2009-2015 F-150, TAURUS, FLEX, MKT, MKS, F-SUPER DUTY, EXPLORER. *PE | |
| TSB-13-5-27 May 2013 | Power Train | FORD/LINCOLN: ON SOME VEHICLES, TRANSMISSION 5TH GEAR START AT STOP, SPEED CONTROL DROPS OR INOPERATIVE, BACKUP CAMERA ON IN DRIVE, 5TH GEAR START FROM STOP AND TRANSMISSION SLIPPING OR NEUTRAL OUT, DUE TO DIGITAL TRANSMISSION RANGE (TR) SENSOR HIGH RESISTANCE. | |
| TSB-11-5-6 May 2011 | Power Train | FORD: THERE MAY BE A SLUGGISH ACCELERATION OR HESITATION FEELING WHEN ROLLING TO A STOP. THIS WILL BE FOLLOWED BY A HARSH BUMP. *RM | |
| SIS-21841 Apr 2011 | Air Bags | COMM-TRANS LUND: SOME 2009-2011 MODELS MAY HAVE THE AIR BAG INICATOR FLASHING WITH A STORED TROUBLE CODE. THIS IS A SOFTWARE PROBLEM. *RM | |
| AS-21769 Mar 2011 | Electrical System | FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM | |
| TSB-10-16-1 Aug 2010 | Engine And Engine Cooling | FORD: THERE MAY BE A ROUGH IDLE OR MISSES WHILE THE MALFUNCTION LIGHT IS ON. THERE ARE MUTLIPLE POSSIBLE TROUBLE CODES STORED. *RM | |
| TSB-09-20-9 Apr 2010 | Seats | FORD: SOME VEHICLES EQUIPPED WITH POWER FOLDING SECOND ROW SEATS MAY FIND THE SEAT NOT FULLY LIFTING AND FOLDING FORWARD (TUMBLE) AFTER THE POWER RELEASE SWITCH IS DEPRESSED. *PE |
Before you buy this vehicle
A test-drive checklist generated from this vehicle's own complaint and recall record.
- Cold-start it yourself and listen for the first thirty seconds.Knocking, ticking that fades as it warms, or blue or white smoke on startup are the sounds of this vehicle's engine cluster. Check the oil level and the coolant color, and ask whether the engine or its head gaskets have ever been out.
- Sit in it with the engine off and test everything that has a switch.Windows, locks, lights, the cluster, the radio. Electrical faults are this vehicle's story and the hardest to see on a drive: an intermittent no-start waits for the second week of ownership. Ask for the battery's age and whether any control module has been replaced.
- Brake hard once from speed on an empty road.A pull to one side, a pulsing pedal, a pedal that sinks at a stop, or an ABS light that stays lit are the brake complaints on this vehicle presenting themselves.
- Run the VIN against open recalls before you negotiate.This vehicle has 1 recall campaign on file. An open recall needs VIN-specific confirmation. Many are quick, no-charge fixes and worth negotiating over; an unresolved do-not-drive advisory, or a remedy the manufacturer has not yet made available, should stop the purchase until it is resolved.
- Ask for the service history in writing, then read it against this page.The complaint families above are where owners of this vehicle report trouble. Repairs in exactly those systems are evidence the car had the problem; no such repairs could mean it never developed it, or that it was never fixed. The test-drive items above are how you tell those apart.
Parts search directory
The generic parts list for this vehicle has its own page: a search launcher for every system, filtered by fuel type and era but not by engine, trim, or brake type. It is not a diagnosis and not a fitment guarantee.
Open the parts directory for this Ford Flex →